This permit is evidence of permission granted to perform the specified well work at the location described on the attached pages and located on the attached plat. Notification shall be given by the operator to the Oil and Gas inspector at least 24 hours prior to the construction of roads, locations, and / or pits. Failure to abide by all statutory and regulatory provisions governing all duties and operations hereunder may result in suspension or revocation of this permit.
This permit is evidence of permission granted to perform the specified well work at the location described on the attached pages and located on the attached plat. Notification shall be given by the operator to the Oil and Gas inspector at least 24 hours prior to the construction of roads, locations, and / or pits. Failure to abide by all statutory and regulatory provisions governing all duties and operations hereunder may result in suspension or revocation of this permit.
This permit is evidence of permission granted to perform the specified well work at the location described on the attached pages and located on the attached plat. Notification shall be given by the operator to the Oil and Gas inspector at least 24 hours prior to the construction of roads, locations, and / or pits. Failure to abide by all statutory and regulatory provisions governing all duties and operations hereunder may result in suspension or revocation of this permit.
Charleston, WV 25304 (304) 926-0450 (304) 926-{14S2 fax west virginia department of environmental protection March 10, 20 II WELL WORK PERMIT Horizontal WeD Earl Ray Tomblin, Governor Randy C. Huffman, Cabinet Secrcwy www.dcp.wv.gov This permit, API Well Number: 47-6101622, issued to NORTHEAST NATURAL ENERGY LLC, is evidence of permission granted to perform the specified well work at the location described on the attached pages and located on the attached plat, subject to the provisions of Chapter 22 of the West Virginia Code of 1931, as amended, and all rules and regulations promulgated thereunder, and to all conditions and provisions outlined in the pages attached hereto. Notification shall be given by the operator to the Oil and Gas Inspector at least 24 hours prior to the construction of roads, locations, and/or pits for any pennined work. In addition, the well operator shall notify the same inspector 24 hours before any actual well work is conunenced and prior to running and cementing casing. Spills or emergency discharges must be promptly reported by the operator to 1-800-642-3074 and to the Oil and Gas inspector. Please be advised that form WR-35, well operators repon of well work, is to be submitted to this office within 90 days of completion of drilling, as should form WR-34 Discharge Monitoring Report within 30 days of discharge of pits, if applicable. Failure to abide by all statutory and regulatory provisions governing all duties and operations hereunder may result in suspension or revocation of this permit and, in addition, may result in civil andior criminal penalties being imposed upon the operators. In addition to the applicable requirements oftbis permit, and the statutes and rules governing oil and gas activity in WV, thi s permit may contain specific conditions which must be followed. Pennit conditions are attached to this cover letter. Per 35CSR-4-5.2.g this permit will expire in two (2) years from the issue date wliess pennined well work is commenced. If there are any questions, 0 contact me at (304) 926-0499 ext. 1654. .
Chief Operators WeU No: MIP 4H Fanm Name: ENROUT PROPERTIES, LLC API Wen Number: 47-6101622 Permit Type: Horizontal Wen Date Issued: 03/10120 1J Promoti ng a healthy environment. - . : - - ~ - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - dep west vlrginio deportment of environmentoJ protection Oil and Gas Conservation Com.mission 601 sth Street. SE Charleston, WV 25304 (304)926-0499, Ext 1656 Department of Environmental Protection Office of Oil and Gas Charleston, WV 25304 Man:h 3, 20 II RE: Application for Deep Well Permit- API #47061-01622 H COMPA."IY, Northeast Natural Energy, LLC F AR.tv1: Enroute Properties. LLC MIP Unit #4H Earl Ray Tomblin, Governor Randy C. Huffman, Cabinet Secretary dep:wv.org Monongalia QUAD: Morgantown South The application for the above company is APPROVED FOR ORISKA.'NY ONLY. If operatol'" wishes to drill deeper than the ORISKANY, additional approval must be obtained from the OGCe. - Marcellus completion - Inspec/or must be notified prior to plug back. The applicant has complied with the provision of Chapter 22C-9, of the Code of West Virginia, nineteen hundred and thirty-one (1931), as amended, Oil and Gas Conservation Commission as follows: 1. Provided a certified copy of duly acknowledged and recorded consent and easement form from all swface owncrs; NI A 2. Provided a tabulation of all deep wells within one mile of the proposed location. including the API number of all deep wells, well name, and the name and address of the operator; none 3. Provided a plat showing that the proposed location is a distance of 400+ feet from the nearest lease line or unit boundary and showing the following wells drilled to or capable of produciog from the objective formation within 3,000 feet of the proposed location. Sincerely, ~ R C 4 . ~ Cindy Raines Executive Assistant To avoid enforcement action and per 39CSR1.4.6 and 4.10 fding of wells logs aDd directional surveys are due witbin 90/60 days of completion of a deep weU. Promoting a healthy environment. , \ n) 11.1 northeast NA,URA L ENERGY MORGANTOWN INDUSTRIAL PARK #4H/#6H SITE SAFETY PLAN February 18, 2011 BASIC HSE AND DRILLING PARAMETERS Post the rcHawing at location (MUST be i n-hand prior to spud): WV DE? Well Pennit Site Reclamation Plan ("Ree Plan" ) - posted in tube at entrance to location. WV DOT Driveway Permit jf applicable Well site 911 Address Project Goals & Objectives: Safety First: No Accidents - focus on observations & on fostering a proactive safety culiure Protect the Environment: No Spills Regulatory Compliance: No Violations No existing top hole wells on pad at present Well Site Supervisor daily checks: The safety, environmental, and regulatory compl iance are the direct responsibility of the well site supervisor on site. Check rig and location housekeeping daily. Inspect all pits and ensure at least a 3' freeboard is maintained. Proper1y dispose of cuttings and fluids as necessary to maintain freeboard). Inspect and maintain the E&S controls every 12 hours. Record checks on morning report. Notify the Oil & Gas Inspector at least 24 hours prior to commencing well work 1 spud (this includes the setting of conductor casing). Tristan Jenkins-304-55Z-3874 Build location and access road. Install silt fence, silt socks, road breakers, and culverts as per well pad design drawings Excavate and line 4000 bbl cutti ngs pit (with 1/3 diked to segregate Marcellus cuttings).Minimum of 20 mil pit liner to be utilized. Fresh water impoundment (4 MM gallons) to be built and lined (FW impoundment mayor may not be built concurrenUy). MIRU Track hoe with hammer to set 20" LS conductor casing @ 36-40' below ground level into competent bedrock. Ensure conductor casing is plumb with level checks before grouting in place. Install metal cellars 6' diameter x 6' deep. Grout if necessary Install pit liner material undemeath any part of rig or its components that could cause a potential spur of fluids of any type on the ground. The edges of the pit liner must be bermed so as to contain such an evenl Topho/e Rig (Ideco H-37 or equivalent). Rig to have a minimum of 3000 scfm air capacity. Perform pre-spud rig safety inspection. Set and pull test anchors and guide lines. Review latest inspection records of DP, DC's, and subs/xo's. Drill rathole/mousehole. , WW-2B (Rev. 8/10) STATE OF WEST VI RGINIA DEPARTMENT OF ENVIRONMENTAL PROTECTION. OFFICE OF OIL AND GAS WELL WORK PERMIT APPLICATION I 1Gr3n! I So. 1) Well Operator Northeast Natural Energy, LLC Operator 10 County District Quadrangle 2) Operator's Well ___ ___ _ 3) Elevation: __ 4) Well Type: (a) Oil, __ or Gas X (b) If Gas: Production _x_, Underground Storage ___ _ Deep X 1 Shallow _ _ _ 5) Proposf3d Target Formation(s): Marcellus Shale Proposed Target Depth: ,:,75:,:50.:.' __ 6) Proposed Total Depth: 8COO'TVO 7) Approximate fresh water strata depths: _ JOO' ,/ 8) Approximate salt water depths: ....:.',.,=-_________________ _ 200' - 250' ./ 9) Approximate coal seam depths: _ _ _________ _ 10) Approxi mate void depths.(coal, Karst. other): ....:: N:::o".:: o'-______ ____ _ 11) Does land contain coal seams tributary to active mine? "N:.:,o _ _____ ___ _ 12) Describe proposed well work in detail Drill and complete a horizontal Marcellus well . Drill vertical section (0 approximately three hundred feel below the base of the Marcellus for Ioggir.g purposes, plug back the vertical section with cement to the kick off point and drill the horizontal se<;tion to a measured depth of 11,456 feet 7 13) CASING AND TUBING PROGRAM TYPE SPECIFICATIONS FOOTAGE INTERVALS CEMENT Size Conductor 20" Fresh Water 13.375" Coal Intermediate 9.625" Production Tubing Uners Packers. 5.5" Kind Sizes Depths Set Grade Weight Qer ft J-55 94 # J-55 54.5 # J-S5 36# P-110 20# For Drilling 36' 450' 1550' 11,456' Left in Welt (Cu. Ft.) 36' Grout to surf. 450' CTS ./ 1550' CTS 11,456' 3138 cu. ft.
.. - -, .. ........ Office of Oil & Gas FE8 09 20 11 WV Department of EnVironmental Protection WW-2B (Rev. 8110) -- . , - \ .. -.:. -.. '. " OffiCe of C!l S. GaE FFR 11 1011 1(0,'1/ Deps.;tment of Environmenta! Protecti n STATE OF WEST VIRGINIA DEPARTMENT OF ENVIRONMENTAL PROTECTION. OFFICE OF OIL AND GAS WELL WORK PERMrT APPLICATION 1) Well Operator Northeast Natural Energy, LLC I 1\bi8nklwn So. Operator 10 County District Quadrangie 2) Operator's Well ______ _ _ 3) Elevation: _ _ 4) Well Type: (a) Oil_ or Gas_,,-x __ (b) If Gas: Production I Underground Storage __ _ Oeep X I Shallow __ _ 5) Proposed Target Formation(s): Marcellus Shale Proposed Target Depth: .:;75::50'''---__ 6) Proposed Total Depth: BOOO'TW Feet Formation at Proposed Total Depth: _ _ 7) Approximate fresh ... tater strata ::""'================= 8) Approximate salt water depths: _ 7&:: 9) Approximate-coal seam depths: _ _____ _ ___ ___ _ 10) Approximate void depths,(coal , Karst, oUler): _ _ _ _______ _ 11) Does land contain coal seams tributary to active mine? _________ _ 12) Describe proposed well work in detail Drill and complete a horiZontal Marcellus well. Orin vertical section to approxi mately three hundred feet be/ow the base of !he MarceUus for logging purposes, plug back the vertical section to the kick off polnland C!rill!hc hOrizontal section to 8 measured depth of 11,458 feel CASING AND TUBING PROGRAM 13) TYPE SPECIFICATIONS FOOT GE I A NTERVALS Size Conductor 20" Fresh Water 13.375" Coal , Intermediate' 9.625" Production 5.5" Tubing Liners Packers. Kind Sizes Deptns Set Grade J-55 J-55 J-55 P-110 Weight For Drilling Left in WeI! 94# 36' 36' 54.5# 450' 450' I 36# 1550' 1550' 20# 11,456' 11,456' I CEMENT Fill -uQ (Cu. Fl,} 1/ . Grout to surf: CTS , n q.. CTS
3138 cu. ft. Scientific Drillin(L . . . , , , J , _. _.1. o , , . ' .- - i - ' , .. r: i... :.. 1 . --; -, -- . , . \il- DIll? W Project: Morgantown Industrial Park Site: Morgantown Industrial Park Unit Well: MIPU#4H III northeast Wcllbore: Original Well Design: Design #1 '''' ,. - 1. ! t .. ',-" -.. . " ; . , .. , M,lPUII4H :- -,. TO II 11456.9-
ll'<Illoll7l.*HSlatIoO'l,)Oolll, \'''-(I"o'DI_ So 110" 100II I lOS' GI.J _(VS) R.l= $Io<1IClP\IMB(\10KC,CD lo"-"'>:!)ore So ltD II&$' aJ CtIeo!D:I!o _ . _ .,-! ... !:!--------'==,.,.,--------! Sf.CTU)t; OTAIU * M> -sI-$ +t/ ..,.. .. ,,- ,.. '- , .
.. I!!M . .. ..
, 1001$.7 .. '104s. 7 ..
..
=,
"'u
"0$ lC1lJ) , mu 1010.:) .<6l.1 lll.. @.
n4"U u . 140.1) 77' 1.' .JUl.l _. oo.u &0$1.9 _m 8 Vertical Section 140.5JO (10Cl0 usflfin) , , .' WW-2A1 (Rev. 8102) 1-\ Operator's Well Number "M"'IP-''''"H''-_ _ ________ _ INFORMATION SUPPLIED UNDER WEST VIRGINIA CODE Chapter 22, Article 6, Section 8(d} IN LIEU OF FILING LEASE(S} AND OTHER CONTINUING CONTRACT(S) Under the oath required to make the verification on page 1 of this Notice and Application, I depose and say that I am the person who signed the Notice and Application for the Applicant, and that (1) the tract of land is the same tract described in this Application, partly or wholly depicted in the accompanying plat, and described in the Construction and Reclamation Plan; (2) the parties and recordation data (if recorded) for lease(s} or other continuing by which the Applicant claims the right to extract, produce or market the oil or gas are as follows: Grantor, lessor. etc. Enrout Properties, LLC Grantee. lessee, etc. Royalty BooklPage Northeast Natural Energy, LLC 18.5% i , RECEIVED Office of Oil & Gas FEB 08 2011 yvv Department of EnVironmental Proteotion Well Operator: Northeast Naruml Energy, LLC 14201577 By: Brett Loft in
State of West Virginia Department ofEnvirorunental Protection Office of Oil and Gas Well Work Permit Application Addendum (To be completed when fl ui d vol umes used or disposed may be greater than 5000 barrels) I) Well Operator Northeasl Nalural Energy LLC 2) Operator ID # .:':: "'::"::::"::' _ _ _ _ 3) Operator's Well Number cM:: "..:" ::H"---_ _ _ 4) County ,,""""' =,,",,""-__ _ 5) Approximate Amount of Water to be Used (bbIS.) 119,050 6) Fracture/Drilling Water Source (estimate % of each source to be used) 20% Surface Water _ _ Groundwater SO% Purchased Water _ _ Reused Water 7) Location of Surface Water Source (if applicable) a) County .-=""'=00::'''''7''''-----,-,---_ Water Source Name MOl1Ql'1gahela Latitude Cd/mls) lUes! 36 m'" 12.024 He Longitude (d/mls) 11 dog S7 IN! 47.484 ~ c : NAD83 x or NAD27 _ _ _ _ _ b) Anticipated month(s) of water withdrawals .: ':::",-Y..: " J::"":::,=--_______ _ 8) Location of Groundwater Source (if appl icable) a) County :=::-::-""=,;;;_ Water Source NameJID ___ ~ ; - - . , . Latitude (d1m/s) Longitude (d1m/s) _____ _ NAD83 or NAD27 ____ _ b) Anticipated month(s) of water withdrawals _ _________ _ 9) Location of Purthased Water Source (if applicable) PublicIPrivate Water System Name Mort;antown Utility Board 10) Location of Reused Water (ifappLicable) County _____ _ WelllFacility ID _ _ _ _ _ _ Page l of 2 11) Will Cencralized PitsIPonds Be Utilized -----yes _ x_no Location (if applicable) Latitude (dlm/s) Longitude (dlm/s), _ _ _ _ _ _ Dimensions in Feet (if applicable) Length Width Depth _ _ _ _ NAD83 or NAD27 _ _ __ _ 12) Water Disposal Method (estimate % each facility is to receive) __ Land Application _x_UIC-provide UIe permit numberUIC20085515 (75%) __ POTW- provide facility name _ _ _ ___ _ _ ___ _ __ 1\'PDEs-provide permit number;::-;;:;c::;;;;:;-__ _ x_Other AdvliIncad Waste Services (N_ Calli . PAl (25%) Fo:m WW_9 Operator', Well No. MIP #4H O ' '''''''",n " ',, ,,' """,/11"" ,(, ,,,,, ,,= ====- < - ,, - I'C"c .. _ , __ ,_ , __ O .. Ptve ... !lh ,n _ .. S" .. , .. n r-" ... ;'1",-... -. .,., __ . ,"'f .' ' n . . .. E-+ E--+ 6+ E-- OpcnOu"h _ . . + __ .. .". _ .. ...,.. C","'O .... ln t I I I ! 2 I I I I I Z t I I I R=k
"'" I Seed TYi'e Kentucky Bluegrass Red Top Whi te Clover Attach: lbs/acre 20 15 15 Area n -'0 (\l Type los/acre % % __ ____ Red Top 15 g '--------'-'---- White Clover 15 - Ol3wi:lg{s)o:road, loc:lion,pil and proposed area for land appli eation, PnotOCClpier;! section ofinvolvcd 7.5' topographi: $heel. -\ I , . , , ..' .e. ?!an A;proved by:' ___ ______ _ Comn::ents: _ _ __ __ 1 " , ' " T f',. ! " , , _ ',' ",1" r. ., , <.1 J lIte:...:, .,:';" C' j,c..:; :.:"'f." :.c''::'''::'''':''''-_ o""'_'.t-J ufc'-, b""I.:... 1 ____ _ Field Reviewerl?
L_-') No SCALE BAR (1"= 100') 0' 100' i!OO' 300' .- ----- "", __ u ' -'" .W._"II'O!; U:>)N;S P:I:> 5u!(......ns 'ON! "oossv pue )l3HON39 - S'i3 " , , l .', - - = , Attachment A to WW-9 Initial plans are to drill two horizontal wells Marcel1us Shale wells on the same pad; the Morgantown Industrial Park #4H (MIP#4Hj and the Morgant own Industrial Park #6H (MJP #6H). If successful, four more horizontal Marcellus wells will be drilled from the existing p a ~ . The cuttings fr9m the MIP #4H ~ i l l be treated and solidified for removal and transport to the landfill listed on the WW9. The drill cuttings from the MIP #GH may be treated and sol idified with Portland cement, covered with synthetic liner and buried or treated and solidified for removal and transport to the landfill. Some flow back fluids from the completion operations on the MIP #4H may be treated and re-used in the M1P# 6H. Drilling fluids will be recycled/reused in the drilling of subsequent wells. Any fluids in the drill pit (drilling fluids and formation water) will be either treated and land applied as per regulations or transferred to the flow back pit/tanks for reuse or disp0S;<lI. RECEIVED Office oj Oil & Gas E3 0 S ,0\\ WV Department of . Environmental Protection '. \ ':. j ,.
.- .,- .. ,- -' -. :, . . :., .. z BOORD, 8ENCHEK and ASSOC .. INC. SITE PLAN Engineering. Surveying. Construetion. ond Mining Serviee. \!\311 ""-on_, (f) n J> r [T1 :; "CD J> ;u , / o o , , , , / , , , , I , , I , ; , , , , , I , , , , , , , , , , , , I , :2 ROAD AND E&S PLAN BOORD, BENCHEK and ASSOC . INC. Engir'leering. S v ~ n g . Constructic n, and Mining Services Soulhf)O;"t PA IS31' Phon4!: 7Z.-&2!t-o.t21 .NyU] 1 . .... '>1<11 " ']
,
,
, ,ooe ,002 (,OOl= .. l) - ..... -- ,001 ,0 3l\lJS z . ""''''''''', ....... 'U= .. ,. ... - .. - 1',.1'1 "' .. J ..... _ J _ ,. .. , ........... iIN. no _ ' _0_ ... t_UJIOOU __ _ .... ' .... ).01""""'. mlOt><WJI:W1'un "" lAn : .. ',... _ ) _ 1Ul(" :' ... ,,,J)WI"' .oo. . _ _ 0- :GNH03'1 EMERGENCY CONTACTS 1) FIRE DEPARTMENTS MORGANTOWN WV 304-983-2000 WESTOVER WV 2) AMBULANCE !EMS MON EMS 304-5990650 JAN.CARE AMBULANCE SERVICE 304-296-9700 3) LIFE FIGHT AMBULANCE SERVICE (HELICOPTER) ANGEL MEDFLIGHT 866-604-8307 4) HOSPITAL RUBY MEMORIAL HOSPITAL 304598-4000 5) STATE POLICE MORGANTOWN DETACHMENT 3042853200 6) MONONGALIA COUNTY POLICE MONONGALIA COUNTY SHERIFFS OFFICE 304-2917290 7) WV DEP/OFFICE OF OIL AND GAS CONTACTS TRISTAN JENKINS.INSPECTOR JAMES MARTINCHIEF DAVE BELCHERINSPECTOR SUPERVISOR DAVE BELCHERCELL PHONE 304-5523874 3049260499 EXT 1654 3049260499 3043897590 8) NORTHEAST NATURAL ENERGY LLC CONTACTS JOHN ADAMS-VP OF OPERAnONS BRETT LOFLlNVP OF REGULATORY AFFAIRS 304-414-7077 304-4147073 DAVE McDOUGALMANAGER CIVIL ENGINEERING 304-941-5033 KEVIN STILESDRILLING CONSULTANT 304-2161083 9) DRILLING CONTARACTORS TRINITY FRYLES WiLSON DRILLING TOM FLYNN.YOST DRILLING 10) KEY CONTRACTORS AND VENDORS BJ SERVICES-CEMENT/PUMPING SERVICES HALLIBURTONCEMENT/PUMPING SERVICES 6183846383 724-998-0224 304-624-9802 888-223-4255 11) BUSINESS AND RESIDENCE IN AREA OF REVIEW (One mile radius of proposed well location) American Environmental Service - (304) 292-0659 2100 Georgetown Drive, Sewickley, PA 15143 Azimuth, Inc. - (304) 292-3731 3741 Morgantown Industrial Park, Morgantown, WV 26501 Blackhawk Interiors .. Joe Whipkey - (304) 292-4011 3500 Morgantown Industrial Park, Morgantown, WV 26501 Chemtura Corporation - Lynn Unger - (304) 296-2554 1000 Morgantown Industrial Park, Morgantown, WV 26501 Dominion Resource - Todd Sackett - (304) 2882702 2800 Morgantown Industrial Park, Morgantown, WV 26501 Easley and Rivers - Kathy Bryce - (304) 291-6803 3800 Morgantown Industrial Park, Morgantown, WV 26501 Global Land -Lenard Satterfield - (845) 35g.0444 Radio Tower Blue and Gold News - (304) 2912242 3715 Morgantown Industrial Park, Morgantown, WV 26501 Javins Corporation - Debra Javins - (304) 292-3234 2000 Morgantown Industrial Park. Morgantown, WV 26501 John Summers - (304) 216-1155 4400 Morgantown Industrial Park, Morgantown, WV 26501 Make-AWish Foundation - Bobbi Spear - (304) 2925600 3711 Morgantown Industrial Park, Morgantown, WV 26501 PS Management - Brian Shaffer - (304) 685-4953 P.O. Box 839, Morgantown, WV 26501 M.T.S. Company- Mike Blosser- (304) 284-8777 2201 Morgantown Industrial Park, Morgantown, WV 26501 wvu Storage - Jim Harvey - (304) 293-6851 1000 Dupont Road, Morgantown, 'WV 26501 Sears - Brian Edmiston - (304) 2765848 2208 Morgantown Industrial Park, Morgantown, WV 26501 CSC Pete Scott - Pete Scott - (304) 292-1340 31 Jo Glen Drive. Morgantown, WV 26508 WV United linen Service - Art McDonald - (304) 216a7644 FI 2100 Rail Street Morgantown Industrial Park. Morgantown, WV 26501 Central Supply - George Finley - (304) 292-55n 3100 Morgantown Industrial Park. Morgantown. WV 26501 Staley Communications - Challe" Matthews - (304) 280$-.0110 1902 Morgantown Industrial Park. Morgantown, WV, 26501 Flint Industries - Mike Lovell- (304) 292-0041 451 North Metro Drive. Morgantown, WV 26501 Learn Industries - Cart Benwal- (713) 20&.0249 200 Metro Drive, Morgantown, WV 26501
Greenscape, Inc. - Doug Stork - (301) 616-8120 Westwood Middle School- Lynn Haney - (304) 291-9300 680 River Road, Morgantown, WV, 26501 Sky View Elementary School- (304) 284-2890 668 River Road, Morgantown, WV 26501 ISA Molecular - Jesse Deavers - (304) 292-2240 3601 Morgantown Industrial Park, Morgantown, WV 26501 SST Trucking (Riverfront) - Rob - (304) 292-445 Rainbow Intemational- Darrell Phillips - (304) 291-6445 2202 Morgantown Industrial Park, Morgantown, WV 26501 Roto Rooter- Brian Stout - (304) 296-7686 2203 Morgantown Industrial Park, MorgantOwn, WV 26501 Core Building Solutions - Chad Matheny - (304) 376-1940 2200 Morgantown Industrial Park, Morgantown, WV 26501 WELL CONTROL EQUIPMENT YOST DRILLING-TOPHOLE CONTRACTOR BOP-REGAN ANNULAR TYPE 11" 3000# LES WILSON DRILLING-HORIZONTAL CONTRACTOR ANNULAR BOP-SHAFFER 11" 5M DOUBLE RAM BOP-SHAFFER 11" 5M CHOKE MANIFOLD-4 1/16" 5M CASING PLAN MORGANTOWN INOUSTRIAL PARK WELL, #4H COUNTY: MONONGAliA STATE: WV CASING SETTING CAPACITY ANNULAR SIZE CASING SIZE DEPTH CF/UN FT HOLE I CASING 20" 36 I 1.9947 0 I 13-318" 0.8679 450' 17.5 20' 9-5/8" 0.4257 1550' 12.25 13-318" 5--112" 0.1245 11,456' 8.75 9-5/8" MIP 411 Weal Vir ginia Monongalia Oranl NORTHEAST NATURAL ENERGY FEB 115 2011 pormlt Humber: P.rmlt Inuod: Ground Elovatlon: Kolly BUlhlng: 1130' 114l5' Morgantown South Rig: Las Wilson 30 Surface: Li t '" 3U.602286 N & l ong - 79.976411" W (Sl alo Plano WIJ Not1h NADB3) "Spud" OlIO: TO Date: Rig R, I, .. o Oat.: FORMATION WElL80RE CASINO &CEMENTINO OATA
!tOLE TOPS DIAGRAM DIRECTIONAL DATA TYPE DEV. i t
41' Ma124' DOL) CONDUCTOR PIPE Vort 10" 11 316' wall US PE (Mil" becllOCk & sanded In) P1rlsbucgh COill "" N" 1 Alr/MI't UO' CONDUCTOR CASINO V. rl I 13-318"54.51 J.SS OTC 0 450' MOITV!) SI!I through kesh ....alel zones ;1 Set l/lfOUOh GOaI IOOU Air II,U! I I Cemented III Go". 1495 TVD , , uso' SURFACE CASINO "" 0-6/8' 30.01' J.S5 LTC 0 '5$O'MO/TVO Set through jIIlIentlat water zoou Set below base 01 Ganu: Ctmenlitd 10 IUlface G .... ISH' TVO eCSHIW'!.!lID I1RII EE flu: Gln.fllinfo: MUd l ogoglno: from 3000' 10 1 0 TOp Itole Rio: Yost Orll'Mg Cotlng: _ ll orilOtllll RIg: Lea Wilaon 30 Open IklIe Wtrellneloggilll)"lOT,CNl Oll Pact l1o1e for logs (yost Otillng) ECS-FMI AI . /OIl1l I MWO/lWO; GM'WO after KOP l a"rallt ngth - 3500' SJ)tI!cNey 211 T TVO 10-,tlrgtl.IlckWille. rlilC 1lal:1I)wn 29, O' M) '0' 104S"1VO V, rl , 0' "lVO ,,\." .. ... , .... FOl m lO , (1 1\'0 \ 0 ..... .0 TlMylS 1260' IV!) Mud .tltlelo ..... H/ImIl ron She!e n;wTVO G,n ... o M!lrcel lu. Shole 76!i0' 1VO i' ./- 13.5 PIID WIIM In l i l .. ... 0n0n<\I\l3 l S 7MO" 1VD \ 10 Cil 11U2' TVO H'... Chert , ... NO ludlng PoInl tLPI @I nn' 1.10 17120' TVO pRODUCnON CA51MB Driskilli)' Sa.-.:lslooe 1850' l VO 81' anI/II 6112" 10.0' p. , 10 CDC G: 11400" 1.10 177.2' TVO PJQlllole TO ."'" - )U' azlmulh CEMENT II 111' CASI NG TO SURFACE Tap. TVO , , Pililbulih Coal 200' lUg InJun l osr GanlL Gordon '87>1' Spe:edlley 27' 1' lIa.town 2910' TuDy l S "' .. Hamilton SlIera ".,. Man:.eIYI Sh;;)10 1660' b - Dnoodaga lS " ... \ Hunlel'511i11 0 Chel 11180' 0 - Orl!kany SBnclslon 7850'
Ii(
, NORTHEAST NATURAL ENERGY-WelL CONTROL EQUIPMENTMIP PAD 11" 5000 PSI SHAFFER ANNULAR Annulu BOP I II Ind Modell _ .... ~ , .... ,. r , ' ~ 11" 5000 PSI SHAFFER DOUBLE RAM BOP Ihnt BOP I., end Mod,11 - ... ....... ' 1 31/8" 5000 PSI CHOKE MANIFOLD &iii en B 4 ' B t ~ c;;- - I o - c;;" ~
Casing Collapse
I Strength (psi) x } /S" Wan N/A I NlA NlA i NlA 1:>-3/S" 54.50# . 11130 12730 853 ' 51'
: 2020 13520 564 ' 453 5-112" 20.0# P-110 CDC 111,100 12,360 641 667 Casing Nominal 10 Drift 10 Conn 00 MU Torque (f't.lbs) Min Opt - MaX 20 x 318" Wall 19.250' 19.062" N/A 1 N/A 13-318" 54.5# J-55 STC 12.615" 12.459" 14.375" ' 5140 9-5/8" 36.0# J-55 LTC 8.921" 8.765" 10.625" 3400 - 4530 - 5660 5-1/2" 20.0# P-110 CDC 4.nS" 4.653" 6.050' 5000- - 7500 Drill Pipe Specifications S" 19.5# G-105 4-1/2" IF is recommended (used pipe, premium class) Tensile Capacity = 436,150 lbs Torsional Capacity = 45,199 ft-lbs Collapse:: 8765 psi Burst= 12,163psi Adjusted weight per foot = 21.92# New Tube Nominal 10 :: 4.276" New T J 00 = 6-5/S" NewTJ ID; 3-1I4" New T J Drift :: 3-118" NewTJ MU Torque:: 31 ,025 ft-lbs Min 00 T J ; 6-3/32' MinODTJMUTorque=21 ,914ft-lbs Interchangeable Connections: NeSO, S" XH, 5--1/2" DSL U\-OIl9 Northeast Natural Energy 1----26 ... " --_-I " 2" LP 8 8 . 2 ~ 10M 27.2" to It --+-- 18.S- 9-5/8" Casing Casing LJ"-'I'S" Tubing , Thl, lira .... ; it the Pr<lpcMy of Wood Crvup Prealilre Control ond i. considered c:onfidMtid. :':;,,1- o ~ ~ cpproved IT! writinq. ",Itheor It nor its eontents me)' b, uMd, copied. tronlDTlitted or nproc!UCDCI ncept for the sole pUrpo')e of Wood croup Pressure Control. WOOD GROUP PRESSURE CONTROL 9-5/8" X 5- 1/2" X 2- 3/8" 10/ 5M S95 Wellhead Assembly, With MTH-2-S95 Tubing Head, MTH Tubing Hanger and MTH Adapter Flange DRAWN .APPRV DRAWING NO. PROPOSED VJK 18MAY09 THH 18MAY09 AE16964
Well Flaring Operations !he will be drilled with drilling mud in an overbalanced manner. No flaring while drilling IS Post fmc, a flowback system consisting of 2" 1502 piping, a 5000 psi choke marufold, separators/fluid handling equipment, and a 30' flare tower will be deployed and utilized. The flare stack will have an electronic ignition system and will be deployed approximately 150' downwind of the wellhead. Wen Killing Operations As previously mentioned, these wells will be driJled in on drilling fluid in an overbalanced manner. Should a kick be detected, the well will be killed by the lADe approved ' 'Weight and Wait" method. Bottomhole pressure will be calculated from SIDPP obtained post-kick", and the drilling fluid density will be increased by adding Barite (weighting material) to the system and circulated throughout the wellbore. The well will then be checked for flow; and if none is detected then drilling operations will res1.ttJ1e. H2S Operations Mudloggers will be utilized during drilling operations after the intermediate string of casing has been set. If H2S is detected by the mudlogger, an alarm will be issued to notify personnel on location of the presencc ofH2S. Personnel shall evacuate to the designated area. The designated area shall be determined at each tour change and will be dependent on current wind and weather conditions. The proper offsite notifications will be made once an accurate head count is confirmed and personnel are located in a safe area. Muster areas will be uphill and upwind of the well cellar per proper H2S protocols. The nearest occurrence of H2S in this area was detected in the late 1960's on a deep well drilled near Uniontown PA on the Chestnut Ridge anticline. The H2S was encountered in the Salina formation, nearly a thousand feet below the Marcellus. No H2S is expected to be encountered in the MIP wells. ,
" BOORD, BENCHEK.rod ASSOC .. INC. En9",HMg. C9mtnlclOn, ond S.MCH $c>.J\. ....... "" -.: ,
] .. 3 LONG,) 79"58'35.8' DEC. LAT.) .39.602203 DEC. LONG,) 79.971562 LONG.) 79'"58 35.1 " DEC. LAT.) DEC. LONG,) 7g.g7641 , ... ", ... - ,- TAX IW' Me) 'J.lCO. .... - .""'-" -.at! JQJii tIoIO Z7) N) E) 1868295.7 LAT.) 39'35'36.9" LONG.) 79'58'02S DEC. LAT. ) 39.593588 'OEC. LONG.) 79.96735" aam:If HC:U!INIO Il1O N) J985e8.5 E) 18368!S!iI.2 LAT.) 39"35'37.2' LONG,) 79' 58'01.7" OEC. LAT.) 39.!;93671 EC. LOOC.) 7e.95714: 14--&1/30 acm . ".' ..... - . -.....a..._""'PoIo " .-1:101' ,;' --_. " ., _ c I.oMoot lor_ ,,' ... -... . I,THE UNDERSIGNED, HEREBY CERTIFY THAT THIS NNt.UV't PLAT IS CORRECT TO THE BEST OF MY KNOWLEDGE AND - ", BELIEF AND SHOWS ALL THE INFORMATION REOUIRED BY ' "-1200' LAW AND THE REGULATIONS ISSUED AND PRESCRIBED BY II . .... r-r-nr-r- \>'V\III;. \H';' I L L.S. #2124 : Emest J. Benchek III (+) DENOTES LOCATION OF WELL ON UNITED STATES TOPOGRAPHIC MAPS WVDKl' DATE: FEBRUARY 02, 2011 OFFICE OF OIL & GAS 601 51fII STREET CBA.RLFSl'ON, WV Z5304 Well Type: DOil 0 Waste DiposaJ CfroducUon Il:I Gos 0 Liquid Injection OStoroge )Ill Deep IJ Shallow OPERATOR'S \\ll #: "IP UNIT NO. 4H API \\ll N: 47 STATE 61 COUNTY O t<,,;t ;<Jt PERMIT WATERSHED: DUNKARD COUNTY /DISlRICT: MONONGAUA!GRANT SURFACE OWNER: ENROUTE PROPERTIES LLC. ElEVATION: 1,130' QUAORANGLE: MDRGANT""'='O"'W"N-=S"O"' UTH :-------- ACREAGE: 65.796 +/ - OIL & GAS ROYALTY OWNER: fNRQUlF PRQPERTIES I I C, ACREAGE: 794.0 +/- LEASE NUMBERS: _ ___________ _ ADDRESS: 707 VIRGINIA STREET - ;'VII to PtW ""' .... " ........ . ' V' . .. ,,,,,M - ." ,rrr . Ann CITY: CHARLESTON liP CODE: 25301 CITY: CHARLESTON STATE: l iP CODE: 25301 ; WW-2A Surface Waiver SURFACE OWNER WAIVER County Operator Operator well number INSTRUCTIONS TO SURFACE OWNERS NAMED ON PAGE WW2-A The wen operator named on page WoN2A is applying for a permit from the State to do oil or gas weU work. (Note: If . !he surface tr.lct is owned by more than three persons, then these malerials were served on you because your name appeared on the Sheriffs tax ticKet on the land or because you actually OCct.Ipy the surface tract In either case, you may be the only owner who wilt actually rece.ve these materials.) See Chapter 22 of Virginla -Code. Well work permits are valid tOr 24 months. 11 you do not aim any interest In the surface tract, malerials to the true owner immediately if you know who it is. Also, please notify the well operator NOTE: YOU ARE NOT REQUIRED TO FILE I O1ief, Office of oa and Gas FEB 1 0 1011 Department of Environmental Protection 60157" Sl SE Charleston. W, 25304 'NV Deoartment of (304) 926-0450 I=nvirnnmer.t"j P-nt o .... ; Ti rM Limits and methods for fili ng comments, The law requires these rr.a'tenaIS1b fit;; S'et'1a1 onl Ofb'e'ft:l'i'E! CiNel date the operator files hIs Application. You have FIFTEEN (15) DAYS after the filing date to file your comments. Commenls must be tiled in person 0: received In the mail by the Chiers office by the time stated above. You maycaU the Chiefs office to be sure of the date. Check with your postmaster to ensure adequate delivel'J time or 10 arrange special expedited hand:ing. If have been contacted by the well operator and you have signed a ..... oluntary statement of no objection" to the planned work described in these materials, then the permit may' be issued at any time, Comments must be i n writing. Your comments must include your name, address and telephooe number, the wen operator's name and weU number am:! the approxfmate location of the proposed well site including district and county from the application. You may add other documents, s:.sch as sketches, maps or photographs to Support your comments. The Chief has the power 10 deny or condition a well work. permIt based on comments on the fOlIo'Ning grounds: 1) The proposed wen wor\( constitute a hazard to the safety of persons. 2) The soli erosion and sediment control ptan Is nct adequate or effective; 3) Damage oecur to publldy owned lands or resources: 4) The proposed wei! work fails to protec1 fresh water sources or supplies; 5) ll1e applicant has committed a substantial violation of a previous permit or a substantial violation of one o. more of the rules prom:JIgated uncler Chapter 22, and has failed to abate or seek review of the violation ... . If you want a copy of the permit as it is issued or a copy of the or der denying t he p ermit, you should request a copy from the Chi ef, List of Water Testing l abomlOf'igs, The Office maintains a list of waler testing labcratories which you can hire 10 tesl your water 10 establish waler quality prior to and after drilfing. Contact the Chief to cbtain a copy. VOLUNTARY STATEMENT OF NO OBJECTI ON I hereby state that I have read the instructions to surface owners and that I have received copies of a Notice and Application for a Well Work Permit on Form WW2-A, and attachments consisting of pages 1 through _ including a work order on Form WW2.f3, a survey plat, and a soil and erosion all fer proposed wen work on my surface land 2S described therein, J I further stale that I have no objection 10 the plariged worl< descritled in these mal erials, and I have no objeclion to a permit being Issued on those materials. FOR EXECUTION BY A NATURAL PERSON ____ --,,::=:;:-::::-_____ Dato Signalure Print Name FOR EXECUTION BY A CORPORATION, ETC. Company r _ f) _ _ -,, __ Name Ct>J/{MI rlUt (7Vi() j Lu: _ By &!(;N" T tl lit'-"".,J '. Its . Signawre Date ... " . WW-2B (Rev. 8110) DEPARTMENT OF OF WEST VIRGINIA TAL PROTECTION WELL WORK PERMIT OF OIL ANO GAS 1) Well Operator Northeast Natural Energy LLC - 5 , I I <lgs Monongar.a !Gf"II nt I 4) Well Type: (a) Oll, __ or Gas X 3) Elevation: 1,130'. -'--'-'-- (b) If Gas: Production I Underground Storage '-- Deep X I Shallow __ _ 5) Proposed Target Fonnation(s): Maroellus Shal. Proposed Target Depth: 7550' 6) Proposed Total Depth: 8OOO'1VD Feet !;ormation at Proposed Total Depth' Ori;::",'-,C:,- -- 7) Approximate fresh water strata depths: 300' ./ . ==. --- 8) ApprOximate salt water ___ --:T _____________ _ \.:;I 7 9) Approximate coal seam depths: 2=50::... _____________ _ 10} Approximate void depths,(coal, tGt. None
11) Does land contain coal seams to active mine? .:..N"o _________ _ 12) Describe proposed well work in detail Drill and complete a horizontal Marcellus welt. Drfll vertical section to approximately three hundred feet below the base of the Marcellus for logging purposes, plug back the vertical section to the kick off point and drill the horizontal section to a measured depth of 11,456 feel 13) CASING AND TUBING PROGRAM Conductor Fresh Water Production Tubing liners 9.625" J-55 5.5" P-110 Sizes Depths Set 36# 20# 1550' 11,456' 450'y CTS 1550' CTS 11,456' 3138 cu. ft. Office of Oil & Gas FEB 08 2011 WW'2A Coal Waiver County ",'''"- COAL OPERATa R, OWNER, OR LESSEE WAIVER Operator Northea$l NalUtar Energy,LtC Operator's Well Number MIP/t4H INSTRucnONS TO COAl OPERATOR, OWNER, OR LESSEE . To coal owner, or named on page WW2-A You are hereby notified that objection you wish to make or are reqUIred to make by WV Code 16 or 17 must be filed 1Mth the Chief of the Office of Oil and Gas within fifteen (1 5) days after the receipt of this application by the Office. Mail objections to: - RECEIVED Office . : Gas Department of EnvironmentalProtection 601 57'" Sl SE Charteston, WV 25304 (304) 926-0499 extension 1654 WAIVER Office of 011 & Gas FEB 1 5 1011 WV DeQartment of Environmental Protection The coal operator _, owner _' __ I lessee __ , of the coal under this well location has this proposed well 'location. If a mine map exists which covers the area otwell locati on, the well location has been added to the mine map. The undersigned has no objection to the work proposed to be done at this location, provided, the well operator has complied with aU applicable requirements of the West Virginia Code and the governing regulations. . FOR EXECUTION BY A NATURAL PERSON ___ _____ Date Signature 'iN 11f Oat. 1\( -
An Integrated Drilling and Geomechanics Approach Helps To Successfully Drill Wells Along The Minimum Horizontal Stress Direction in Khuff Reservoirs PDF