Professional Documents
Culture Documents
Introduction
In this project we show our shoe in front of our
designed machine then that machine start polishing
our shoes automatically by just rotating shoe brush.
Here we use ac motor with both side shafts. In these
shafts we integrated shoe brushes.
This ac motor connected with IR sensor along with
a relay.
When show shoe then IR sensor becomes active
which on the relay.
When relay on motor start rotating shoe polish
work starts for 30 second then motor will stop
automatically.
BLOCK DIAGRAM
Hardware requirements
ARDUINO UNO
5V RELAY MODULE
IR SENSOR
AC MOTOR WITH BOTH SHAFT
DIODES
CAPACITOR
RESISTOR
LED
MECHANICAL STRUCURE
12V 1AMP TRANSFORMER
7805 VOLTAGE REGULATOR
BC547
POLISH LIQUID
Diode
Diode
Diode definition:-
Diode is an electronic device with two Blocking Reverse Current
transmitting terminals that allows electric
current to flow in one direction while
blocking current in the opposite direction.
Resistors
Resistor
Definition of Resistor
“A resistor is an electrical component that limits or regulates
the flow of electrical current in an electronic circuit.”
11. Capacitor
7805
IR Sensor
Infrared
Sensor
IR Receiver
1/ High /5v
IR Transmitter
0/ Low/ 0v
Arduino Basic Board
Input voltage : 5-12v