Professional Documents
Culture Documents
PROPOSAL
CONVERSION OF
AGRICULTURAL &
WATER SUPPLY
TUBEWELLS TO
SOLAR ENERGY
1
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
Prepared for
Prepared By
Submitted on
2
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
Table of contents
No Name Page
1 Statement of confidentiality and non disclosure 5
2 Executive summary 6
About us 6
Vision 6
Partners 6
Advantages 7
Fact Sheet 7
3 Figure I: Sun Insulation data of Pakistan 8
4 Figure II: Annual % daily solar radiation map of Pakistan. 9
5 Figure III: Map of Pakistan’s direct solar Radiation 10
6 Company’s Background 11
7 Mission Statement 12
8 Partners, franchises’ & Distribution Rights 12
9 Identification Of Needs 13
Problems 13
Basic Requirements 13
Technical Requirements 13
10 Basic Pumping Information 14
Introduction 14
Solar VS Conventional Pumps (A Comparison) 14
11 Types Of Solar Pumps 15
Solar Submersible Pumps 15
Surface Pumps 16
12 Calculation Of Solar Power Needs 16
13 Water Pipe Sizing Chart 17
14 Project possibility
15 Proposed plan I (________________________________)
16 Proposed plan II (________________________________)
17 Proposed plan III (________________________________)
18 Proposed Plan Objective & Tasks
19 Proposed Plan Implementation Strategy
20 Benefits Of Proposed Plan
21 Performance Comparison Solar VS Conventional
22 Comparative Data Sheets Solar VS Conventional
23 Graphs
3
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
4
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
The recipient agrees to instinct each employee that they must not disclose any
information concerning this document to others except to the extent that such
matter is generally known to, and are available to use by, the public. The
recipient also agrees not to duplicate and distribute or permit others to
duplicate or distribute any material contained herein without MSB
ENTERPRISES’s express written consent.
MSB ENTERPRISES retains all title, ownership and intellectual rights to the
material and trademarks herein, including all supporting documentations, files,
material and multimedia.
5
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
EXECUTIVE SUMMARY
About us
Vision
Partners
MSB enterprises have teamed up with the most advanced solar cell
producers in the world like Solara Inc and Kyocera.
MSB enterprise holds the exclusive sole distribution rights of above
mentioned companies in Balochistan.
6
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
Advantages
Fact Sheet
7
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
8
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
One solar panel can produce up to 1000 W/hour of electric power at very
nominal Cost
ost in areas having higher rate of solar radiation.
(Fig.III)
.III) Map of Pakistan’s direct solar Radiation
10
Basement Taj Centre, M. A. Jinnah Road, Quetta.
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
COMPANY’S BACKGROUND
Founded 6 years back by the Parent company Bukhari Traders & HiTech Office
Equipments, MSB Enterprises has played its role as a major general order
supplier firm not only with the Government of Balochistan but also with
multinationals, banks and private sectors. Our ever increasing satisfied client’s
list includes
State Bank Of Pakistan
Balochistan Text Book Board
Command & Staff College
School Of infantry & Tactics
Head Quarters Southern Command
Chief Minister’s Secretariat
Standard Chartered Bank
11
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
MISSION STATEMENT
MSB ENTERPRISES is a progressive company providing clean, renewable
sources of power generation. We provide remote, urban and industrial clients
the means to save money, reduce ecological impact and realize their
sustainable living goals.
Our goals are achieved through personalized consultation, design, sales and
installation of sustainable living systems. As we are a small company, we are
able to take the time to analyze customers' requirements and come up with an
appropriate customized solution.
We want to expand our company. Through growth, we can set higher
objectives, serve more people, increase our knowledge base, and further our
mandate.
12
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
IDENTIFICATION OF NEEDS
PROBLEMS
Over all shortfall of power in the country
Increasing oil prices
Heavy amounts in terms of subsidy to agricultural sector which
consumes 80% of total electricity in Balochistan
Scattered population & high budget transmission lines
BASIC REQUIREMENTS
Generation of power through renewable sources
A turn-key solution for agricultural tube wells and urban & rural water
supplies with the help of renewable energy
On and off grid power generation by alternate energy
TECHNICAL REQUIREMENTS
13
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
Introduction
The sun is the natural source of energy for an independent water supply. Solar
pumps operate anywhere that the sun shines, and the longer it shines, the
more water they pump. When it's cloudy, they pump less water, but often you
need less water when it is cloudy. Photovoltaic modules, the power source for
solar pumping, have no moving parts, require no maintenance and last for
decades. A properly designed solar pumping system will be efficient, simple
and reliable.
Solar water pumping systems operate on direct current. The output of the
solar power system varies throughout the day and with changes in weather
conditions. The nature of variable electricity in the form of direct current (DC)
is quite different from conventional, steady alternating (AC) current from the
utility grid or a generator. To use solar energy economically, the pumping
system must utilize the long solar day, drawing a minimum of power. This
means pumping slower than conventional pumps.
Small solar pumps are unique, both electrically and mechanically. The most
14
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
If your water sources are remote from power lines, add up your long-term
costs of fuel and repairs on generators, or the cost of utility line extensions.
Now consider the savings with a solar pump that needs attention only once
every 5 to 30 years depending on model.
Solar powered pumps can provide an equal volume of water per day without
the high and inefficient energy demands of a large capacity AC pump. Instead
of pumping a large volume of water in a short time and turning off, the solar
pump works slowly and efficiently all day. Often a solar pump will work fine in
a well with a recovery rate too slow for a conventional AC pump.
If you are pumping from a well, we have solar pumps that can deliver
from 1 gallon per minute (GPM) to over 75 GPM. The smallest pump, the low
power diaphragm pump, operates from two 50 to 75 watt solar modules,
depending on the head (vertical distance) they are pumping. It can pump 500
to 1000 gallons per day and lift water 200 feet. This pump requires service
every 2 to 4 years. If you have a higher lift, need more water or want a pump
that does not require service for 15 to 20 years, then we can also provide a
pump that can lift water 525 feet and can pump over 20,000 gallons per day at
lower lifts. For greater water needs or deeper wells, our solar AC submersible
15
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
With all solar powered pumps, the necessary solar array can be determined by
looking at the watts required for the head and flow in your situation. Solar
array watts should be at least 20% higher than the power required by the
pump in your situation. If you use a larger array or a tracking array, the pump
will operate at its maximum output for more hours of the day, delivering more
gallons per day. If the pump runs on 24 volts, you can use pairs of 12V solar
modules wired in series or 24V modules. Two solar modules with total wattage
equivalent to or exceeding the wattage required by the pump must be used. If
the pump uses 48 volts, you can use groups of four 12V solar modules wired in
16
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS
SULTANTS & SUPPLIERS
series or group of two 24V modules whose total wattage exceeds the pump’s
power requirement.
17
Basement Taj Centre, M. A. Jinnah Road, Quetta.
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
18
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
PROJECT POSSIBILITY
After studying and providing all basic know how and potential of solar tube
wells in Balochistan, we at MSB Enterprises have figured out two project
implementation options for your department.
I. Choose or short list a site where you would like to install the very first
solar tube as a model to demonstrate at your cost however the labor
services shall be provided free of cost by MSB Enterprises.
II. Let MSB Enterprises bear all the costs of model project at your chosen
site for a limited period of time simply by entering a legal contract with
our company.
PROPOSED PLAN
MSB Enterprises shall be glad to provide the following services for the
installation of first model solar tube well.
I. Complete solar and technical data analysis of proposed site before
installation.
II. Provision and installation of instruments required according to the local
conditions.( solar panels & pumps, inverters, charge controller &
batteries)
III. After installation a complete study based on daily readings to calculate
and evaluate the true potential of our solar pumps along with a
comparison of costs and efficiency of solar pumps versus conventional
submersibles.
19
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS
SULTANTS & SUPPLIERS
PS150-Centric
Centric
20
Basement Taj Centre, M. A. Jinnah Road, Quetta.
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
Applications
21
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
PS200 HR/C
Solar-operated Submersible Pump System, 4" Helical
Rotor (HR) or Centrifugal (C) Pump Unit
Overview
lift up to 50 m
flow rate up to 2.7 m3/h (HR) resp. 5.0 m3/h (C)
simple installation
maintenance free
22
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
Applications
drinking water supply
livestock watering
pond management
irrigation
etc.
Controller PS200
controlling of the pump system and monitoring of the operating states
mounted at surface (no submerged electronic parts)
two control inputs for well probe (dry running protection), float or pressure switches,
remote control etc.
automatic reset 20 minutes after well probe turns pump off
protected against reverse polarity, overload and high temperature
speed control, max. pump speed adjustable to reduce flow rate to approx. 30 %
solar operation: integrated MPPT (Maximum Power Point Tracking)
battery operation: low voltage disconnect and restart after battery has recovered
max. efficiency 88 % (motor + controller)
enclosure: IP 54 (sealed, weatherproof)
23
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
brushless DC motor
water filled
dynamic slide bearings, material: carbon/ceramic
wetted material: stainless steel (AISI 316), POM,
rubber, cable drinking water approved
Pump end (PE)
high life expectancy
none-return valve
dry running protection (optional)
material: stainless steel (AISI 316), rubber
Self-cleaning.
PS1200 HR/C
Submersible Water Pump for Solar Operation
Overview
lift up to 240 m
flow rate up to 21 m3/h
simple installation
maintenance-free
high reliability and life expectancy
cost-efficient pumping
2 years manufacturer's warranty against defects in material and
workmanship
25
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
Applications
drinking water supply
livestock watering
pond management
irrigation
etc.
26
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
Controller PS1200
controlling of the pump system and monitoring of the operating states
mounted at surface (no submerged electronic parts)
two control inputs for well probe (dry running protection), float or
pressure switches, remote control etc.
automatic reset 20 minutes after well probe turns pump off
protected against reverse polarity, overload and high temperature
speed control, max. pump speed adjustable to reduce flow rate to approx.
30 %
solar operation: integrated MPPT (Maximum Power Point Tracking)
battery operation: low voltage disconnect and restart after battery has
recovered
max. efficiency 92 % (motor + controller)
enclosure: IP 54 (sealed, weatherproof)
27
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
PS1800 C
Submersible Water Pump for Solar Operation
Overview
lift up to 50 m
flow rate up to 22 m3/h
simple installation
maintenance-free
high reliability and life expectancy
28
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
cost-efficient pumping
2 years manufacturer's warranty against defects in material and
workmanship
Applications
drinking water supply
livestock watering
pond management
irrigation
etc.
Controller PS1800
controlling of the pump system and monitoring of the operating states
mounted at surface (no submerged electronic parts)
Two control inputs for well probe (dry running protection), float or
pressure switches remote control etc.
automatic reset 20 minutes after well probe turns pump off
protected against reverse polarity, overload and high temperature
Speed control, max. pump speed adjustable to reduce flow rate to approx.
30 %
solar operation: integrated MPPT (Maximum Power Point Tracking)
battery operation: low voltage disconnect and restart after battery has
recovered
29
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
30
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
Features:
Long -life 24 VDC operation
For 4" wells or larger
Quick disconnect with "Watertight-Gland" Design Pat Pend
Corrosion-proof housing with stainless-steel fasteners
Runs dry without damage
50 mesh stainless steel inlet screen
State of the art solid diaphragm
The solution to your remote water pumping needs. This pump is rugged,
durable and built to last. The 9300 delivers a steady 112 GPH (422 LPH) at
its maximum depth of 230 feet (70M) when supplied with 24 VDC. Its
unique water-tight power connector stops water wicking and prevents
potential condensation problems. Great for livestock watering, irrigation,
pond aeration, remote homes and cabins.
Note: Do not use any solar water pump for petrol gasoline, petroleum
products, solvents, thinners or any other flammable liquid with a flash
point below 82 C (180 F). Not for use where flammable vapors are present.
Model 9325-043-101
24VDC Submersible Pump for potable water wells 1/2" Hose Barb discharge
Description
port 50 mesh SS inlet screen
Vertical Lift
20 60 100 140 180 230
(feet)
Vertical Lift
6.1 18.3 30.5 42.7 54.9 70.1
(meters)
Flow (GPH) 111 105 100 93 87 79
Flow (LPH) 420 398 379 352 329 300
Solar Array (Min
58 78 99 115 135 155
Watts)
Current Amps 1.7 2.3 2.9 3.5 4.0 4.6
31
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
Features:
Self priming up to 12 feet
Can run dry without damage
Optional motor cooling fins
One way check valve prevents reverse flow
Available for 12 VDC, 24 VDC, and 115 VAC
Automatic operation with pressure demand switch
32
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
Model Description
33
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
Overview Applications
surface centrifugal pump for solar swimming pool water circulation
operation through a filter system and
flow rate up to 15 m3/h thermal collectors
simple installation pond management
maintenance-free thanks to irrigation
brushless DC motor aquariums
high reliability and life expectancy etc.
cost-efficient pumping
2 years manufacturer's warranty
against defects in material and
workmanship
34
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
35
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
Controller PS600
controlling of the pump system and monitoring of the operating states
mounted at surface (no submerged electronic parts)
Two control inputs for well probe (dry running protection), float or
pressure switches remote control etc.
automatic reset 20 minutes after well probe turns pump off
protected against reverse polarity, overload and high temperature
Speed control, max. pump speed adjustable to reduce flow rate to
approx. 30 %
solar operation: integrated MPPT (Maximum Power Point Tracking)
battery operation: low voltage disconnect and restart after battery has
recovered
Max. efficiency 92 % (motor + controller)
36
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
37
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
PS150 Boost.
Booster Pump for Solar Operation
LORENTZ PS150 Boost provides city water pressure, anywhere. It has been a
standard in home renewable energy systems since 1986. It is economical for
domestic water supply, drip irrigation and water purification. Use solar-electric
power to provide 250 to 10,000 liters per day from shallow water sources.
PS150 Boost can push water as high as 140 m.
LORENTZ PS150 Boost is not submersible, but can draw water from shallow
wells, springs, cisterns, tanks, ponds, rivers and streams and push it through
miles of pipeline. Slow pumping minimizes the size and cost of the solar array-
battery system, wire and piping.
LORENTZ PS150 Boost is more powerful, quieter and much more durable
than plastic RV/Marine pumps. It is less expensive than submersible DC
pumps. Wearing parts typically lasts 5 to 10 years. Overall life expectancy is 25
to 30 years.
Short Overview
solar operated surface vane type pump
max lift up to 120 m
Max. flow rate 0.9 m3/h
simple installation
high reliability and life expectancy
cost-efficient pumping
wetted materials: stainless steel, brass, rubber, plastic
Applications
drinking water supply
water purification and filtration
pressurizing for home water systems
drip irrigation
Water circulation in thermal solar collectors (max. +60 oC, +90 oC on
request)
etc.
39
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
Total Lift PS150 Boost 60 PS150 Boost 125 PS150 Boost 240
[m] [l/h] [W] [l/h] [W] [l/h] [W]
5.0 260 35 480 50 900 65
10 260 40 470 55 900 90
15 250 45 470 62 890 105
20 250 55 470 70 880 120
25 250 63 460 80 880 135
30 250 72 450 90 870 150
40 250 80 450 105 870 200
45 240 85 450 112 860 225
50 240 90 450 120
60 240 95 430 140
70 240 110 420 160
80 240 125 410 185
90 240 140 410 200
100 230 165
120 230 185
140 220 220
40
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
LORENTZ PS150
Boost Set
with inline filter
41
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
Suction Capacity
5 m (15 ft) at sea level. Subtract 1 m (3 ft) for every 1,000 m (3,300 ft) altitude.
Pump should be placed as low and as close as possible to the water source.
Suction capacity my be further limited by intake pipe friction (or clogged
filter).
Filtration Requirement
This pump cannot tolerate dirt. Water must be filtered clear. If water is very
dirty, improve the source or consider a different pump.
Installation
Pump may be mounted horizontally or vertically.
Pump must not be submerged
It may be placed inside a 6" (120 cm) or larger well casing, suspended by a
rope
Accessories
Inline Filter: (10") Uses standard filter cartridges
Installation Kit includes: Pressure switch, pressure gauge, check, drain and
shut-off valves and tank tee.
Float switch for tank shut off if full.
Well probe sensor to protect pump from dry-running.
42
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
Dimensions
Pump Unit
Length: 33 cm (13")
Weight: 7.0 kg (15 lb)
Controller
260 x 175 x 100 mm (10" x 7" x 4")
Weight: 1.5 kg (3.6 lb)
Warranty
1 year against defects in materials and workmanship
43
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
INVERTERS
CHARGE CONTROLLERS
BATTERIES
44
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
45
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
46
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
47
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
48
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
49
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
50
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
51
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
52
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
53
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
54
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
55
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
56
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
57
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
58
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
59
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
60
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
61
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
62
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
63
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
64
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
65
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
66
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
67
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
68
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
69
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
70
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
71
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
72
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
73
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
74
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
75
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
76
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
77
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
78
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
79
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
80
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
81
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
82
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
83
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
84
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
85
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
86
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
87
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
88
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
89
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
90
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
91
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
92
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
93
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
94
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
95
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
96
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
97
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
98
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
99
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
100
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
101
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
102
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
103
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
104
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
105
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
106
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
107
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
108
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
109
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
110
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
111
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
112
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
113
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
114
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
115
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
116
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
117
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
118
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
119
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
120
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
121
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
122
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
123
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
124
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com
MSB ENTERPRISES
ALTERNATE ENERGY CONSULTANTS & SUPPLIERS
125
Basement Taj Centre, M. A. Jinnah Road, Quetta.
Phones: - 081 2837030-31, Fax: - 081 2824292, msbenter@gmail.com