You are on page 1of 6

TSOP17..

Photo Modules for PCM Remote Control Systems


Available types for different carrier frequencies
Type TSOP1730 TSOP1736 TSOP1738 TSOP1756 f0 30 kHz 36 kHz 38 kHz 56 kHz Type TSOP1733 TSOP1737 TSOP1740 f0 33 kHz 36.7 kHz 40 kHz

Description
The TSOP17.. series are miniaturized receivers for infrared remote control systems. PIN diode and preamplifier are assembled on lead frame, the epoxy package is designed as IR filter. The demodulated output signal can directly be decoded by a microprocessor. TSOP17.. is the standard IR remote control receiver series, supporting all major transmission codes.
GND VS OUT
94 8691

Features
D Photo detector and preamplifier in one package D Internal filter for PCM frequency D Improved shielding against electrical field disturbance

D TTL and CMOS compatibility

D D D D D

Output active low Low power consumption High immunity against ambient light Continuous data transmission possible (1200 bit/s) Suitable burst length 10 cycles/burst

Block Diagram
2 Input Control Circuit 100 kW 3 PIN AGC Band Pass Demodulator 1 GND OUT VS

94 8136

TELEFUNKEN Semiconductors Rev. A4, 12-May-97

1 (6)

TSOP17..
Absolute Maximum Ratings
Tamb = 25_C Parameter Supply Voltage Supply Current Output Voltage Output Current Junction Temperature Storage Temperature Range Operating Temperature Range Power Consumption Soldering Temperature (Pin 2) (Pin 2) (Pin 3) (Pin 3) Test Conditions Symbol VS IS VO IO Tj Tstg Tamb Ptot Tsd Value 0.3...6.0 5 0.3...6.0 5 100 25...+85 25...+85 50 260 Unit V mA V mA C C C mW C

(Tamb 85 C) t 10 s, 1 mm from case

Basic Characteristics
Tamb = 25_C Parameter Supply Current ( pp y (Pin 2) ) Transmission Distance Output Voltage Low (Pin 3) Irradiance (30 40 kHz) Test Conditions VS = 5 V, Ev = 0 VS = 5 V, Ev = 40 klx, sunlight Ev = 0, test signal see fig.7, IR diode TSIP5201, IF = 400 mA IOSL = 0.5 mA,Ee = 0.7 mW/m2, f = fo, tp/T = 0.4 Pulse width tolerance: tpi 5/fo < tpo < tpi + 6/fo, test signal (see fig.7) Pulse width tolerance: tpi 5/fo < tpo < tpi + 6/fo, test signal (see fig.7) Angle of half transmission distance Symbol ISD ISH d VOSL Ee min 0.35 Min 0.4 Typ 0.6 1.0 35 Max 0.8 Unit mA mA m mV mW/m2

250 0.5

Irradiance (56 kHz)

Ee min

0.4

0.6

mW/m2

Irradiance Directivity

Ee max 1/2

30 45

W/m2 deg

Application Circuit
330 W *) 2 TSOP17.. TSAL62.. 3 4.7 mF *) >10 kW optional +5 V **)

mC

1
96 12108

GND *) only necessary to suppress power supply disturbances **) tolerated supply voltage range : 4.5 V<VS <5.5V

2 (6)

TELEFUNKEN Semiconductors Rev. A4, 12-May-97

TSOP17..
Typical Characteristics (Tamb = 25_C unless otherwise specified)
Ee min Threshold Irradiance ( mW/m2 ) 1.0 E e min / E e Rel. Responsitivity ( % ) 0.8 2.0 f ( E ) = f0 1.6 1.2 0.8 0.4 0.0 0.7
94 8143

0.6

0.4 0.2 0.0 0.8 0.9 1.0 1.1 1.2 1.3 f / f0 Relative Frequency

Df ( 3 dB ) = f0 / 10

f = f0

"5%

0.0
94 8147

0.4

0.8

1.2

1.6

2.0

E Field Strength of Disturbance ( kV / m )

Figure 1. Frequency Dependence of Responsivity


1.0 0.9 tpo Output Pulse Length (ms) 0.8 0.7 0.6 0.5 0.4 0.3 0.2 0.1 0 0.1
96 12110

Figure 4. Sensitivity vs. Electric Field Disturbances


10 f = f0 1 kHz

Input burst duration

Ee min Threshold Irradiance ( mW/m2 )

10 kHz 1

l = 950 nm, optical test signal, fig.7

100 Hz

1.0

10.0

100.0 1000.0 10000.0


94 9106

0.1 0.01

0.1

10

100

1000

Ee Irradiance ( mW/m2 )

DVs RMS AC Voltage on DC Supply Voltage ( mV )

Figure 2. Sensitivity in Dark Ambient


5.0 4.5 4.0 3.5 3.0 2.5 2.0 1.5 1.0 0.5 0 0.01 0.10 1.00 10.00 100.00 Ambient, l = 950 nm Correlation with ambient light sources ( Disturbance effect ) : 1 0W/m2 1.4 klx ( Stand.illum.A, T = 2855 K ) 8.2 klx ( Daylight, T = 5900 K )

Figure 5. Sensitivity vs. Supply Voltage Disturbances


1.0 0.9 0.8 0.7 0.6 0.5 0.4 0.3 0.2 0.1 0 30 15 0 15 30 45 60 75 90 Sensitivity in dark ambient

E e min Threshold Irradiance (mW/m2 )

^ ^

E e min Threshold Irradiance (mW/m2 )

96 12111

E DC Irradiance (W/m2)

96 12112

Tamb Ambient Temperature ( C )

Figure 3. Sensitivity in Bright Ambient

Figure 6. Sensitivity vs. Ambient Temperature

TELEFUNKEN Semiconductors Rev. A4, 12-May-97

3 (6)

TSOP17..
Ee Optical Test Signal ( IR diode TSIP 5201, IF = 0.4 A, 30 pulses, f = f0, T = 10 ms ) T on ,T Output Pulse Length (ms) off 1.0 0.9 0.8 0.7 0.6 0.5 0.4 0.3 0.2 0.1 0 0.1 t tpo2 )
96 12114

Ton

t tpi * * tpi Output Signal


1) 2)

w 10/fo is recommended for optimal function


96 12109

Toff
l = 950 nm, optical test signal, fig.8

VO VOH VOL

7/f0 < td < 15/f0 tpo = tpi 6/f0

"

1.0

10.0

100.0 1000.0 10000.0

td1 )

Ee Irradiance (mW/m2)

Figure 7. Output Function


Ee Optical Test Signal 1.0 0.9 I s Supply Current ( mA ) 0.8 0.7 0.6 0.5 0.4 0.3 0.2 0.1

Figure 10. Output Pulse Diagram

Vs = 5 V

600 ms T = 60 ms

600 ms

94 8134

VO VOH VOL

Output Signal, ( see Fig.10 )

0 30 15 Ton Toff t
96 12115

15

30

45

60

75

90

Tamb Ambient Temperature ( C )

Figure 8. Output Function


3.0 E e min Threshold Irradiance (mW/m2 ) 2.5 2.0 1.5 1.0 0.5 0 0
96 12113

Figure 11. Supply Current vs. Ambient Temperature


1.2 1.0 0.8 0.6 0.4 0.2 0 750
94 8408

N=16 pulses per burst

N=32

S ( l ) rel Relative Spectral Sensitivity

0.1

0.2

0.3

0.4

0.5

0.6

0.7

850

950

1050

1150

tp/T Duty Cycle

l Wavelength ( nm )

Figure 9. Sensitivity vs. Duty Cycle

Figure 12. Relative Spectral Sensitivity vs. Wavelength

4 (6)

TELEFUNKEN Semiconductors Rev. A4, 12-May-97

TSOP17..
0 10 20 30 0 10 20 30

40 1.0 0.9 0.8 0.7 50 60 70 80 0.6


95 11339p2

40 1.0 0.9 0.8 0.7 50 60 70 80 0.6


95 11340p2

0.6 0.4 0.2 0 0.2 0.4 drel Relative Transmission Distance

0.6 0.4 0.2 0 0.2 0.4 drel Relative Transmission Distance

Figure 13. Vertical Directivity y

Figure 14. Horizontal Directivity x

Dimensions in mm

96 12116

TELEFUNKEN Semiconductors Rev. A4, 12-May-97

5 (6)

TSOP17..
Ozone Depleting Substances Policy Statement
It is the policy of TEMIC TELEFUNKEN microelectronic GmbH to 1. Meet all present and future national and international statutory requirements. 2. Regularly and continuously improve the performance of our products, processes, distribution and operating systems with respect to their impact on the health and safety of our employees and the public, as well as their impact on the environment. It is particular concern to control or eliminate releases of those substances into the atmosphere which are known as ozone depleting substances ( ODSs). The Montreal Protocol ( 1987) and its London Amendments ( 1990) intend to severely restrict the use of ODSs and forbid their use within the next ten years. Various national and international initiatives are pressing for an earlier ban on these substances. TEMIC TELEFUNKEN microelectronic GmbH semiconductor division has been able to use its policy of continuous improvements to eliminate the use of ODSs listed in the following documents. 1. Annex A, B and list of transitional substances of the Montreal Protocol and the London Amendments respectively 2 . Class I and II ozone depleting substances in the Clean Air Act Amendments of 1990 by the Environmental Protection Agency ( EPA) in the USA 3. Council Decision 88/540/EEC and 91/690/EEC Annex A, B and C ( transitional substances ) respectively. TEMIC can certify that our semiconductors are not manufactured with ozone depleting substances and do not contain such substances.

We reserve the right to make changes to improve technical design and may do so without further notice. Parameters can vary in different applications. All operating parameters must be validated for each customer application by the customer. Should the buyer use TEMIC products for any unintended or unauthorized application, the buyer shall indemnify TEMIC against all claims, costs, damages, and expenses, arising out of, directly or indirectly, any claim of personal damage, injury or death associated with such unintended or unauthorized use. TEMIC TELEFUNKEN microelectronic GmbH, P.O.B. 3535, D-74025 Heilbronn, Germany Telephone: 49 ( 0 ) 7131 67 2831, Fax number: 49 ( 0 ) 7131 67 2423

6 (6)

TELEFUNKEN Semiconductors Rev. A4, 12-May-97

You might also like