Professional Documents
Culture Documents
E IV (VII-SEM) MECHANICAL
Production Technology – I
Quiz Paper-2
Time: 15 minutes
EXAM NO: Date:
ROLL NO:
Name:
2 Two starts Hob rotating at 120rpm to cut spur gear having 80 teeth, for it finds out RPM
of blank.
(a) 1 (b) 1.5 (c) 2 (d) 3
6 Calculate the B.E.P if fixed cost is Rs. 100,000, variable cost Rs. 100per unit & Selling
price is Rs.200per unit.
(a) 100 pieces (b) 1000 pieces (c) 500 pieces (d) 750 pieces
7 In merchant’s theory 2Φ + β – α =
(a) Π (b) 2Π (c) Π/2 (d) Π /4
8 In a single-point turning operation of steel with cemented carbide tool, Taylor’s tool life
exponent is 0.25. if the cutting speed is halved, the tool life will increase by
(a) 2 times (b) 4 times (c) 8 times (d) 16 times
9 If cutting speed is 0.2m/s , cutting force 2764N, efficiency of machine tool is 85% ,then
what is the value of Motor power
(a) 0.65KW (b) 0.553KW (c) 0.50KW (d) 0.71KW
1 When machining long shaft of small diameter which rake angle is recommended.
(a) Positive (b) Negative (c) Zero (d) None of all
2 Single start hob is used to cut spur gear having 90 teeth and blank is rotated at
1.5rpm.What is the speed of Hob.
(a) 1.5 (b) 60 (c) Zero (d) 135
5 Which one of the following process does not cause tool wear
(a) USM (b) ECM (c) EDM (d) AJM
6 The time taken to drill hole through 25mm thick plate with the drill rotating at 300 rpm
and moving at a feed rate of 0.25mm/rev is
(a) 10s (b) 20s (c) 100s (d) 200s
7 In metal cutting operation the approximate ratio of heat distributed among chip, tool,
and w/p in order of
(a) 80:10:10 (b) 34:33:33 (c) 40:40:20 (d) 10:10:80
8 In a single-point turning operation of steel with cemented carbide tool, Taylor’s tool
life exponent is 0.25. if the cutting speed is halved, the tool life will increase by
(a) 2 times (b) 4 times (c) 8 times (d) 16 times
9 If cutting speed is 2m/s ,α =10o , ф = 31.25o then what is the value of shear velocity
(a) 1.11m/s (b) 0.75m/s (c) 2.11m/s (d) 1.75m/s