You are on page 1of 67

Huawei UMTS900M Refarming

Deployment Strategy and RNP

HUAWEI TECHNOLOGIES CO., LTD.


Agenda
UMTS900 Deployment Strategy
Huawei Refarming Solution
2G Traffic Transfer Strategy
GSM900 Frequency re-plan and performance
Inter-RAT Operation Solution
Antenna Solution
UMTS Refarming Application
Why Refarming? Demands from Data Growth

Data services offset the Coverage No 3G service in rural area


falls of voice revenue and Requirement Coverage gap between 2.1GHz and 900MHz
becomes the key driver to
growth
Voice ARPU falls in 4 countries Service Poor or No data service in rural area
Requirement (inc. fixed data access)

Capacity
2.1GHz spectrum insufficient for 3G capacity
Requirement

UMTS grows as GSM turns down


Cost
TCO (UMTS 900MHz) << TCO (UMTS 2.1GHz)
Requirement

Evolution partial 900MHz frequencies spared as GSM subscribers


Requirement moving to UMTS gradually

HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential Page 4


Refarming Get Better Network on Lower Cost
Radio planning U900 vs. U2100: about 6dB better link budget in U900, Cell Coverage of U90
0 2.5~3 times larger than U2100
Radio planning U900 vs. G900: Link budget +6-9dB, Better receiver sensitivity
Capacity planning: Co-site for higher capacity sharing, 50% fewer sites with U900 than U2100

Cell Coverage Comparison

HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential Page 5


Feasibility Analysis of UMTS900 Refarming

Deployment Strategy and RNP


Spectrum Technical Voice Cost
Availability Feasibility Migration Affordability
Challenges
& Solution

Configurable Band frequency allocation Migration of existing co-site


width of UMTS carrier GSM traffic co-antenna
GU adjacent TFR Solution co-cabinet
More Valuable frequency Evolution from2G to co-accessories
spectrum left to GSM interference impact 3G co-transmission
retained
Inter-RAT Operation
Industry

Industry Maturity ( Product and terminal industry)


Chain

License Permission on UMTS900

HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential Page 6


Huawei, Major Contributor to Refarming Industry
Pioneer for technical trials
- Orange, France
- Proximus, Belguim

Phase 1
- Globe, Bulgaria, etc.
1st verify Buffer Zone theory
1st test in-build U900 performance
1st verify negligent impact to G900
Trial

Leader in commercialization
- Optus, Australia
- SFR, France
- VDF, Romania Deployment
- Teliasonera, Finland
Phase 2

- AIS, Thailand, etc.


1st Tighter Frequency Reuse
1st Single-RAN refarming
1st antenna sharing
Phase 3

1st to deploy G/U SDR850MHz and SDR900MHz


1st to deploy U900 on 4.2MHz Bandwidth Enhancement
1st to deploy Tighter Frequency Reuse

HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential Page 7


Typical Deployment Strategy for Refarming

Extend 3G Coverage Improve 3G Coverage Initial 3G Roll-out


In in In
Sub-urban & Rural Urban area All areas

No UMTS service coverage yet Indoor coverage is not good No 3G service yet anywhere
voice traffic is low, easy to Blind spots in dense urban No 2.1Ghz spectrum
release frequencies for UMTS Frequent handover between UMTS Sufficient 900Mhz spectrum for networ
Poor or No fixed broadband 2.1Ghz and GSM 900Mhz due to k-wide refarming
coverage quality difference

U900

U2100

HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential Page 8


Typical UMTS900 Deployment Scenarios

Extend 3G Coverage
in
Suburban & Rural

Network character
No UMTS coverage yet
low voice traffic, easy to release
frequencies for UMTS
Poor or no data service

RNP Focus on
Coverage Requirement
Service Requirement
Cost Requirement

UMTS2100 for Urban coverage


UMTS900 refarming for Suburban and Rural coverage

HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential Page 9


Typical UMTS900 Deployment Scenarios

Improve 3G Coverage
in
Urban
Urban area
area

Network character
Indoor coverage not good
Blind spots in Dense Urban
Capacity supplementary for
UMTS 2.1GHz

RNP Focus on:


Coverage Requirement
Capacity Requirement

UMTS2100 for Urban coverage


UMTS900 refarming for urban coverage and capacity

HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential Page 10


Typical UMTS900 Deployment Scenarios
Initial 3G Roll-out
in
All
All areas
areas

Network character
No 3G service yet anywhere
No 2.1GHz spectrum
Sufficient 900MHz spectrum for
network-wide refarming

RNP Focus on
Coverage Requirement
Cost Requirement

U2100 is mainly covered in the urban and core towns


Refarming the GSM900 all over the network

HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential Page 11


Agenda
UMTS900 Deployment Strategy
Huawei Refarming Solution
2G Traffic Transfer Strategy
GSM900 Frequency re-plan and performance
Inter-RAT Operation Solution
Co-Antenna Solution
UMTS Refarming Application
Flexible Huawei UMTS Refarming Solution
Configurable Bandwidth of UMTS carrier

Flexible Between 4.2MHz and 5MHz from RAN Release12.0


with 0.1MHz steps for both downlink and uplink
Efficiently suitable for 850,900,1700,1800 and 1900MHz frequency
UU4.2M solution two adjacent 4.2M UMTS carriers is ready from SRAN releas3.0
3.8MHz solution can be designed for a network
according to actual conditions.
guard

More valuable spectrum left to GSM use

UMTS
GSM GSM

HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential Page 13


Flexible Huawei UMTS Refarming Solution

Sandwich frequency solution Sandwich frequency solution


Sandwich allocation flexibly puts U900 carrier i
nto the proper spectrum location based on the
UU solution and interference consideration with
other operators.

Edge allocation solution


Edge allocation solution has lower frequency uti
lization since the more frequency guard bandwi Edge frequency solution
dth shall be reserved to avoid the risk.
Min. frequency gap (f1): 2.2MHz separation
Min. frequency gap (f2): 2.6MHz between
UMTS900 and the GSM900 of neighbour
operator

Sandwich frequency solution is preferred

HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential Page 14


Huawei Refarming Solution highlights

4.2MHz for UMTS Tighter Frequency Reuse


16% Up to 44% less spectrum bandwidth
less spectrum bandwidth
needed for UMTS 1 2 needed for GSM

Reuse of Legacies
Refarming Sandwich & Buffer Zone
Guarantee better coverage 6 3
Maximize value of investment Solutions No Negative Impact to GSM

5 4 2G Traffic Transfer Strategy


SingleRAN/ SDR
Coverage/Load/Service Intersyst
Easy to maintenance
em Balance
Improve 2G/3G performance Reduce CS block rate
Improve data throughput

HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential Page 15


UMTS 900 Refarming RNP Procedure

Start

UMTS900 frequency allocation Strategy Refarming key points:


Interference Analysis among
2G capacity Migration and G900 UMTS900 & other Systems
frequency re-plan
Capacity Analysis to meet both
GSM & UMTS traffic requirement
UMTS900 Dimension and Plan
GSM900 Frequency Planning

Inter-RAT Operation design Inter-RAT Operation Solution


between GSM900 & UMTS900

GU antenna solution

End

HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential Page 16


Agenda
UMTS900 Deployment Strategy
Huawei Refarming Solution
2G Traffic Transfer Strategy
GSM900 Frequency re-plan and performance
Inter-RAT Operation Solution
Antenna Solution
UMTS Refarming Application
2G Traffic Transfer Procedure
Y
Reduce
Reducethe
the
A: A>B
A:Existing
Existing A>B
Configuration
Configuration
Configured
Configuredcapacity
capacity

User B:
B:Traffic
Userincreasing
increasing Traffic
prediction requirement
requirement
prediction
2G
2GTraffic
Traffictransfer
transfer

Frequency
Frequencybandwidth
bandwidth G900->G1800 G900->U900
G900->U900
After G900->G1800
AfterRefarming
Refarming

Required
RequiredFrequency
Frequency
reuse
reuseDensity
Density N Y Final
Meet
MeetRequired
Required FinalG900
G900site
site
frequency configuration
G900
G900TFR
TFR frequencyreuse
reuse configuration
density
density

HUAWEI Confidential Page 18


2G traffic migration Strategy-1 G900->G1800)
Scenarios
GSM 1800M is available and continuously covered;
GSM 900M GSM 900M GSM 900M GSM 1800M has rich frequency;
G900 and G1800 are deployed with Co-site

Migration Strategy
Active HR, raise its proportion configured up to
50%~70%
GSM1800 GSM1800 GSM1800
Transfer traffic from G900 to G1800 by add site configuration
depend on the required frequency reuse factor from 9~12
Increase 1800M sites co-sited with G900

Traffic sharing Strategy


Camp on G1800 and G900 randomly in the idle state,
Better cell handover
UE prefers to make the cell selection to G1800.
Load balance handover
Allow intra-frequency better cell handover;
Coverage edge handover
Load handover is performed according to the traffic

HUAWEI Confidential Page 19


2G traffic migration Strategy-2 G900->U900)
Scenarios
GSM 900M GSM 900M U900 is continuously covered;
GSM 900M
There is no 1800 spectrum
G900 and U900 are deployed with co-site
Migration Strategy
Active automatically the U900 service for all the existing 2G users
Dual-mode terminal and 3G rate policies appeal to the transferred 2G user
Voice traffic shared on UMTS900 shall be dimensioned, and the experience shall be good.
Transfer traffic from G900 to UMTS900 with the above preconditions.
UMTS 900M UMTS 900M UMTS 900M
Traffic sharing Strategy
Terminal camp on UMTS as long as it support G/U dual-mode
Dual-mode UE camp on GSM in no UMTS coverage area
Voice calls remain in individual RAT cells
PS service on dual-mode UE shall perform Cell Reselection or HO if it enter into UMTS coverage area

Better cell handover

Load balance handover

Coverage edge handover

HUAWEI Confidential Page 20


UMTS Dimension Consideration
U2100 is continuously covered;
UMTS Voice Capacity Comparison
U900 is also continuously covered;
Suggested Strategy:

U900 R99 F2 F2 Randomly Camping


+HSPA With loading Balancing

U2100R9 F1 F1
9+HSPA

U900 is continuously covered;


U2100 is NOT continuously
covered;
Suggested Strategy:
U2100R99 F2
Force to camp on F1,
+HSPA
With service delaminating

U900 F1 F1
R99+HSP
A

HUAWEI Confidential Page 21


2G traffic migration Strategy-3 (G900 TFR)
Scenarios
GSM 900M GSM 900M GSM 900M There is no 1800 spectrum
The U900 service for the existing 2G users needs
special application
2G users will to migration is very low for the tough
Dual-mode terminal and 3G rate policies.
UMTS 900M UMTS 900M UMTS 900M

Migration Strategy
Active HR, raise its proportion configured up to
50%~70% to reduce the existing G900 configuration
Better cell handover
Maintain the existing G900 configuration with the less
Load balance handover frequency
Coverage edge handover
The quality will deduce and Huawei TFR( tight frequency
reuse) solution will slower the trend

HUAWEI Confidential Page 22


Tighter Frequency Reuse solution for G900 capacity

Huawei TFR solution Case 4.8MHz Frequency Available


study:
Bandwidth :4.8MHz@900M( 63~86) S4/4/4
after reframing S4/3/3
S3/3/
BCCH layer : 63~76, TCH S2/2/2 2
layer:77~86 Industry FR LOAD 50% FR LOAD 70% FR LOAD 90%
IBCA Enhanced ICC
AMR penetration:90%
Anti- DTX UISS (w/o GPS) Enhanced UISS
Capacity target:: traffic increase Interference Power control ICC/EICC IBCA
10%, HR 50%, Site Configuration shall TFO AMR AMR
tech.
be S444 SD
E-ICC Spatial-Temporal Interference UL Rx call
Assign
ment
Hand
over
assig SDC
SDCC
H
TCH
Site DL Rx Qaul n CH Blocki
feature Qaul drop succe succ Block
Cancellation Combining Type (0-4)
(0-4) rate ss
rate
ess
rate
succ
ess
drop
rate
ing
rate
ng
rate
rate
UISS Um Interface Software Synchron DTX/PC/AM 94.00 98.00 95.50 97.00 1.00
S222 93.50% 1.20% 0.35% 1.50%
R % % % % %
ization DTX/PC/AM
94.00 97.70 94.80 96.55 1.15
S332 R /EICC/TFO 93.50% 1.50% 0.40% 1.00%
IBCA Interference Based Channel All /UISS+IBCA
% % % % %

ocation S444
DTX/PC/AM
R /EICC/TFO 90.50%
91.00
2.00%
96.20 93.00 95.00 1.70
0.80% 1.00%
% % % % %
/UISS+IBCA

HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential Page 23


Agenda
UMTS900 Deployment Strategy
Huawei Refarming Solution
2G Traffic Transfer Strategy
GSM900 Frequency re-plan and performance
Inter-RAT Operation Solution
Antenna Solution
UMTS Refarming Application
Interference Type Between GSM and UMTS

How to calculated the interference


ACIR represents the interference between GSM900 and
UMTS900

Main interference introduce


UMTS NodeB to GSM UE interference
GSM UE to UMTS NodeB interference
UMTS UE to GSM BTS interference
GSM BTS to UMTS UE interference

How to minimize the interference


Carrier separation minimize interference caused by adjacent carrier between GSM900 and UMTS900;
Isolation distance minimize interference caused by same frequency between GSM900 and UMTS900.

HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential Page 25


GU Network Level Performance loss from GU adjacent frequency

2.2MHz

GU900 Co-Site
Urban: ISD=750m
Rural: ISD=7500m GSM UMTS GSM
4.2MHz
4x3 frequency reuse for BCCHs, and 4x3 for TCHs
GU Frequency GSM Voice Call Drop EDGE DL Throughput UMTS HSDPA UMTS DL R99 Capacity UMTS HSUPA UMTS UL Coverage Loss
Gap increase Loss Throughput Loss Loss (voice Sub.) Throughput Loss (Cell Radius)
Urban Rural Urban Rural Urban Rural Urban Rural Urban Rural Urban Rural

2.2MHz 0.00% 0.00% 0.00% 0.00% 0.83% 0.48% 0.43% 0.63% 0.89% 0.86% 1.63% 0.79%
2.4MHz 0.00% 0.00% 0.00% 0.00% 0.29% 0.14% 0.21% 0.52% 0.13% 0.15% 0.00% 0.00%
2.6MHz 0.00% 0.00% 0.00% 0.00% 0.00% 0.00% 0.02% 0.04% 0.04% 0.05% 0.00% 0.00%

4x3 frequency reuse for BCCHs, and 1x3 for TCHs


GU Frequency GSM Voice Call Drop EDGE DL Throughput UMTS HSDPA UMTS DL R99 Capacity UMTS HSUPA UMTS UL Coverage
Gap increase Loss Throughput Loss Loss (voice Sub.) Throughput Loss Loss (Cell Radius)
Urban Rural Urban Rural Urban Rural Urban Rural Urban Rural Urban Rural

2.2MHz 0.00% 0.00% 0.00% 0.00% 2.48% 1.39% 1.28% 1.89% 2.66% 2.68% 5.01% 3.80%
2.4MHz 0.00% 0.00% 0.00% 0.00% 0.86% 0.43% 0.21% 0.52% 0.38% 0.46% 0.00% 0.00%
2.6MHz 0.00% 0.00% 0.00% 0.00% 0.00% 0.00% 0.02% 0.04% 0.13% 0.16% 0.00% 0.00%

HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential Page 26


Cell Level Performance loss from GU adjacent frequency

2.2MHz

GU900 Co-Site
Urban: ISD=750m
Rural: ISD=7500m GSM UMTS GSM
4.2MHz

The worst performance of worst cells are shown as follows:


GU Frequency GSM Voice Call Drop EDGE DL Throughput UMTS HSDPA UMTS DL R99 UMTS HSUPA UMTS UL Coverage
Gap increase Loss Throughput Loss Capacity Loss (voice Throughput Loss Loss (Cell Radius)
Sub.)

Urban Rural Urban Rural Urban Rural Urban Rural Urban Rural Urban Rural

2.2MHz 0.00% 0.00% 0.22% 0.00% 4.86% 4.70% 3.85% 5.68% 6.84% 6.65% 7.71% 5.31%
2.4MHz 0.00% 0.00% 0.00% 0.00% 2.58% 2.50% 1.62% 4.32% 0.76% 0.89% 0.90% 0.69%
2.6MHz 0.00% 0.00% 0.00% 0.00% 0.00% 0.00% 0.09% 0.10% 0.38% 0.49% 0.65% 0.64%

HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential Page 27


Adjacent frequencies plan consideration for G900
2.6MHz frequency guard bandwidth between BCCH
and UMTS is recommended. Frequency hopping, DTX & power control
PDCH assign to adjacent carriers enabled for TCH in adjacent carriers

adjacent
channels
GSM
carrier x y

Both adjacent frequencies in the sandwich


Adjacent carrier will be assigned to the U
schedule shall be not assigned in a cell.
nderlay of Concentric Cell
Overlay

Underlay

HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential Page 28


Buffer Zone: GU co-frequency interference guard

HUAWEI buffer zone solution to solve the interference when UMTS900 sites and GSM900 sites
are assigned the same frequency , but in different regions

A GSM sites A area is corresponding to GSM


coverage.
GSM900
B area is the frequency isolation
B Buffer zone area, the frequencies of G900 is
different from both A and C area
GSM900 GSM900
UMTS sites C area is corresponding to UMTS
coverage.
C

GSM900 UMTS900 GSM900

Proposal for buffer zone plan:


Buffer zone distance is commonly 2~3 layer sites or the distance of twice cell diameter,
Spectrum allocation
RF optimization or obstructed topography will deduce the size of buffer zone
The co-frequency interference signal received in the A or C shall below -110dBm

HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential Page 29


Buffer Zone Case Study
Basic Info
CASE: Optus, Australia Buffer zone locates at the edge of urban
area
UMTS900 Cell0 ISD: 5.5km
Buffer Zone

GSM900 (Cell 2)
GSM900 Cell2

GSM900 (Cell 1) GSM900(Cell 1)


GSM900 Cell1

GSM900 GSM900
UMTS900 (Cell 0)

Achievement for Buffer Zone UE -> Node B Impact Node B -> UE Impact

UL interference reduces 2.1 RTWP Rise (dB) UE Interference Rise (dB)


dB Buffer Zone (one site) 0.1 0.3
DL interference reduces 2.2 3.2
No Buffer Zone
about 3dB

HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential Page 30


Buffer zone Impact to Performance of GU sites
GSM MS C/I distribution compare UMTS UE Ec/Io distribution compare
GSM topology mode:4X3;
UMTS cell radius: 4Km;
GSM topology mode:4X3;

G900 Sites U900 Sites

One layer
Isolation
zone

The impact between Base Station and UE can be ignored with 2~3 layer isolation zone.

HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential Page 31


Case Study: 10MHz Spectrum for Refarming

Example: Spectrum Assignment in 900MHz

V Operator
Operator C Operator B

10MHz

How to perform GSM and UMTS refarming?

HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential Page 32


Case Study: Assignment of GSM TRX and UMTS Carrier

V operator
Operator C Operator B

10MHz

4.6MHz

4.6MHz bandwidth allocated for UMTS900


5.4MHz spectrum available for GSM900

Sandwich Solution recommended.


No interference to neighboring operators.

UMTS GSM

HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential Page 33


Case Study: Frequency Planning for VF Italy
Operator C 50 channels Operator B
V operator

1 channel 10 channels 23 channels 1 channel


15 channels

TCH BCCH TCH UMTS900 TCH

U900 BCCH

min. 2 CHs min. 1 CH min. 2 CHs

Minimum 1 CH (200kHz) between UMTS900 and BCCH.

2 CHs (1 TCH + 1 guard CH) between BCCH of V operator and UMTS900 of Operator C.

2 CHs (1 TCH + 1 guard CH) between UMTS of V operator and BCCH of Operator B.

GSM frequency planning: SFH to spread the interference in the network.


15 channels for BCCH, 1 SFH group for all TCH, i.e. MA={CH1, CH2, CH3, , CH12}.

Frequency Planning: 1+2+2+SFH

HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential Page 34


Agenda
UMTS900 Deployment Strategy
Huawei Refarming Solution
2G Traffic Transfer Strategy
GSM900 Frequency re-plan and performance
Inter-RAT Operation Solution
Antenna Solution
UMTS Refarming Application
Inter-RAT Operation Strategy 1
--U900 for Rural coverage and U2100 for Urban coverage
UMTS2100-UMTS900 inter-freq UMTS2100 intra-freq soft
Coverage zone HSPA hard handover handover
/R99

UMTS900 intra-freq soft


handover
UMTS2100

UMTS900

GSM900 GSM900

UMTS900/GSM inter-RAT
handover

Suburban & rural Urban Hot Spot & Dense


Urban

HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential Page 36


Inter-RAT Operation Strategy 2
--U900 for continuous coverage and U2100 for hot area capacity expansion
UMTS
UMTS
900
900 UMTS UMTS
Uni-directional blind Handover UMTS 2100 2100 UMTS
from UMTS 2100 cell to 900 UMTS 900
UMTS
UMTS900 cell based on load Users camp on UMTS 2100 layer UMTS 900
900
to establish R99 + HSDPA servic 900 UMTS
es 2100

UMTS 2100 Cell The first phase of UMTS900 deployment wil


Uni-directional Handover from l be mainly for coverage continuity and U
UMTS 2100 cell to UMTS900 cell MTS2100 absorb load in hot spot areas.
based on coverage

UMTS 900 Cell UMTS 900 UMTS 900 Cell


Cell

Uni-directional blind Handover All UMTS layers provide R99+HSPA serv


Continuous UMTS layer for ice
from UMTS 900 cell to GSM900
coverage Users camp on 2100 layer when availabl
cell based on load
e
According to the cell load the call wi
GSM Cell GSM Cell GSM Cell
ll be established in 2100 layer or re-
directed to 900 layer.

HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential Page 37


Mobility Management:
Roaming strategy between GSM and UMTS
3G subscribers configured to camp on
3G subscribers configured to camp on
WCDMA network with the higher priority by
WCDMA network with the higher priority by
choosing the UTRAN ACCESS
choosing the UTRAN ACCESS UMTSGSM GSMUMTS
TECHNOLOGY in the USIM file
TECHNOLOGY in the USIM file cell reselection PLMN or cell reselection

WCDMA WCDMA

GSM

Cell reselection from UMTS to GSM networks


via Inter-system Cell Reselection : No upgrade for GSM networks
Cell reselection from GSM to UMTS networks
via Inter-system Cell Reselection: GSM BSS need to be upgraded to support SI2quater
via PLMN/Access Technology Reselection: No upgrade for GSM networks

HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential Page 38


Mobility Management:
Inter-RAT handover between GSM and UMTS

Camping on UMTS in idle Staying in 2G during the Call ends, Cell Reselection to
CS Handover to 2G 3G
mode call
Services

Service begins

Packet
Services
Cell Reselection or cell Cell Reselection
Cell Reselection
Change Order to GPRS to GPRS
UMTS cell to UMTS
GSM/GPRS cell

Unidirectional handover from UMTS to GSM is proposed for CS services.

Bidirectional handover between UMTS and GSM by cell reselection is proposed for PS services

Note: No upgrade of GSM network for handover from 3G to 2G

HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential Page 39


Summary for GU Mobility Startegy
Idle Mode RRC setup RAB setup Connected

SHO UMTS2100

RRC DRD

RRC R-Dir

RAB DRD

IFHO

LDR
DRD to GSM
Cell Re-selection

RRC R-Dir

RAB DRD

Inter-RAT HO
LDR
UMTS900
SHO

GSM

Full flexibility for Traffic Management

HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential Page 40


Agenda
UMTS900 Deployment Strategy
Huawei Refarming Solution
2G Traffic Transfer Strategy
GSM900 Frequency re-plan and performance
Inter-RAT Operation Solution
Antenna Solution
UMTS Refarming Application
Contents of Antenna Solution

Case 1: Antenna Solution with Huawei SDR Product


One Antenna is needed to support GSM and UMTS simultaneously.

Case 2: Sharing Existing GSM900 Antenna


Co-antenna with SASU
Co-antenna with 3dB combiner

Case 3: Independent Antenna for U900

HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential Page 42


Case 1: Huawei SDR Product RRU3908
RRU3908 Solution (1 RRU = GSM900 + UMTS900 modes)

now GSM900 GU900

UMTS 900
UMTS900 Rollout
Switch on
GSM900
RRU3908

SDR
swap

Add UMTS Card

BBU3900 BBU3900
GSM900 G+U 900

GSM900 Modernization
UMTS900 Switch on
With SDR Module

Multi mode (GSM/UMTS) supported simultaneously in one module.


The specifications of RRU3908 are fully Compliant with ETSI.

HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential Page 43


Case 1: Huawei SDR Product MRFU
MRFU Solution (1 MRFU = GSM900 + UMTS900 mode)

now GSM900 GU900

UMTS 900
UMTS900 Rollout
Switch on
GSM900 BTS3900
U U U
G G G
New-add: 3G M M M
/ / /
M M M T T T
R R R 900M + 2G U U U
S S S
swap F F F 900M
U U U
Add MRFU modules
Existing: 3G
2100M

GSM900 G+U 900

GSM900 Modernization
UMTS900 Switch on
With SDR Module

Max. 2*80W output power in one MRFU module Software upgrade to UMTS900
6 Carriers for GSM only, 4 Carriers for UMTS only
For dual mode: UMTS 1C + GSM 1~5C, UMTS 2C + GSM 1~4C

HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential Page 44


Case 1: Huawei SDR Product MRFU
MRFU Solution (1 MRFU = GSM900 or UMTS900 mode)
S R
now GSM900
g M
GU900
r t in
po
up
UMTS 900
UMTS900 Rollout

GSM900 BTS3900
ot s Switch on

s n
tr ie
n
M M M M M M M M M

swap
ou R R R R R R R R R

nc
F F F F F F F F F
U U U U U U U U U
Add MRFU modules

pe a
E uro
m e
o
Fo rS GSM900 G+U 900

GSM900 Modernization
UMTS900 Switch on
With SDR Module

Max. 2*80W output power in one MRFU module Software upgrade to UMTS900
8 Carriers for GSM only, 8 Carriers for UMTS only

HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential Page 45


Case 1: Antenna solution with Huawei SDR Product
900MHz antenna

1 Separate Antenna Solution difficult


easy

Separate tilt & azimuth tuning for network optimization


High cost for adding new antennas & feeders

Optimization
Slow deployment for additional engineering

Engineering
No change for antenna and
feeder system
2 Co-feeder, co-antenna Solution

Fast deployment for easy engineering


Low cost for sharing the legacy devices
High difficulty for network optimization
GSM900
GSM900 + difficult easy
UMTS900
UMTS900

M M M M M M
R R R R R R Multi mode (GSM/UMTS) supported
F F F F F F
U U U U U U GSM900
GSM900 ++
UMTS900
simultaneously in one module.
UMTS900
Only one antenna is needed to support GSM and
UMTS.

BTS3900 DBS3900

HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential Page 46


Case 2 Sharing Existing GSM900 Antenna

GSM TX UMTS TX GSM TX UMTS TX


GSM&UMTS GSM&UMTS RXD GSM&UMTS RXM GSM&UMTS RXD
RXM

SASU
3dB 3dB

SASA

TX/RXM TX/RXM RXD


TX/RXD

GSM900
GSM900 UMTS900
UMTS900

Co-antenna with Co-antenna with


SASU and SASA 3dB combiner

HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential Page 47


SASU: Same band Antenna Sharing Unit

Install on the wall Install on the pole


SASU Characteristic:
Solution for the shared antenna between GSM and UMTS system or betwe
en two UMTS systems on the same band.
6-port unit for antenna & feeder, 1 Tx port for GSM & UMTS respectively
SASU Advantage:
No extra loss in the uplink
Maximum 0.6dB insertion loss in the downlink
No impact on frequency planning for GSM & UMTS

HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential Page 48


Huawei SASU for GU900 Co-antenna Solution

SASU
(Same band Antenna Sharing Unit)
Install on the pole
Install on the wall SASU Advantages
SASU Characteristic No extra loss in the uplink
6-port unit for antenna & feeder Maximum 0.6dB insertion loss in the downlink
sharing between GSM900 and UMTS900 No impact on frequency planning for GSM & UMTS
1 Tx port for GSM & UMTS respectively

HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential Page 49


SASA: Same band Antenna Sharing Adapter

Principles of the SASA

SASA:
Combine the TX carriers on two antennas into
the carriers on one antenna,
No affecting the performance of the existing
GSM network.
GSM_M
GSM_D

HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential Page 50


SASU Solution Helps to Retain GSM Coverage
Best Co-Antenna Solution for Overlap Mode

Traditional Combiner SASU Solution


Disadvantage of Combiner
New sites needed to retain
existing GSM coverage
3dB insertion loss (DL/UL)
antenna antenna
30% coverage reduced
Not support RET
Cable attenuator Cable attenuator

Advantage of SASU
(SASU: Same Antenna Sharing Unit)
combiner combiner
SASU
Negligible Impacts to GSM
negligible loss on UL
G900 U900 G900 U900
BTS Node B < 0.6 dB loss on DL BTS Node B
Support RET function (with
10dB Gain)

HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential Page 51


Case 3: Independent Antenna for U900

In case of high configuration, 2 independent antennas


can be used.

GSM900 UMTS900

Independent antenna

HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential Page 52


Disadvantage of Independent Antenna U900&G900
Additional equipment cost Limitation of evolution
New antenna lack of installation space for LTE/SAE
New pole evolution
New feeder
New TMA

Sites renegotiation Slow the pace of site deployment


New antenna and pole Additional Longer time to market
Cost

Additional installation cost Additional maintenance cost


New antenna New antenna
New pole
New feeder

HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential Page 53


Antenna Solution Summary

Solution Advantages Disadvantages

Easy to implement RF optimization


Independent antenna much additional cost needed
respectively.

1) 3G and 2G system can not adjust the down tilt angle and
Save the installation space and cost for
Co-antenna with SASU azimuth independently;
antenna and feeder
2) downlink increase less than 0.6dB loss.

1) 3G and 2G system can not adjust the down tilt angle and
Co-antenna with 3dB Save the installation space and cost for
azimuth independently;
combiner antenna and feeder
2) downlink increase more than 3 dB loss.

1) save the space and cost of antennas


and feeders;
Co-antenna 3G and 2G system can not adjust the down tilt angle and azimuth
2) No insertion loss;
with GU mRRU/mRFU independently;
3) Easy RF tuning for 2G/3G co-coverage
objectives;

HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential Page 54


Agenda
UMTS900 Deployment Strategy
Huawei Refarming Solution
2G Traffic Transfer Strategy
GSM900 Frequency re-plan and performance
Inter-RAT Operation Solution
Co-Antenna Solution
UMTS Refarming Application
Refarming Solution case study S Operator

Network Information for Refarming


Scenario :Suburban& Rural
G900 and G1800 and U2100 , total 45 Sites
Bandwidth : 9.8MHz(76-124) @900M,
23.8MHz (512-525, 647-751)@ 1800MHz
UMTS900 Refarming : 1 U900 carrier

Refarming Solution 2.2MHz

Swap and Refarming with Single RAN3.0 MRRU for G90


0/G1800&U900
Sandwich allocation, 4.2MHz of total 12.4MHz for UMTS
G900:76~89,111~124; U900:90~110
GSM89 UMTS 110 GSM
Traffic migration :GSM900-> GSM1800M 4.2MHz

HUAWEI Confidential Page 56


Huawei frequency Refarming

Frequency re-plan area shall be separated in


URBAN
to refarming area, buffer zone & RF optimizat
Channels: 64-124
ion zone;

G900 cell BCCH shall has a frequency guard


Area to refarm : 4.2Mhz
Channels: 76 - 89 and 111 - 124
over 2.6MHz with UMTS channel, available r
ange is 76 87 and 113 124 TCH of G
Zone de garde: Replan in
10Mhz 900 Co-sited with U900 shall not use the adja
Channels: 76 - 124
cent frequenies(89,111), while TCH of separ
ate G900 site can use them.

HUAWEI Confidential Page 57


Buffer Zone Frequency Planning Sites in
Refarming zone

Sites in buffer zone

Sites in RF
optimization zone

HUAWEI Confidential Page 58


Inter-RAT Operation Solution in Refarming Area

Adjacent cell relationship


G900 Adjacent cells: D1800, U900(co-site),U2100 F0(no
co-site),
U900 Adjacent cells:G900,,U2100 F0
U2100 F0 Adjacent cells: U2100 F1, U2100 F2,
U900(GU co-site), G900(no co-site)

Mobile strategy
In idle state, bidirectional reselection
between GSM and UMTS
In connection state, handover from
UMTS to GSM, but not allowed from
GSM to UMTS.

HUAWEI Confidential Page 59


Intra-UMTS Multi- carrier Solution

Adjacent cell relationship


G900 Adjacent cells: D1800, U900(co-site),U2100 F0(no
co-site),
U900 Adjacent cells:G900, U2100 F0
U2100 F0 Adjacent cells: U2100 F1, U2100 F2
( overlapped coverage cell ), U900(GU co-site), G900(no
co-site)

Mobile strategy
In idle state, bidirectional reselection between U900
and U2100, Bidirectional handover based on coverage
from UMTS2100 to UMTS900 is recommended
In only U2100 F0,F1,or F2 overlapped coverage area,
UE camp on UMTS2100 F0 as preference.
U2100 F1 and F2 have higher priority for HSPA service
than U2100 F0, and such service accessing to F0 will
DRD to F1,F2.

HUAWEI Confidential Page 60


Swap and Refarming flow - Refarming

HUAWEI Confidential Page 61


Swap and Refarming flow - Swapping

HUAWEI Confidential Page 62


Swap and Refarming flow - Swapping

HUAWEI Confidential Page 63


Performance Overview- GSM CS

HUAWEI Confidential Page 64


Performance Overview- GSM PS

HUAWEI Confidential Page 65


Performance Overview- GSM PS

HUAWEI Confidential Page 66


Performance Overview- GSM PS

HUAWEI Confidential Page 67


06.April 2006

Thank You
www.huawei.com

www.huawei.com

HUAWEI TECHNOLOGIES CO., LTD.

You might also like