Professional Documents
Culture Documents
Click to edit Master subtitle style Mariy Muslih M. 111910101026 M. Dahlas Dzuhro 111910101030 Naufal Firas 111910101036 Henry Wicaksana 111910101040 Yohannes C. 111910101025
5/24/12
THERMOPLASTIC
Thermoplastic polymer is a polymer which have propertie that it doesnt keep against hot. If this polymer get heated, then it will be soft and if we continue to cooling this polymer it will be hard. The molecule structure is linear or branched not linked.
5/24/12
TERMOPLASTIK
Polimer
termoplastik adalah polimer yang mempunyai sifat tidak tahan terhadap panas.Jika polimer jenis ini dipanaskan, maka akan menjadi lunak dan didinginkan akan mengeras. Struktur molekulnya linier atau bercabang, bukan jaringan.
5/24/12
THERMOPLASTIC PROPERTIES
Small
Doesnt If If
get heated it will be soft get cooled it will be hard melting point or it can be recycle
5/24/12
Flexible Low
Reform-able
Sifat-sifat Thermoplastik
Berat Tidak Jika Jika
Mudah
Fleksibel. Titik
Dapat
Polyethylene (PE)
Polyethylene
is a material that is include one of thermoplastic polymer. If this polyethylene get radiated, it will be cross connection.
5/24/12
Polyethylene (PE)
Polietilen
adalah suatu bahan yang termasuk dalam golongan polimer termoplastik. Jika polietilen diradiasi akan terjadi pembentukan ikatan silang.
5/24/12
5/24/12
5/24/12
slight delay.
Pressure phase, Cooling phase.
5/24/12
5/24/12
is desirable to have highest possible filling speed (Injection Rate) duringfilling phase. phase covers85 to 98%of totalinjection stroke. speed filling is terminated atSwitch-over pointand low 5/24/12
Filling
High
Due
to relaxation of compression (1015%) of melt during injection stroke, melt expands and fills up remaining empty space in the mould. after the melt has to be cooled further, below heat defection temperature of material. This would prevent deformation of moulding during ejection. 5/24/12
There
Urutan Proses
Sangat
diharapkan untukmemiliki kecepatanpengisiantertinggi(Ting katInjection) selama fillingfase. 85sampai 98%strokeinjeksitotal. tinggidiakhiri di Switch-over point dan 5/24/12 kecepatanfaseTekanan
Mengisifasemencakup
Pengisiankecepatan
Karenarelaksasikompresi(10-15%)
setelahmelelehharusdidinginkan lebih lanjut,di bawah titik leleh 5/24/12 material.Hal ini akan mencegah
5/24/12
5/24/12
5/24/12
Video
5/24/12
Thank you
5/24/12