You are on page 1of 5

Practicing of the fundamental scheme of a device of Tariel Kapanadze.

How sweet is taste of a freebie! Dmitry-X. I will remind that basis of practicing is the green box and the block diagram which has been laid out in the patent.

Circuit .
1. The entrance cascade. The entrance cascade with one charging capacity is shown on the drawing. This capacity is charged very slowly at 100 Hz fluctuations, that extremely doesnt suit us.

Pic.1. This problem can be solved with two methods: to lift the frequency of a pumping or to resort to a buffer version, accumulating preliminary the energy in the buffer capacity, a Pic. 2 and a Pic. 3.

Pic.2.

.3. Not to complicate the basic scheme too much, we choose a version with buffer capacity. 2. Keys of a charge discharge of capacity "points". Like an engine distributor . And maybe really to use the dispenser of the distributor of the engine? We have: 4 candles, 6 candles, 8 candles and even 12 candles. We take on 4 candles. How can look like Pic. 4.

.4. If to choose the way of using the semi-conductor keys, then the basic problem will be in the maximum value of breakdown voltage for transistors, or (dont know) for thyristors. But the thing is that as a result the entrance circuit will be in series that is good for us because the voltage drop by resonance will tend to zero. Then, the charge of working capacity through a discharger wont drop to a zero, so amplitude of variable fluctuation will be far from 2000 Volt. Quite really to use the same transistors or thyristors, which extreme values of parameters are less than 2000 Volt, a Pic. 5 and a Pic. 6.

.5.

.6. 3. The generator of high frequency a discharger. Yet there are no problems here. It is possible to make (it?) on a primitive as in the original, or it is possible to use car candles as LAZJ does.

4. The primary filter (5). As the primary filter (5) we can use the capacity designed for serial resonance of the first inductance (6). 5. The primary coil (6). We treat this issue rather cautiously and carefully. It is necessary to think over in details how can it all be made both in sense of circuit technology, and in sense of form factor. The movie allowed us to see all of it clearly. 2

The primary coil is wound on a cardboard framework through which the thick wire of grounding is stretched. The primary coil is more thin than the secondary and has bigger number of coils. Secondary coil has bigger diameter and it is made of thicker wire. I have counted about 7-8 coils in it. Lets accept 10 coils. Then the primary one will have about 100 coils. Diameters of wires of which the coils are made, are quite big. I think that not to make a mistake in topics that we still dont understand completely, it is better to follow blindly the original, so better not to stint in copper. Placing of coils relative to each other is typical Tesla. The secondary coil is not wound for all the length of primary. It provides a variant of the falling output characteristic that reduces influence of the second inductances load on the first. Therefore we, as well as Tesla, will have to make both of them on separated frameworks, and then adjust by minimum of mutual influence using the displacement method. 6. The first regulator of frequency (7). As the first regulator of frequency we use the sensor of current passage simultaneously for A and B circuits in form of the ohm resistor. When current increases, voltage drop on it grows and vice versa. And the signal from this sensor actually regulates the frequency of a charge of capacity and delivery of this charge on the discharger. So the frequency of the discharger spark as the high-frequency generator is not regulated (for us its absolute primitive!), and frequency of giving their packs on inductance is regulated. Its more simple to use a wire potentiometer which cursor provides better possibility to adjust sensitivity of the sensor inside of a circuit. Enough for circuit A.

Circuit .
1. The alternate magnetic field from the primary coil (6) is transformed to the secondary coil (10). According to the patent, displacement, withdrawal of resonant frequency of the second inductance is made by units (8) and (9). In a green box theres no unit (9) per se. There is only the unit (8). It is the same capacity of a serial circuit, but with the resonant frequency chosen at 1/10 less than resonance of frequency of the first inductance. And thats all. Yes, really, this capacity is included in the bottom part of a A circuit before the current sensor. 2. The unit (11) is not considered, because it doesnt exist in the green box. Here is the general view of the scheme.

Conclusion. There are no face values and the detailed scheme of the generator (of?) keys for pumping the first inductance. It needs to be calculated by everyone, proceeding from the considerations which were laid out above. It wont be difficult for those, who went deep into all of this. It will be very interesting to hear opinions about this topic from other Forum members. Especially interesting are opinions of whether all this is harmful to the human. The thing is that in my estimation, there is a time transfer of energy from the ether in the area of working coils, that is absolutely not known in physics nowadays and that can create some consequences. So - I practice the element of transfer itself carefully inductances unit. (I dont know what does the guy mean) But I think that theres a way out of this situation and I suggest to go this way. One of the methods is to reduce the capacity of a signal of the time transfer of energy, it means to light a bulb in a freebie not for 220 volt, but for example for 6,3 Volts. Why does Tariel have 220 Volt? Because as a shock hammer on the ether by force of the first inductance he also uses the method that Tesla used the discharger in the air medium. And for this purpose it is necessary to use a voltage of more than 1000V on 1mm of air space of dischargers gap. Certainly, from 2000V it is much more easy to get and to keep up the nominal level of pumping out to the load at 220V than at 6,3 V. In Teslas time electrotechnology was just arising so he did not have that elemental basis that we have. (But if we also had his brain, we didnt have any problems at all!). So we have a possibility to try it all on lower energies and to save ourselves and our relatives from unknown disasters. And for it we need in the first place that "hammer-key" about which Lord was speaking in the first post in the beginning of this thread. I express deep gratitude to LAZJ for discussion and the help in writing this article. Victor Grieg March, 2009. 4

You might also like