Professional Documents
Culture Documents
SHEAR
Fv
~
AXIAL
Iv
< 1
-
according
to subcases Fv = 0.40 Fy (F4-1) calculate min Kv and Cv in have Fv =0.4 and to satisfy 'a' and then order to Fy in (F4-2) the (F5-1)
tw
380
y
It
< 1
COMPRESSIO
where
fa < 1according
F
a
~<
tw
-
rv
subcase
760 IF:
-VF
according
kl /
r "--
t>
J::
95
h 760
and -,;'
JF:
The allowable stress be shall be subject to a reduction factor Qs; use (A-B5-3) or (A-B5-4)
Calcylate the effective area of memberwith reduced effective lenght of web "be"
Q
a
EffectiveArea ActualArea
Enter in form Q=Qs*Qa I with
NOTE 1:
For the limiting Width-Thickness Ratios for Compression Elements see TABLE B5.1 When the limiting ratios contain Fb the calculation is iterative with the first position Fb =0.6Fy
I AISC
I BENDING
f S;1 accoding to the Fh following subcase
h
I
ension and compression see previous page From axial tension From axial compression ......
-<-tw
-
970
.[F;
NO
YES
I I
-The conditions (G1-1) and (G1-2) shall be satisfy -The Fb calculated in the double framed boxes is reduced by Factors Rpg (G2-1) -The bending tensions fbx and fby shall be calculate:l by using the reduced effective lenght of web "be" in Wx and Wv. Sec. A-B5-b Flange Fb Fb=0.75Fy (F2-1) (F2-3) 0.60Os Fy for Os use (A-B5-3) or (A-B5-4)
See note 2
--1 Weak
Axis
r-
Strong Axis
I
NO
AXIAL COMPRESSION AND BENDING /RS;1 accoding to the following subcase '-fa S; 0.15 Fa fa> 0.15 Fa
use (H1-3) { IR = MAX (H1-1) (H1-2)
@
see (F1-2)
-L1-6) Fb=MAX
or (F1-7) (F1-B)
YES
See note 2
/ NOTE 2
Flange Compact Compact Non Compact Non Compact Slender Web Compact Non Compact Compact Non Compact Compact Non Compact Fb 0.66Fy (F1-1) 0.60Fy (F1-5) (F14) 0.60Os Fy for Os use (A-B5-3) or (A-B5-4) in use H1-1 to H1-3 for sections containing slender element the provision of Appendix B5.2.d and B5.2.c shall be satisfy: -if the section contains slender web the stresses Fa, fbx, and fby shall be calculated using the effective width of uniformly compressed elements -if the section contains slender flange the allowable bending stress Fb shall be the smaller value O.60FyQs or thath provided in Sect. F1.3. The term falO.60Fy in equation (H1-2) shall be replaced
NOTE 1
If AISC factor is > 1, all the basic allowable stress may be increased by AISC factor.