Professional Documents
Culture Documents
CAUTION:
Turn off the power while removing the DIP switch cover to prevent an electric short, which can damage the printer. Use a crosshead screwdriver to remove the screw holding the DIP switch cover.
Look at the numbers and letters in the area indicated in the illustration. If the last letters are US, use the US tables below. If the last letters are STD, use the STD tables. ON
ON OFF
CAUTION:
OFF
Be sure to put back the DIP switch cover before using the printer.
Note: The functions of the switches are shown in the following sections. The DIP switch function of US is little different from the STD.
(DIP Switch 2)
On 42/35 Type A, B Fixed to On Memory switch Used Used Off 40/33 Type D Fixed to Off Fixed to Off DIP switch Fixed to Off Fixed to Off Not used Not used
3 4 5 6 7 8
3 4 5 6 7 8
Rev. D
Setup 3-15
(DIP Switch 2)
On 42/35 Type A, B Fixed to On Used Off 40/33 Type D Fixed to Off Fixed to Off Not used Print column selection Reserved (Auto cutter enable/ disable) Pin 31 reset signal
3~7 8
3~7 Reserved 8
Note: See the next page for When the letters are US. See Notes for DIP switch 2-1 (page 3-19) about the DIP SW 2-1 setting. When you use serial interface model with 1200bps, 2400bps, or 19200bps, you have to adjust DIP switch Serial interface selection function and Memory switch Serial communication condition.
3-16 Setup
Rev. D
(DIP Switch 2)
On 42/35 Off 40/33
Receive buffer capacity Handshaking Word length Parity check Parity selection Transmission speed BUSY condition
Reserved (Auto cutter enable/ disable) Pin 6 reset signal Pin 25 reset signal Reserved Reserved Reserved Serial interface selection
Type D Fixed to Off Not used Not used Fixed to Off Fixed to Off Fixed to Off DIP switch
3 4 5 6 7 8
3 4 5 6 7 8
Note: When the printer has a data receive error, the printer prints ?. Usually DIP switch 1-1 should be turned off. The right side up printing mode is a mode used for a printer that is hanging on a wall. For detail, see What is Right side up printing ? (page 5-10). Regardless of the setting of DIP switch 1-1, if you want to perform right side up printing, DIP switch 1-2 must be fixed to off.
(DIP Switch 2)
On Off 40/33 Print column selection 42/35
Reserved (Auto cutter enable/ disable) Reserved Pin 31 reset signal Reserved
3 4~7 8
3 4 5~8
Rev. D
Setup 3-17