Professional Documents
Culture Documents
Column Heaters
Important Safeguards
When using electrical appliances, in order to reduce the risk of fire, electric shock, and/or injury to persons, basic safety precautions should always be followed, including:
To disconnect the heater, set controls to OFF then remove the plug from the outlet. Do not insert or allow foreign objects to enter any ventilation or exhaust opening as this may cause an electric shock, fire or could damage the heater. This heater has hot electrical parts inside. DO NOT use it in areas where gasoline, paint or flammable liquids are used or stored. Use the heater only as described in this booklet. Any other use not recommended by the manufacturer may cause fire, electric shock or injury to persons. Fully remove the power cord from the cord tidy before use. Always uncoil the power cord before applying power. This product must always be used AND STORED in the upright position. The heater must not be located immediately below a socket outlet. COMPULSORY WARNING This heater is filled with a precise quantity of oil. Repairs requiring the opening of the oil container are only to be conducted by the manufacturer or a qualified service agent who should be contacted if there is an oil leakage. Disposal of the oil should be in accordance with local regulations. You should contact your local council to determine the correct procedure. If the supply cord is damaged it must be replaced by the manufacturer or its service agent or a similarly qualified person to avoid a hazard. This product has not been designed for any uses other than those specified in this booklet.
Hand Grip
Control Panel
Cord Tidy
Castors
3 Heat Settings
The diagram below shows how to securely attach the castors so that your Column Heater can easily be wheeled from room to room. Supplied are two U-bolts with two threaded ends and metal spacers. These have to be fitted together with one of the two wheel brackets. They are designed to prevent the fin and control panel from touching walls, etc. Ensure the feet are aligned horizontally and tighten the wing nuts. The wing nuts can be securely tightened without the use of a tool. This is the only time that you should ever turn the Column Heater on its side or upside-down. After attaching the castors wait 15 minutes for the oil in each column to settle back into position.
Heating
The columns or fins that are joined together to form this heater are filled with a special oil that conducts heat to the metal surfaces. These in turn warm the air around them which gently and silently heats the room. Be careful never to damage or puncture the columns because they work under pressure as the oil inside heats up. Like any electrical appliance, this product may cause injury or damage property if used whilst damaged.
Cord Tidy
For storage purposes, gently push the folded cord into the cord tidy as illustrated below.
Power Consumption
Switch 1 MCH5/1000 MCH7/1200 MCH7/1500 MCH9/2000 MCH11/2400 MCH11/2400T 400 Watt 500 Watt 500 Watt 800 Watt 1000 Watt 1000 Watt Switch 2 600 Watt 700 Watt 700 Watt 1200 Watt 1400 Watt 1400 Watt Switches 1 & 2 1000 Watt 1200 Watt 1200 Watt 2000 Watt 2400 Watt 2400 Watt
The timer here is set to switch on at 6.00 pm and switch off at 9.00 pm.
Warranty
The benefits conferred by this warranty are in addition to all implied warranties, other rights and remedies in respect of the product which the consumer has under the Trade Practices Act and similar State and Territory Laws. The original purchaser of this MISTRAL product is provided with the following warranty subject to the following conditions. Mistral International Pty Ltd warrant this product for a period of 2 years from the date of purchase for all parts defective in workmanship or materials. This product or defective parts will be replaced free of charge. WARRANTY CONDITIONS 1. This warranty is only valid for appliances used according to the manufacturers instructions. 2. This appliance must not be modified or changed in any way. 3. Connection must be to the voltage requirements as specified in the ratings label located on the product. 4. The manufacturer does not accept liability for any direct or consequential damage, loss or other expense arising from misuse or incorrect installation and operation of the appliance. 5. Warranty will only be given where proof of purchase is provided, e.g. original invoice. 6. Not designed or warranted for industrial or commercial use.
DO NOT SEND IN THIS WARRANTY Fill out the following details and file with your purchase invoice. RETAIN & FILE WITH YOUR RECEIPT. Your Purchase Receipt/Invoice is proof of date of purchase. You must be able to present it at the place of purchase to obtain a replacement or service under warranty. Mistral International Pty Ltd reserves the right to discontinue items, modify designs and change specifications without incurring obligation. Whilst every effort is made to ensure that descriptions, specifications and other information in this publication is correct, no warranty is given in respect thereof and the company shall not be liable for any errors therein. Purchased from: Co. Name: Address: Date of Purchase:
NOTE: Consistent with our continuing product development policy, improvements may have been made which render the contents of this package slightly different to that shown.
9/00 17139 Product of Mistral International Pty Ltd ACN 006 680 315 324 Frankston - Dandenong Road Dandenong South, Victoria, Australia 3175 Telephone +61 3 9212 1333 Facsimile +61 3 9212 1340 Internet Address: www.mistral.com.au RINGGRIP (NZ) Pty Ltd ACN 006 771 922 9 Ben Lomond Crescent, Pakuranga, Auckland, NZ Telephone 0 800 328 280 Facsimile 0 800 328 238
Mistral is a registered trademark of Mistral International Pty Ltd.