Professional Documents
Culture Documents
Care must be taken when installing this accessory to ensure damage does not occur to the vehicle. The installation of this
accessory should follow approved guidelines to ensure a quality installation
Microphone
A GBS ECU
GBS
B
1. Vehicle Disassembly
(a) Vehicles with Automatic Transmission
should be placed in Park and have the
Parking Brake set before disconnecting the
Battery.
Fig. 1-2
Cowl Nut
Fig. 1-3
Bolt
Retaining Clip
(1) Press down on the Retaining Clip while pushing
Hood Release Lever the Lever out.
Fig. 1-5
Hood Release Lever (g) Remove the Hood Latch Cable from the
Hood Latch Lever. (Fig. 1-6)
(h) Remove the Lower Dash Cover.
Hood Latch Cable
Fig. 1-6
Bolts (x4)
Fig. 1-7
TVIP Box
Fig. 1-8
Fig. 1-9
Phillips Screwdriver (l) Remove the 2 bottom Screws from the Cup
Holder Drawer Assembly. (Fig. 1-10)
Screws (x2)
Fig. 1-10
CONTINUED
Fig. 1-11
Fig. 1-12
FOR VEHICLES WITH FLOOR MOUNT
AUTOMATIC SHIFT LEVERS ONLY.
(Steps o)
Nylon Panel Removal Tool
(o) Remove the small Tray below the Climate
Control Console. (Fig. 1-13)
(1) Disconnect any Connectors.
Tray
Fig. 1-13
Knockout Cover
Fig. 1-14
Fig. 2-1
GBS Microphone
Fig. 2-2
Fig. 3-1
4. ECU installation
10mm Socket, Extension
(a) Remove 2 Nuts from the Vehicle Brace near
Vehicle Brace
the Driver’s Side J/B. (Fig. 4-1)
(b) Pull the Brace away from the Vehicle
Reinforcement. (Fig. 4-1)
(1) Do not remove the Brace from the studs.
Remove Nuts (x2) Vehicle J/B
Fig. 4-1
Bracket Pin
GBS ECU
Fig. 4-2
Reinstall
(e) Re-secure the Vehicle Brace by reinstalling 2
Nuts. (Fig. 4-3)
GBS
Reinstall ECU (1) Verify that the Bracket is secure.
Fig. 4-3
Fig. 4-4
Clear Tape V2 Window Label (b) Place the V2 Window Labels on the inside of
Line Up With Bottom Text of 10mm the Front Door Windows as shown.
Window Etching (or aligned with (Fig. 5-1)
other “Factory Alarm” Labels)
(1) Use the Labels with the Red Tag.
(2) Use the ENGLISH Labels for US Vehicles.
Use the SPANISH Labels for Mexico Vehicles.
(3) Discard the Labels without the Red Tag
Fig. 5-1 (4) Use a piece of clean adhesive tape to lift the
Labels off their protective backing.
Fig. 6-1 (d) Place the GBS Owner's Guide, sealed in the
bag, in the Glove Box.
(e) Discard RS3200 Plus Owners Guide, and
Warranty Card.
(f) Install the Short Pin. (Fig. 6-2)
Fig. 6-2
Press and release the remote control’s lock 1. The turn signal lights flash once.
button to start the system’s arming process. All doors lock.
The security LED lights up.
With the tip of a key, or Striker Tool pulled 3. The horn sounds repeatedly.
all the way out (PPO only), tap the center of The headlights flash repeatedly.
the driver’s door window to trigger the The turn signal lights flash repeatedly.
alarm. The LED lights up.
For all vehicles, press the unlock button of 4. The horn stops sounding.
the remote key to stop the alarm. All the lights stop flashing and/ or turn off.
The security LED turns off.
NOTE: If you do not disarm the system,
the alarm will last 20 seconds. It is not
necessary to check the alarm duration.
Passenger Air Bag Switch (if equipped) Functioning Passenger Air Bag Switch
RS3200 PLUS
SECURITY SYSTEM
DESIGNED FOR USE WITH YOUR VEHICLE’S
REMOTE KEYLESS ENTRY SYSTEM
OWNER’S GUIDE
Rev. A 06/20/05
TOYOTA RS3200 PLUS Security system Page 1
To better understand the features and functions of this security system, please read this Owner’s
Guide completely prior to use.
TABLE OF CONTENTS
DESCRIPTION PAGE
INTRODUCTION 2
BRIEF DESCRIPTION–RS3200 PLUS FEATURES 3, 4
IN OPERATION
ARMING THE RS3200 PLUS (except PASSIVE ARMING) 5
DISARMING THE RS3200 PLUS (except PASSIVE DISARMING) 6
PASSIVE (AUTOMATIC) ARMING & DISARMING 7
AUTOMATIC REARMING 8
ARMING SUSPENSION 8
ALARM INFORMATION 9
ALARM TRIGGERS 9
ALARM DESCRIPTIONS 10
STOPPING AN ALARM 10
GLASS BREAKAGE SENSOR INFORMATION
GLASS BREAKAGE SENSOR CHECK PROCEDURE 11
PROGRAMMING
PASSIVE (AUTOMATIC) ARMING AND ENTRY DELAY 12
(Not applicable to Highlander and Sienna. Please consult your
Toyota Dealer for programming information.)
WARNING and CAUTION INFORMATION 13
O
C
B
IN
lea
Par
Page 2 TOYOTA RS3200 PLUS Security system
INTRODUCTION
Congratulations on your choice of the RS3200 PLUS add-on security system to protect your vehicle!
To get the most from the system, we strongly recommend that you read this Owner’s Guide com-
pletely to learn all of its features and functions.
The RS3200 PLUS provides security through point-of-entry monitoring, glass breakage detection and
ignition switch monitoring. While ARMED, the system will be TRIGGERED and sound an ALARM when a
door, trunk or hatch is forcibly unlocked or opened*, or when a window is tapped on or broken.
During the ALARM, the vehicle’s horn sounds and the headlights, tail lights and front marker or turn
signal lights flash. A l s o , the vehicle’s starter is disabled, preventing engine start. In addition to the
comprehensive protection, the RS3200 PLUS works in conjunction with your vehicle’s remote key- irá un retraso de
less entry system, enabling you to ARM and DISARM the security system at the same time the doors
are remotely locked and unlocked. In vehicles equipped with a buzzer, it will chirp when the system RAMOS AQUÍ.
is REMOTE ARMED and DISARMED. DIFERENTE DEL
IÓN DEL MOTOR
L SISTEMA DE
KEY The RS3200 PLUS will ARM 30 seconds after you close the trunk (if
P ARMING/DISARMING open) and lock the vehicle’s doors with the key, and will DISARM when
P you unlock a door with the key.
ARMED MODE While ARMED, the trunk may be opened with the key (or trunk release button
SUSPENSION** on your remote control, if so equipped) without TRIGGERING an ALARM. Once
T the open trunk is closed, the system ARMS again.
The RS3200 PLUS may be programmed to automatically ARM 30
PASSIVE (AUTOMATIC)
ARMING
seconds after the ignition key is removed, the vehicle exited and the
last door and the trunk closed, without the necessity of locking doors.
A PASSIVE DISARMING The RS3200 PLUS may be DISARMED with the vehicle’s ignition key
after it was PASSIVELY ARMED.
ADJUSTABLE ENTRY When the RS3200 PLUS has been PASSIVELY ARMED, an ENTRY DELAY
E DELAY (user-selectable at 0, 15, or 30 seconds) will start when a door is
T opened before an ALARM is TRIGGERED.
When you lock the vehicle with the central lock switch (while a door
MANUAL ARMING
P
is open), the RS3200 PLUS will ARM 30 seconds after you close all
the doors and the trunk (if open).
IGNITION KEY The RS3200 PLUS may be DISARMED by inserting the key into the
ignition switch and turning it to “ON.”
(
A DISARMING
Forcibly unlocking or opening a door or trunk while the RS3200 PLUS
A POINT-OF-ENTRY is ARMED will TRIGGER an ALARM immediately. (If the system was PASSIVELY
S PROTECTION ARMED, the ENTRY DELAY must pass after opening a door before the ALARM is
TRIGGERED.)
L GLASS BREAKAGE
The RS3200 PLUS utilizes a microphone (usually mounted in the
SENSOR S TATUS MONITOR) to sense the noise from tapping on window glass, or
A glass breaking, and TRIGGER the system to sound an ALARM. It is fine
tuned to “listen” for this type of noise, and ignore other sounds.
WARN AWAY ALARM When the GLASS BREAKAGE SENSOR’S microphone picks up tapping or
breaking of window glass, it TRIGGERS a WARN AWAY ALARM; the headlights
A
and tail and marker or turn signal lights flash, and the horn sounds for 20
seconds, but the starter is not disabled. If there is another detection of glass
tapping or breaking, or if a door is opened or unlocked without a key, the
regular ALARM is TRIGGERED.
IGNITION SWITCH While ARMED, the RS3200 PLUS monitors the ignition switch. If an attempt is
A MONITORING made to start the vehicle without a key, an ALARM is TRIGGERED.
C
**Starting from 2002 M.Y., Arming Suspension Mode by using the key to unlock the trunk is not applicable
to Camry, Solara, and Corolla.
Page 4 TOYOTA RS3200 PLUS Security system
S DEL SISTEMA
TOYOTA RS3000 PLUS Security system Page 5
∆E
*
OPERATION
ARMING THE RS3200 PLUS (except PASSIVE ARMING)
The system may be ARMED in several ways. Do one of the following:
Q
PR Lock the doors from inside the vehicle:
Remove the key from the ignition switch.
Open the driver’s or front passenger’s door.
Push the central lock switch.
Exit the vehicle, and close all the doors.*
Close the trunk or hatch, if necessary.* Then:
The STATUS MONITOR’S LED turns on for 30 seconds,
PUSH THE LOCK
SWITCH WHILE THE
then starts flashing.➀ The system is now ARMED.
DOOR IS OPEN
GIR
➀ LIGHTS ➁ ③
FOR 30
SEC-
ONDS
(PRE-
ARMING)
THEN
El FLASHES
(SYSTEM ALL DOORS LOCK WHEN THE TAIL AND MARKER OR TURN SIGNAL
IS THE SYSTEM IS REMOTE LIGHTS FLASH ONCE WHEN THE SYSTEM IS
AR
ARMED) ARMED REMOTE ARMED
O
* The system will not ARM while any of the doors, trunk or hatch is open.
∆ If your vehicle is equipped with a buzzer.
Page 6 TOYOTA RS3200 PLUS Security system
OPERATION
rpadeando.
del vehículo para
DISARMING THE RS3200 PLUS (except PASSIVE DISARMING) SARMAR REMOTAMENTE AL SISTEMA
ERAS E INTERMITENTES PARPADEAN DOS
The STATUS MONITOR’S LED stops flashing.➀The system is , después gírela a la posición
now DISARMED.* :
PUSH THE UNLOCK Press the unlock button again within 3 seconds after unlocking the
BUTTON driver’s door to unlock the remaining doors.
las puertas.
ber desasegurado la puerta
tas nuevamente dentro de
Use the ignition switch:
Insert the key into the ignition switch, then turn it to ON. dejará de parpadear. (1)
The STATUS MONITOR’S LED stops flashing.➀The system is
1
now DISARMED.*
∆
lo centellearán dos veces. (3)
3
TURN THE KEY TO “ON” This method of disarming is rarely used. You must be inside the
TO
vehicle while the system is armed in order to do it.
DISARM THE SYSTEM tas desde el control remoto.
NOTE: If your vehicle’s tail and marker or turn signal lights turn on for 2 seconds when the system
remoto:
is DISARMED,* the TRIGGER MEMORY was activated; something TRIGGERED an ALARM while
you were away from the vehicle. This feature is not available for Corolla / Matrix.
ismo tiempo.
desde la puerta trasera;
➀ ➁ ➂ unner, también podrá
STOPS
FLASH- a dejará de parpadear. (1)
1
ING
WHEN y gírela hacia la parte trasera
THE SYS-
TEM IS
DIS- THE DRIVER’S DOOR
ARMED UNLOCKS WHEN THE THE TAIL AND MARKER OR TURN SIGNAL
siguientes:
SYSTEM IS REMOTE LIGHTS FLASH TWICE WHEN THE SYSTEM IVO)
DISARMED IS REMOTE DISARMED
* Please note, if the system utilizes your vehicle’s engine immobilizer system LED instead of the
STATUS MONITOR, the LED will continue to flash.
NOTE: If your vehicle’s tail and marker lights turn on for 2 seconds when the ignition key
is turned to “ON”, the TRIGGER MEMORY was activated; something TRIGGERED an ALARM
while you were away from the vehicle. This feature is not available for Corolla/Matrix.
la ➀ LIGHTS ➁
po FOR 30
TURNS
15 SECONDS
ON (NO
(PRE-ARM-
FLASH-
de
ING)
ab ING)
THEN
ha DURING
STARTS
de THE
FLASHING
ENTRY
(SYSTEM
C
DELAY
A IS ARMED)
O
* If the ENTRY DELAY time elapses before the ignition switch is turned to “ON”, an ALARM will be
TRIGGERED. To DISARM the system during an ALARM, insert the ignition key and turn it to “ON”, or
press and release the remote control’s unlock button.
Page 8 TOYOTA RS3200 PLUS Security system
OPERATION
AUTOMATIC REARMING
When you unlock the doors using the remote control, the RS3200 PLUS is DISARMED at the same
time. However, if you do not open a door or the trunk within 30 seconds, the keyless entry system
will relock the doors and the RS3200 PLUS will REARM 30 seconds later.
45 15
30
para el Camry, Solara y
THE DOORS ARE WHEN NO DOOR, FOR MORE THAN THE KEYLESS THE LED WILL abrir el maletero no estará
UNLOCKED BY TRUNK OR HATCH 30 ENTRY LIGHT UP FOR 30 tado de suspensión del
PRESSING THE IS OPENED... SECONDS... SYSTEM AUTOMAT- SECONDS los automóviles modelo
UNLOCK BUTTON ICALLY RELOCKS (PRE-ARM), THEN
ON THE REMOTE THE DOORS, THEN FLASH WHEN THE
CONTROL... THE RS3200 PLUS SYSTEM IS ARMED
AUTOMATICALLY
REARMS.
ARMING SUSPENSION**
e monitorea el condición se
otón para abrir el maletero a
to tenga la función para
The ARMED state of the RS3200 PLUS can be suspended temporarily by using the key to unlock and lmente al emplear la llave
open the trunk. If your remote control is so equipped, you may also suspend the ARMED state using
the trunk release button➀to open the trunk. When the ARMING is suspended, the STATUS MONITOR’S
LED will turn off ➁until the trunk is closed again.
RMA
TURNS
PARPADEARÁ CUANDO EL TEMA RS3200
(PRE-ARMADO) Y LUEGO
**Starting from 2002 M.Y., Arming
AS PUERTAS, Y
OFF POR 30 SEGUNDOS MÁTICAMENTE
WHEN Suspension Mode by using the SE ENCENDERÁ EL LED E ENTRADA SIN
THE key to unlock the trunk is not
ARMED applicable to Camry, Solara, and
STATE
IS SUS-
Corolla.
OPENING THE TRUNK
SUSPENDS THE PENDED
ARMED STATE OF THE
SECURITY SYSTEM
ALARM INFORMATION
ALARM TRIGGERS
While the system is ARMED, an ALARM will be TRIGGERED when any of the following occurs:
Pulling the trunk release lever inside the vehicle will also TRIGGER
an ALARM.
The RS3200 PLUS can detect the absence of the ignition key if
the ignition circuit is shorted in attempt to start the vehicle.
➤ Power restoration
ALARM DESCRIPTIONS
Regular ALARM ➀
When an ALARM is triggered in any way other than initial detection by the GLASS BREAKAGE SENSOR,
the following occur:
The horn sounds repeatedly for 60 seconds.
The headlights flash repeatedly for 60 seconds.
The tail and marker or turn signal lights flash repeatedly for 60 seconds. SEGUNDOS
The starter is disabled (no engine start) until the system is DISARMED. DURANTE 20
The door lock will be relocked if someone reaches in and unlocks the inside lock button. PARPADEARÁN
After 60 seconds of ALARM, the system will REARM and continue to protect the vehicle.
INTERMITENTES
TRASERAS Y LAS
LUCES LAS
➀ THE STARTER IS DIS-
ABLED UNTIL THE SYSTEM TAIL OR TURN SIG-
IS DISARMED NAL LIGHTS FLASH
THE HORN
FOR 60 SECONDS
SOUNDS
FOR 60 SECONDS larma regular (descrita
MARKER OR TURN
SIGNAL LIGHTS
evamente, o si alguna puerta
FLASH undos.
FOR 60 SECONDS segundos.
HEAD LIGHTS
FLASH
FOR 60 SECONDS o romper algún cristal, el
WARN-AWAY ALARM ➁
Upon initial detection of noise from tapping on, or breaking glass, the GLASS BREAKAGE SENSOR
TRIGGERS a WARN AWAY ALARM:
The horn sounds repeatedly for 20 seconds.
The headlights flash repeatedly for 20 seconds.
The tail and marker or turn signal lights flash repeatedly for 20 seconds.
If the GLASS BREAKAGE SENSOR detects noise again, or if a door or trunk is opened while the system
is still ARMED, the regular ALARM (described above) is activated.
60 SEGUNDOS
➁ PARPADEARÁN POR
Y LAS INTERMITENTES
Simply DISARM the system using the remote control or key as described on page 6.
TOYOTA RS3200 PLUS Security system Page 11
(Remember, the system will not ARM if any door, the trunk or
hatch is open.)
3. With the tip of a key, tap the center of the driver’s door window.
Tap the glass with light to moderate force.
PROGRAMMING
The RS3200 PLUS is factory-set to not PASSIVELY ARM. To change the system’s operation for programación ha terminado.
PASSIVE ARMING operation, as well as adjust the ENTRY DELAY time, follow the procedure below. For nuevamente. El proceso de
more information on this feature, please refer to page 7. (Not applicable to Highlander and esto no sucede, empiece
Sienna. Please consult your Toyota Dealer for programming information.) puerta en dos segundos; si
. El sistema desasegurará la
PASSIVE ARMING ON/OFF SELECTION, ENTRY DELAY TIME SELECTION
1. Before you begin: 2. Insert and remove the key from
Open the driver’s door. Close the remaining doors the ignition key cylinder 3
and the trunk or hatch. Unlock all doors with the inside times; this must be completed
lock switch. Remove the key from the ignition switch. within 5 seconds.
de programación.
ductor.
la puerta del
re el seguro
pasos en menos de 40
e. Open the driver’s f. The system locks the door g. Unlock the driver’s
door. in 2 seconds; if this does door knob.
not happen, start over. pacio de 40 segundos.)
3. Select the Operating Mode and Complete the Programming Procedure. pletar en el espacio de cinco
veces; este procedimiento
etire la llave del cilindro de
Warning
• This product is applicable only to vehicles with 12V DC, negative grounding specifications. Do
not use in vehicles with 24V specifications. Otherwise, damage to the unit or a fire may result.
• Never attempt to disassemble or modify the product. Otherwise, an accident, fire or electric
shock may result.
• When replacing fuses, be sure to use fuses with the same specified capacity (amperage.)
Otherwise, damage to the unit or vehicle, fire or electric shock may result.
• If an abnormal condition occurs, such as liquids spilling onto the product, or the product
emitting smoke or strange odors, stop using it immediately and consult the dealer from whom
you purchased the product. Continued use of the product before corrective actions are taken
may result in an accident, injury or fire.
• Never pull the plastic bag over your head. Otherwise, a serious injury or death from suffocation
• may occur.
•
Caution
•
•
Do not use this product for applications other than in-vehicle use. Otherwise, an electric shock
or injury may result.
• Do not allow children to play with the remote controls. Otherwise, the doors may be locked or
unlocked, the security system armed or disarmed, or an alarm triggered unintentionally.
l
•
•
If this product is dropped or its case is damaged, disconnect the power supply lead and
l contact the dealer from whom you purchased it to obtain service. Otherwise, a fire or electric
shock may result.
i
•
02-28940700
090002-28940700