You are on page 1of 4

DESIGN OF SUB-MODULES OF A MICRO-PROCESSOR

USING

LOW POWER DESIGN TECHNIQUES

B.Tech. Major (or Minor) Project Report

BY ACHIRANSHU GARG

DEPARTMENT OF ELECTRONICS & COMMUNICATION ENGINEERING NATIONAL INSTITUTE OF TECHNOLOGY HAMIRPUR-177005, HP (INDIA) DECEMBER, 2008

DESIGN OF SUB-MODULES OF A MICRO-PROCESSOR


USING

LOW POWER DESIGN TECHNIQUES

A Major (or Minor) Project Report


submitted in partial fulfilment of the requirements for the award of the degree of Bachelor of Technology in ELECTRONICS & COMMUNICATION ENGINEERING

BY ACHIRANSHU GARG

DEPARTMENT OF ELECTRONICS & COMMUNICATION ENGINEERING NATIONAL INSTITUTE OF TECHNOLOGY HAMIRPUR-177005, HP (INDIA) JUNE, 2008

CERTIFICATE
I hereby certify that the work which is being presented in the B.Tech. Major (or Minor) Project Report entitled Investigation on Various Low Power Techniques for CMOS Circuits, in partial fulfillment of the requirements for the award of the Bachelor of Technology in Electronics & Communication Engineering and submitted to the Department of Electronics & Communication Engineering of National Institute of Technology Hamirpur HP is an authentic record of my own work carried out during a period from January 2009 to July 2009 under the supervision of Name & Designation of supervisor(s), E&CE Department. The matter presented in this thesis has not been submitted by me for the award of any other degree elsewhere. Signature of Candidate ACHIRANSHU GARG R.No. 04401 This is to certify that the above statement made by the candidate is correct to the best of my knowledge. Signature of Supervisor(s) Date: Name & Designation Project Supervisor(s)

Head Electronics & Communication Engineering Department National Institute of Technology Hamirpur HP

B.TECH. Project Report should be in following format


Single Column Format. Text size 12, in IEEE format. It should be in 1.5 spacing. IEEE Transaction style for References, it should be followed in the text as well. Each Figure should have a Caption below & Table should have a Caption above it

and each Table & Figure should find a mention in the text, refer to any IEEE Transaction Paper, eg. IEEE Trans. on VLSI, ED etc.

General Format of the Report should be:


Title of Reoprt (20 font) List of Figures List of Tables List of Abbreviations ACKNOWLEDGEMENTS ABSTRACT (16) 1. INTRODUCTION (16) 2. SECTIONS IN CAPS (2, 3, 4, 5) 2.1 Subsections in Running Fonts (14) 3..etc. 6. RESULTS AND DISCUSSION 7. CONCLUSIONS REFERENCES PUBLICATIONS FROM THE WORK

You might also like