You are on page 1of 6

OBJECTIVE QUESTIONS IN ANALOG ELECTRONICS

1. The early effect in a bipolar junction transistor is caused by (a) fast turn-on (c) large collector-base reverse bias 2. MOSFET can be used as a (a) current controlled capacitor (c) current controlled inductor (b) voltage controlled capacitor (d) voltage controlled inductors (b)fast turn-off (d) large emitter-base forward bias

3. Thermal runaway is not possible in FET because as the temperature of FET increases (a) the mobility decreases (c) the drain current increases (b) the transconductance increases (d) none of the above

4. A source follower using an FET usually has a voltage gain which is (a) greater than +100 (c) exactly unity but negative (b) slightly less than unity but positive (d) about -10

5. A differential amplifier has a differential gain of 20,000 . CMRR=80 dB. The common mode gain is given by (a) 2 (b) 1 (c) 1/2 (d) 0

6. The approximate input impedance of the OPAMP circuit which has Ri=10k,Rf=100k,RL=10k (a) (b)120k (c)110k (d)10k

7. An OPAMP has a slew rate of 5 V/ S .The largest sine wave O/P voltage possible at a frequency of 1MHZ is (a) 10 volts (b) 5 volts (c) 5/ volts (d)5/2 volts

8. A change in the value of the emitter resistance Re (a) affects the difference mode gain Ad (c)affects both Ad and Ac

in a differential amplifier

(b) affects the common mode gain Ac (d) does not effect either Ad and Ac

OBJECTIVE QUESTIONS IN ANALOG ELECTRONICS

9. A differential amplifier is invariably used in the i/p stage of all OP-AMPs.This is dome basically to provide the OP-AMPs with a very high (a)CMRR (b)bandwidth (c) slew rate (d)open-loop gain

10. The effective channel length of a MOSFET in a saturation decreases with increase in (a) gate voltage (b)drain voltage (c)source voltage (d)body voltage

11. Which of the following is not associated with a p-n junction (a) junction capacitance (c)depletion capacitance (b)charge storage capacitance (d)channel length modulation

12. In a p-n junction diode under reverse bias , the magnitude of electric field is maximum at (a) the edge of the depletion region on the p-side (b) the edge of the depletion region on the n-side (c) the p-n junction (d) the center of the depletion region on the n-side 13. An n- channel JFET has IDSS=2mA,and Vp=-4v.Its transconductance gm=(in mA/V)for an applied gate to source voltage VGS=-2v is (a)0.25 (b)0.5 (c)0.75 (d)1

14. In a common emitter, unbypassed resister provides (a)voltage shunt feedback (c)negative voltage feedback (b)current series feedback (d)positive current feedback signal

15. A constant current signal across a parallel RLC circuits gives an o/p of 1.4v at the frequency of 3.89KHZ and 4.1KHZ .At the frequency of 4KHZ,the o/p voltage will be (a)1 v (b) 2v (c)1.4v (d)2.8v

16. Class AB operation is often used in power (large signal) amplifiers in order to (a) get maximum efficiency (c) overcome a crossover distortion (b)remove even harmonics (d)reducing collector dissipation

OBJECTIVE QUESTIONS IN ANALOG ELECTRONICS

17. The bandwidth of an RF tuned amplifier is dependent on (a) (b) (c) (d) Q factor of the tuned o/p circuit Q factor of the tuned i/p circuit Quiescent operating point Q-factor of the o/p and i/p circuits as well as quiescent operating point

18. If  =0.98 ,Ico=6A and I=100A for a transistor,then the value of Ic will be (a)2.3mA (b)3.2mA (c)4.6 mA (d)5.2mA

19.The MOSFET switch in its on-state may be considered equivalent to (a)resistor (b)inductor (c)capacitor (d)battery

20. Most of the linear ICs are based on the two-transistor differential amplifier because of its (a) input voltage dependent linear transfer characteristic (b) high voltage gain (c) high input resistance (d) high CMRR 21. Negative feedback in an amplifier a) Reduces gain b) Increase frequency &phase distortion c) Reduces bandwidth d) Increases noise 22. A dc power supply has no-load voltage of 30v,and a full-load voltage of 25v at full-load current of 1A.Its output resistance & load regulation ,respectively are a) 5 & 20 % b) 25 & 20 % c) 5 & 16.7 % d) 25 & 16.7 %

23. The current gain of a bipolar transistor drops at high frequencies because of a) Transistor capacitances b) High current effects in the base d) The early effect
3

c) Parasitic inductive elements

OBJECTIVE QUESTIONS IN ANALOG ELECTRONICS

24. The ideal OP-AMP has the following characteristics. a) Ri= ,A= ,R0=0 c) Ri= ,A= ,R0= b) Ri=0 ,A= ,R0=0 d) Ri=0 ,A= ,R0=

25. An npn BJT has gm=38mA/v, c =1014 F, c =1013F and DC current gain 0=90.For this transistor fT & f are a) fT =1.64 x 108 Hz & f = 1.47 x 1010 Hz. c) fT =1.33 x 1012 Hz & f = 1.47 x 1010 Hz b) fT =1.47 x 1010 Hz & f = 1.64 x 108 Hz d) fT =1.47 x 1010 Hz & f = 1.33 x 1012 Hz

26. A 741-type OP-AMP has a gain-bandwidth product of 1MHz.A non-inverting amplifier using this opamp & having a voltage gain of 20db will exhibit -3db bandwidth of a) 50 KHz b) 100KHz c) 1000/17 KHz d) 1000/7.07 KHz

27.An amplifier using an opamp with slew rate SR=1v/sec has a gain of 40db.if this amplifier has to faithfully amplify sinusoidal signals from dc to 20 KHz without introducing any slew-rate induced distortion, then the input signal level must not exceed a) 795mV b) 395mV c) 795 mV d) 39.5mV

28. In the differential voltage gain & the common mode voltage gain of a differential amplifier are 48db &2db respectively, then its common mode rejection ratio is a)23dB b)25dB c) 46dB d) 50dB

29. Generally, the gain of a transistor amplifier falls at high frequencies due to the a) Internal Capacitance of the device c) Skin effect b) Coupling capacitor at the input d) Coupling capacitor at the output

30. An amplifier without feedback has a voltage gain of 50,input resistance os 1 K & Output resistance of 2.5K.The input resistance of the current-shunt negative feedback amplifier using the above amplifier with a feedbacik factor of 0.2 is a) 1/11K b) 1/5K c) 5K d) 11K

OBJECTIVE QUESTIONS IN ANALOG ELECTRONICS

31. The action of JFET in its equivalent circuit can best be represented as a a) Current controlled Current source c) Voltage controlled voltage source b) Current controlled voltage source d) voltage controlled current source

32. Three identical amplifiers with each one having a voltage gain of 50,input resistance of 1K & output resistance of 250 ,are cascaded.The open circuit voltage gain of combined amplifier is a) 49dB b) 51dB c) 98dB d) 102dB

33. An ideal OP-AMP is an ideal a) Current controlled Current source c) Voltage controlled voltage source b) Current controlled voltage source d) voltage controlled current source

34. In a full-wave rectifier using two ideal diodes,Vdc & Vm are the dc & peak values of the voltage respectively across a resistive load. If PIV is the peak inverse voltage of the diode, then the appropriate relationships for this rectifier is. a) Vdc = Vm/, PIV=2Vm c) Vdc = 2Vm/, PIV=Vm b) Vdc = 2Vm/, PIV=2vm d) Vdc = Vm/, PIV=Vm

35. The cascade amplifier is a multistage configuration of a) CC-CB .b) CE-CB c) CB-CC d) CE-CC

36. The current gain of a BJT is a) gm r0 b) gm / r0 c) gm r d) gm /r

37. The most commonly used amplifier in sample & hold circuits is a) A unity gain non-inverting amplifier c) An inverting amplifier with a gain of 10 b) A unity gain inverting amplifier d) An inverting amplifiers with a gain of 100

OBJECTIVE QUESTIONS IN ANALOG ELECTRONICS

38. Assume that the op-amp of the fig. is ideal. If Vi is a triangular wave ,then V0 will be C V - R V0

a) square wave

b) Triangular Wave

C) Parabolic Wave d) Sine Wave

39. Introducing a resistor in the emitter of a common amplifier stabilizes the dc operating point against variations in a) Only the temperature c) Both Temperature & b) only the of the transistor d) None of the above

40. Voltage Series feedback (also called series-shunt feedback) results in a) Increase in both input & output impedances b) Decreases in both input & output impedances c) Increase in input impedance & decreases in output impedance d) Decrease in input impedance & increase in output impedance

Ans:- 1. (c), 2. (b), 3. (a), 4. (a), 5. (a), 6. (d), 7. (d), 8. (b), 9. (a), 10. (b), 11. (d), 12. (c), 13. (b), 14. (c), 15. (b), 16. (c), 17. (a), 18. (d), 19. (c), 20. (d), 21. (a), 22. (b), 23. (a), 24. (a), 25. (b), 26. (b), 27. (c), 28. (c), 29. (a), 30. (a), 31. (d), 32. (c), 33. (b), 34. (b), 35. (b), 36. (c), 37. (b), 38. (c), 39. (c), 40. (c)

You might also like