Professional Documents
Culture Documents
www.huawei.com
GE fiber cable
2G 3G 4G-TDD 4G-FDD
2G 3G 4G-TDD 4G-FDD
Once enter the system view ,the bracket NE Name changed successful
becomes [ ]
Command Lines:
<ZBR058_ATN_NE1> sys #To enter system view
[ZBR058_ATN_NE1] undo dcn #To disable dcn
Y #To confirm the configuration
As packets from BTS/NodeB includes VLAN ID, all the ATN Site ID
VLAN ID
VLAN ID (3G) VLAN ID (4G) VLAN ID (OaM)
(2G)
ports should configured as Trunk to pass through those
ZBR058 1322 1323 1324 1325
VLAN IDs.
Use the VLAN design according to the right side table.
ATN910i ATN910i
Trunk port means the port which can allow more than 1 VLAN ID;
All ATN ports should be configured as TRUNK;
Configure the interface0/2/10 for Trunk as below (for example):
Command Lines:
interface Gigabit Ethernet 0/2/X #To enter the required port
Undo shutdown #To enable this port
Portswitch #To configure this port as layer2
port link-type trunk #To configure this port as trunk
Port trunk allow-pass vlan xxxx xxxx #Configure the vlans which
need be allowed on this port ,
separate different vlans by space.
RTN310-NE1 NE4
GNE
XPIC E-LAG
E-LAG XPIC
GE0/2/5 GE0/2/4
ATN910i ATN910i
To run this save command , you should under the <HUAWEI> view, if your are under system-view
[HUAWEI] , please use quit command quit system-view.
As 0/2/8 and 0/2/9 configured as access, you can just connect the lap top to this 2 ports to
do CWO test for 2G and 3G.
0/2/10 is configured as trunk, the message come to these ports must be tagged with vlan.
So If your laptop is vlan-supported, you can just configure the required vlan to your lanport,
and do the CWO test for 4G.
If your laptop is not vlan-supported, you can configure the 0/2/11(last one) which is spared
as access , and assign the 4G vlan on it to do CWO test.