You are on page 1of 2

COMMERCIAL PHOTOVOLTAIC SOLUTION

SOLARTOWER™
TECHNICAL DRAWING
• 9 times more powerful
• 17% savings on installation
• 8.2% size gain efficiency
• Contamination free active layer
• LaserCut™ edge
• Hurricane grade design

SPG8-450 MODULE SPECIFICATIONS


• Length: 6172mm of Panel
• Height: 4419mm of Panel
• Height of SolarTower™: 40 feet
• Lifetime: 25+ years
• Frame-less Design
• Rated Power 450 Watt max (+/-5%)
• Output Voltage – 120V (at max power)
• Panel Rated Current – 3.8 A (at max power)
• Glass Type: Ultra Clean low iron
3.2mm thick

The SolarTower™ is Advanced Solar Photonics’ commercial photovoltaic solution for solar
energy by commercial and industrial businesses. The Solar Towers™ design allows for
the highest amount of energy produced with the smallest footprint. This new design
incorporates Advanced Solar Photonics’ SunPanels™ by mounting them to an innovative
modular pole design allowing for ingenious utilization of space. Our SunPanels™ can be
mounted strategically around your facility without the use of conventional mounting on
roofs.
SUNPANELS™
• Generates approximately 4 kW per SolarTower™
TECHNICAL DRAWING
• Automated Sun Following allows the SolarTower™ to move with the suns motion,
maintaining constant solar exposure
6172 242.992

71.600 2.819

• Multiple SunPanels™ can be added for increased power generation


• Small plot size needed for installation
• Meets state requirements for solar energy incentive programs
4419.600 174.000 • Modular design of base to accommodate additional panels as needed

ABOUT ADVANCED SOLAR PHOTONICS


Located in Lake Mary, Florida, Advanced Solar Photonics, LLC (ASP) is a division of Fonon
Technology International, Inc. (FTI). Providing technological solutions to the Flat Panel
Display (FPD) Industry for over 15 years, FTI has accumulated substantial experience in
precision fabrication and mask repair for Generation 8 flat panel displays. ASP has made
further advancements in thin-film photovoltaic technology due to ASP’s own patents and
knowhow, combined with worldwide strategic partnerships. ASP is now executing phase
1 of a plan to build a 40MW SolarFab™ manufacturing line to produce thin-film SunPanel™
modules in its 320,000 square foot high-tech facility. ASP will begin module shipments in
the third quarter of 2009.

ASP is developing its technology on the bases of its own patents and knowhow, strategic
partnership IP, the latest advancements in the TFPV technology, available through worldwide
cooperation.

400 Rinehart Road • Lake Mary, FL 32746 USA


www.advancedsolarphotonics.com • info@advancedsolarphotonics.com
Tel: 407.829.2613 • Fax: 407.804.1002

You might also like