Professional Documents
Culture Documents
Before you can register for classes each semester, you must see an advisor at the College Transfer Advising Center. An advisor must remove your advising hold or you will be blocked from online registration in WebAdvisor. The AS premajor is a general academic plan; you should base your individual decision for course selection on the requirements of your specific engineering major at your preferred 4-year university.
Course Taken
II.
ENG
III.
Social/Behavioral Sciences. Select one history course: HIS 111, 112, 121, 122, 131, 132 Select 2 courses from 2 different subject areas: ANT 210 ECO 251 Microeconomics, 252 Macroeconomics (One ECO course is recommended) POL 110, 120, 210 PSY 150 (recommended) SOC 210, 213, 220, 225
9 HIS ( )
Page 1 of 3
IV.
Natural Sciences.. The following courses are required: CHM 151 PHY 251 (pre-req MAT 271) PHY 252
V.
Mathematics. The following courses are required: MAT 271 MAT 272
VI.
Other Required Hours. Both of the following courses are required: MAT 273 Calculus III MAT 285 Differential Equations (pre-req MAT 271) One of the following courses is required: Must Take CIS 115 as Pre-req for the following CSC 134 C++ (EE needs, Aero & ME (replaces FORTRAN)) Or CSC 151 JAVA (Computer Science majors need to take) One of the following courses is required: CHM 152 DFT 170 (Solid Works good for any Engineering) EGR 220 Statics (only for Civil, ME, Aero) (pre-req PHY 251)
If CHM 152 is not selected, then a minimum of 4 cr. hrs. in mathematics, natural sciences, or computer science is also required in Other Elective Hours below.
4 3
( (
) )
CSC
3-4 ( )
VII.
Other Elective Hours... Select the remaining 7 hours from the Other Electives List below. If CHM 152 is not selected in Other Required Hours above, then
minimum of 4 cr. hrs. in math, natural sciences, or computer science is required. Suggested courses below
( 2 ( 3
) )
CIS 115 Intro to Programming and Logic 3 credits EGR 150 Intro to Engineering , 2 credits equivalent to Introduction to Engineering Can take HEA 110 and PED XXX for PE and Health requirements 1 credits each ( ) )
(
Page 2 of 3
NOTES: Every type of Engineering has specific courses that are recommended or required.
Aero = Aerospace Engineering EE = Electrical Engineering CE - Computer Engineering ME = Mechanical Engineering 1. Mechatronics - joint degree of Electrical and Mechanical Engineering, available at UNC Asheville as a transfer student 2. Biomedical engineers can take Biology, Organic Chemistry I and II at Wake Tech. Make sure these courses transfer to the University that you transferring to. 3. Start Physics or Calculus at Wake Tech finish at Wake Tech. Start Physics or Calculus at other college finish at other college. 4. Check your transfer college requirements for Art, Drama or Journalism. Some Colleges of Engineering require specific courses or will not transfer these courses to your major. 5. East Carolina University undergraduate degrees in Systems Engineering, Bioprocesses, Biomedical Engineering, Engineering Management. 6. NC A&T - undergraduate degrees Civil, Architecture, Bioenvironmental, Computer Science, Computer and Engineering Electrical Engineering, Industrial and Systems Engineering, Mechanical and Chemical Engineering 7. NCSU - all types of Engineering are available. 8. UNC Charlotte undergraduate degrees in Civil, Environmental, Electrical Computer, Mechanical and Engineering Science For specific questions about Engineering and Engineering University transfer options Contact Susan Meardon Dept Head for Pre-Engineering 919.866.5344 slmeardon@waketech.edu
This Checklist Is For Advising Purposes: Only The Registrar Can Clear Students For Graduation. If this is your last semester and you are graduating you must complete an Application for Graduation with the Registrar.
Associate in Science (A.S.) Pre-Major in Engineering A1040D 2008*03 Recommended Courses Checklist Page 3 of 3