2.Deepak Ravi 1109120038 3.Raju Sahu 1109120082 4.Ishwar Dutt 1109120052
Project Synopsis Presentation On PWM-inverter scheme for grid connected WEGS for power quality measure DEPARTMENT OF ELECTRICAL ENGINEERING Scope of the project:
The project demonstrate the power quality problem due to installation of wind turbine with the grid
The influence of the wind turbine in the grid system concerning the power quality measurements are-the active power, reactive power, variation of voltage, flicker, harmonics, and electrical behavior of switching operation and these are measured according to national / international guidelines.
Today the PWM inverter control technology has been developed and it can technically manage to control the power level associates with the commercial wind turbines Scope of the project:
The pulse width modulation (PWM) inverter scheme for the grid connected wind energy generation system for power quality improvement is simulated using MATLAB/SIMULINK in power system block set.
Due to improvement in technologies, the wind turbine is expected to support the grid and therefore the wind turbine has to control the reactive power over a wide range, and also to deliver the reactive power, in case of voltage drop and can remain connected during short-term voltage drop. Challenges:
The power quality issues can be viewed with respect to the wind generation, transmission and distribution network can cause the variation in voltage to which the wind turbine is connected, such as voltage sag, swells, etc. However the wind generator introduces disturbances into the distribution network.
POWER QUALITY ISSUES:
Voltage Variation : a) Voltage Sag /Voltage Dips b) Voltage Swells c) Short Interruptions d) Long duration voltage variation Flicker Harmonics Wind turbine Location in power system Self Excitation of wind turbine generating system CONCLUSION:
The Project will simulate the scheme in MATLAB/SIMULINK for maintaining the power quality in such a way that it can cancel out the reactive and harmonic parts of the load current and maintain the source voltage and current in-phase at the point of common coupling in the grid system. Reference
[1] B. R. Gupta, Generation of Electrical Energy, S. Chand, 2009. [2] http://en.wikipedia.org/wiki/Variable_speed_wind_turbine [3] Sharad W.Mohod, IEEE Member Dept. of Electronic Engineering, Prof. Ram Meghe, Dr. Mohan V. Aware. A novel, PWM-inverter scheme for grid connected WEGS for power quality measure. [4] P. W. Carlin, A. S. Laxsonand, E. B. Muljadi, The History and State of the Art of Variable-Speed wind Turbine Technology, National Renewable Energy Laboratory/National Wind Technology Center, 1617 Cole Boulevard, Golden, CO 80401, USA [5] Mahmoud M. N. Amin, Student Member, IEEE, O. A. Mohammed, Fellow, IEEE Energy Systems Research Laboratory, Power Quality Improvement of Grid- Connected Wind Energy Conversion System for Optimum Utilization of Variable Speed Wind Turbines, Florida International University Department of Electrical and Computer Engineering Miami, Fl. 33174, USA