Professional Documents
Culture Documents
4111024961
B. Of Electronic Engineering
OHNISHI ELECTRONIC
INDUSTRIAL TRAINING
KFS 3236
OUTLINE
Introduction of Company
Objective and Mission
Organization Structure
Department Placement
General Operation
Activity During Training
Conclusion
Introduction of Company
OHNISHI ELECTRONICS (M) SDN BHD was established in 1995.
47, Jalan Firm 2/1, Tebrau Industrial Estate 1, 81100 Johor Bharu, Johor.
Started its business on 1st December 1995. The total paid up is RM 6
million.
Total number of employees in the company of 55 people.
Various business conducted in this company:
1. Bare Board Tester Jig
2. In-Circuit Tester Jig
3. Functional Test Jig
4. Manual Press Machine
5. Air Cylinder Press Machine.
Objective and Mission
CORPORATESS OBJECTIVE
Quality assurance
Technological development
Mutual reliance
Self-Learning
Social responsibility
MISSION
To provide the best quality goods and services for customer and thus satisfying
their every requirement. In realising the end, is create the fundamentals for
Enjoying our assignments at workplace.
Organization Structure
General Operation
1. Marketing.
2. Designing printed circuit boards (PCBs).
3. Drilling, tapping and milling.
4. Performing Wiring.
Department Placement
ASSEMBLY AND WIRING DEPARTMENT
FUNTION SECTION
Make preparation for producing jig such as etching PCB board,
soldering PCB and installation electronic component.
Doing wiring process follow diagram schematic.
Check wiring and do inspection on jig before delivery out to
customer.
Activity During Training
1. Etching Process
Equipment for etching
Container
Water developer
Ferrik Chloride Acid
Hand gloves
PCB Kinsten
Activity During Training
Etching process : Immerse and shaking slightly
Activity During Training
PCB after etching process
Activity During Training
2. Preparation
Wire preparation for BAX-F
Activity During Training
LED circuit and Regulator Testing relay circuit
Activity During Training
Process of wiring jig BAX-F Data Writer
3. Jig wiring
Activity During Training
Wiring from test point to Sony PCB
Activity During Training
A jig's primary purpose repeatability, accuracy
and interchange ability in the manufacturing of
products.
BAX-F Data writer jig.
Contain 4 buffer PCB, LED PCB, Ground and
transistor PCB.
Function data writer is to test PCB board and set
the PCB following the program through the
buffer.
Activity During Training
Top view of Data Writer
Bottom view of Data Writer
Conclusion
Following knowledge was achieved during training:
Team working
Dealing with real industry cases.
Capability to read schematic diagram circuit.
Assembling electronic PCB in correct way.
Wiring and inspection jig.
THANK YOU