Professional Documents
Culture Documents
2 18:02 Page 1
Short terminal A
■ PRECAUTION Loading coil A
Base element Short terminal B
R WARNING: HIGH VOLTAGE!
NEVER touch the antenna element/wire while tuning Loading coil B
or transmitting. This may result electrical shock or burn. Short terminal C
Loading coil C
R WARNING SUSPEND operation immediately or Short element
NEVER put up the antenna when thunder occurs or Short terminal D
can be heard in the distance.
Loading coil D
R WARNING NEVER assemble or disassemble the
antenna at any crowded area. A person may be in-
Short terminal E
jured.
USE the AH-703 for portable operation with the IC-703
ONLY. NEVER install the antenna to a vehicle for mo-
bile operation.
DISCONNECT the antenna when not using the an-
tenna for long period of time.
Antenna connector
DO NOT use chemical agents such as benzine or alco- (PL-259 type)
hol when cleaning, as they can damage the AH-703.
READ THE IC-703 INSTRUCTION MANUAL FIRST
before attempting to operate the transceiver.
■ Antenna specifications
■ Supplied items • Frequency coverage : 7, 14, 21, 28 and 50 MHz bands
• Type of antenna : 1⁄4λ type whip antenna
Top element Base Allen wrench • Antenna connector : PL-259 (50 Ω: nominal)
element • Max. input power : 20 W
• Total antenna length : Approx. 1,390 mm; 4.6 ft
(at the longest element length)
• Weight : Approx. 330 g; 11.6 oz
(without grounding wires)
Grounding wires
Set screw
Icom, Icom Inc. and the logo are registered trademarks of
Icom Incorporated (Japan) in the United States, the United King-
dom, Germany, France, Spain, Russia and/or other countries.
AH-703.qxd 03.10.2 18:02 Page 2
;
• Keep the separation cable on the outside of the LC-156.
;
;
;
AH-703
controller case
;
;
;
IC-703
t Repeat the steps e and r until the VSWR be-
comes better than 1.5:1.
q Set the desired operating frequency on the IC-703. K When changing the operating frequency, manual
w Connect the short element between the short termi- tuning is helpful for good operation. Even changing
nals to suits the set operating frequency as follows. the frequency 10 kHz, you should start with manual
tuning.
Freq. Short element
Band connection Using loading coil