Professional Documents
Culture Documents
2
CCNA 1
Chapter 2
===========================================================================
Which of the following types of networks pass a token sequentially to each host?
(Choose two.)
Ethernet
*Token Ring
*FDDI
Frame Relay
ISDN
===========================================================================
Which of the following are ways that bandwidth is commonly measured? (Choose three.)
GHzps
*kbps
*Mbps
Nbps
MHzps
*Gbps
===========================================================================
Which of the following are typical features that determine throughput? (Choose two.)
Bandwidth is free.
*Bandwidth has capacity limits.
Bandwidth never increases.
Bandwidth is not a key factor in analyzing network performance.
===========================================================================
Which of the following is the official name for the address assigned to each network
interface card (NIC) by its manufacturer?
NIC address
*MAC address
IP address
Source Address
===========================================================================
Which physical network topology uses a single backbone cable and connects all hosts
directly to this cable?
ring
star
*bus
mesh
===========================================================================
Which OSI and TCP/IP layer appears in both models yet has different functions in
each?
transport
session
*application
Internet
physical
===========================================================================
Which of the following topologies are considered logical topologies? (Choose two.)
bus
*token-passing
star
mesh
*broadcast
hierarchical
===========================================================================
Page 2
1.2
During the data encapsulation process, how is the data broken down by the transport
layer?
packets
*segments
data bits
frames
===========================================================================
Which of the following describe a LAN? (Choose two.)
*operates within a limited geographical area
provides dial-up connectivity
uses serial interfaces to allow operation at lower speeds
*connects physically adjacent devices
ensures single access to specialty hosts
===========================================================================
Which of the following are considered valid types of VPNs? (Choose three.)
internal
* intranet
external
*extranet
local
*access
===========================================================================
Which of the following physical topologies connects all cables to a central point of
concentration?
ring
*star
mesh
bus
===========================================================================
Refer to the figure. What is the maximum possible throughput obtained end to end on
this network when the user on Lab A communicates with the user on LAB D?
The maximum possible throughput is based on the largest connection, the T3.
*The maximum possible throughput is based on the smallest connection, the T1.
There is not enough data to determine the maximum possible throughput.
The maximum possible throughput is the T1 plus T3 speed divided by 2.
===========================================================================
What is the name of the Layer 1 PDU?
segment
packet
frame
*bit
===========================================================================
Which layer of the TCP/IP model encapsulates TCP segments into packets?
application
transport
*internet
network
physical
===========================================================================
Which layer of the TCP/IP model deals with quality-of-service issues such as
reliability, flow control, and acknowledgement?
application
internet
* transport
network
Page 3
1.2
===========================================================================
From the following list, choose the data packaging type that is created at the data
link layer during the data encapsulation process.
packets
segments
data bits
* frames
===========================================================================
Refer to the following list. Choose the correct order of data encapsulation when a
device sends information.
segments
bits
packets
data
frames
1 - 3 - 5 - 4 - 2
2 - 1 - 3 - 5 - 4
2 - 4 - 3 - 5 - 1
4 - 3 - 1 - 2 - 5
*4 - 1 - 3 - 5 - 2
3 - 5 - 1 - 2 - 4
===========================================================================
Page 4