Professional Documents
Culture Documents
FEATURES
Direct Modulation DFB Laser Built-in TEC, Thermistor and Monitor PD 14-Pin Butterfly Type Module QAM Transmission Application 10mW Output Power Low Residual Chirp Selected wavelengths according to ITU-T grid available
FLD5F7CZ-J
APPLICATIONS
This laser is intended for use in Dense Wavelength Division Multiplexed (DWDM) systems that employ Quadrature Amplitude Modulation (QAM) on Quadrate Phase Shift Keying (QPSK). Transmission spans up to 60 km are possible without ampification.
DESCRIPTION
This Laser is a high power laser capable of QAM transmission. It is packaged in a butterfly type module. The module employs a high efficiency optical coupling system, coupling the laser output through a built-in optical isolator into a single mode fiber pigtail. The modules also include a monitor photodiode, a thermoelectric cooler (TEC) and thermistor. This device is designed for DWDM direct modulation transmission systems. Selected wavelengths specified to the ITU-T grid are available. ABSOLUTE MAXIMUM RATINGS (Tc=25C, unless otherwise specified)
Parameter Storage Temperature Operating Case Temperature Optical Output Power LD Forward Current LD Reverse Voltage PD Reverse Voltage PD Forward Current TEC Voltage TEC Current Thermistor Temperature Lead Soldering Time Environmental Operating Humidity Environmental Storage Humidity Symbol Tstg Top Pf IF VR VDR IPD Vc Ic Tth Tsold Xop Xst Condition Min. CW CW Cooling Heating Cooling Heating ATC Operation 260C Top<30C Tstg<30C -40 -20 -2.0 -0.5 -20 Ratings Max. +70 +65 20 150 2 20 10 +2.5 +1.4 +65 10 95 95 C C mW mA V V mA V A C sec % % Unit
FLD5F7CZ-J
Parameter Laser Set Temperature Threshold Current Operating Current Forward Voltage (Pin No. 3) Slope Efficiency Tracking Error Monitor Current Monitor Dark Current Monitor PD Capacitance Peak Wavelength Chirp Linewidth (FWHM) Side Mode Suppression Ratio 2nd Order Intermodulation Distortion 3nd Order Intermodulation Distortion Relative Intensity Noise Input Impedance (Pin No. 12) Bandwidth (-1dB) RF Return Loss Isolation Sr IMD2 IMD3 RIN Zin fc S11 Is Symbol Tset Ith Iop VFDC S Pf Im ID Ct p nFM
OPTICAL AND ELECTRICAL CHARACTERISTICS (TL=Tset, Tc=25C, BOL, unless otherwise specified)
Note 1. Total change in Pf over -20<Tc+65C Test Conditions: Pf=10mW at TL=Tset, Tc=25C Constant Current Operation with TEC operating Note 2. Test Conditions: TL=Tset
Part Number FLD5F7CZ-J21 -J23 -J25 -J27 -J29 -J31 -J33 -J35 Wavelength (nm) 1560.61 1558.98 1557.36 1555.75 1554.13 1552.52 1550.92 1549.32 Tolerance (nm) 0.4 0.4 0.4 0.4 0.4 0.4 0.4 0.4
Note 3. Test Conditions: Pf=10mW, measured at 500MHz. Note 4. Test Conditions: Pf=10mW, Optical Modulation Index OMI=35.0%/ch, 2 unmodulated carriers (f1=553.25MHz, f2=595.25MHz) 1310nm Zero-dispersion single-mode fiber: 50km, Optical Reflection=-40dB (excluding reflection from long-haul fiber) Measured Frequency: IMD2: f=42MHz IMD3: f=511.25MHz Note 5. Test Condiitons: CW, Pf=10mW, f=500MHz, Optical Reflection <-40dB (No long-haul fiber is used in the measurement) Note 6. Test Condiitons: Pf=10mW, no matching network is used in the measurement
FLD5F7CZ-J
Limit Typ. 0.5 1.2 0.6 10.0 3,450 Max. 1.0 2.4 2.4 12.6 3,630 Unit C A V W k K
TEC AND THERMISTOR CHARACTERISTICS (TL=Tset, Tc=25C, BOL, unless otherwise specified)
2.0 1.5
15
10
FLD5F7CZ-J
Fig. 3 Case Temperature Dependence of Wavelength
0.05 Pf=10mW 0.04 0.03 0.02 0.01 0.00 -0.01 -0.02 -0.03 -0.04 -0.05 -50 -40 -30 -20 -10 0 10 20 30 40 50 60 70 3.0
2.0 Vc
2.0
1.0
1.0 Ic
0.0
0.0
-1.0 10 20 30 40 50 60 70
T=Tc-Tset (C)
T=Tc-Tset (C)
0 -5 -10 -15 -20 -50 -40 -30 -20 -10 0 10 20 30 40 50 60 70 T=Tc-Tset (C)
Pf=10mW
500
Frequency (MHz)
FLD5F7CZ-J
IMD2 (dBc)
-40
f=42MHz
-50
-60 1 10 100
IMD3 (dBc)
-50
f=511.25MHz
-60
-70 1 10 100
FLD5F7CZ-J
CZ PACKAGE
17.240.20 15.240.25 PIN 7 8.250.50 5.20.2 8.890.15 12.70.25 14-0.50.1 15.20.3 2.540.20 5.40.5 PIN 1 14-0.10.05
UNIT: mm
2 1
7
5.410.25
5.080.15
8.250.50
0.90.1
5.080.15
TEC
8
#
10
11 12 13
14
PIN 8
PIN DESIGNATIONS
4.150.20 5.80.2
*L
25.00.5
1 2 3 4 5 6 7 8 9 10 11 12 13 14
Thermistor Thermistor LD Cathode Power Monitor Anode Power Monitor Cathode Thermoelectric Cooler (+) Thermoelectric Cooler (-) Case Ground Case Ground NC Case Ground LD Modulation (-) Case Ground NC
CONNECTOR
* Pigtail length (L) and connector type are specified in the detail (individual) specification.
CAUTION
Eudyna Devices Inc. products contain gallium arsenide (GaAs) which can be hazardous to the human body and the environment. For safety, observe the following procedures:
www.us.eudyna.com
Do not put this product into the mouth. Do not alter the form of this product into a gas, powder, or liquid through burning, crushing, or chemical processing as these by-products are dangerous to the human body if inhaled, ingested, or swallowed. Observe government laws and company regulations when discarding this product. This product must be discarded in accordance with methods specified by applicable hazardous waste procedures.
Eudyna Devices Inc. reserves the right to change products and specifications without notice. The information does not convey any license under rights of Eudyna Devices Inc. or others.