Professional Documents
Culture Documents
HOME
TEAM
MEMBERS HOME COUNTRIES
CAA LINKS
TRAINING MANUALS
MOD 1 MCQ
MOD 2 MCQ
MOD 3 MCQ A
MOD 3 MCQ B
MOD 4 MCQ
MODULE 5 MCQ
MODULE 6 MCQ
MODULE 7 ESSAYS
MODULE 7 MCQ
MODULE 8 MCQ
MODULE 9 ESSAYS
MODULE 9 MCQ
MODULE 10 ESSAYS
MOD 10 MCQ A
MOD 10 MCQ B
MOD 10 MCQ C
MOD 11 MCQ
MOD 13 MCQ A
MOD 13 MCQ B
MOD 13 MCQ C
MOD 14 MCQ
MOD 15 MCQ
MOD 16 MCQ A
MOD 16 MCQ B
MOD 17
PROCEDURES
PROCEDURES PT 2
A300 - 600 FCOM 1
A310 FCOM 1
A320 SYSTEMS
A320 PILOTS REVISION
A320 EXAM
A330 FCOM1
A330 PILOTS REVISION
A330 EXAM
A340 FCOM 1
A340 EXAM REVISION
A340 FOR PILOTS
BOEING 737
BOEING 777
BLOG
CALENDAR
Members
JOBS / TRAINING
FORUMS
YOUR RATING!!
ATC MOVEMENT
GAMES
Photo Gallery
HELP
Videos
LATEST AVIATION NEWS
CONTACT US
Module Fourteen
a) HP turbine
# b) LP turbine
c) IP turbine
4. The air data input to the FADEC fails. The result will be
# b) reduction gearbox
c) prop shaft
a) Direct current
b) Alternating current
# a) None
b) No indication
Page 1- Mod 14
a) increase
b) decrease
# c) not change
# c) a helicopter engine
a) engine RPM
# b) shaft horsepower
c) propeller RPM
# a) RPM gauge
b) Torque gauge
c) Horsepower gauge
17. What are the units of manifold pressure on a normally aspirated engine?
a) PSI
b) Inches of water
# c) Inches of mercury
18. In a FADEC what is the result of Channel A failing to receive information from a
sensor?
Page 2 - Mod 14
# a) alternating current
b) direct current
c) either ac or dc
20. A synchro pressure measuring system works on the principle of changes in pressure
related to changes in
a) frequency
b) voltage
# c) flux
# a) stagnation thermocouples
b) rapid response
# a) differential pressure
b) absolute pressure
c) HP oil pressure
a) increasing RPM
c) increasing pitch
a) N3 RPM
b) fuel flow
a) P1 to P4
b) P1 to Pfan
# c) P1 to P6
Page 3- Mod 14
a) SHP
# b) ESHP
c) BHP
30. To measure oil temperature, which of the following would most likely be used?
b) Thermocouple measurement
c) Optical pyrometer
a) thrust
# b) torque
c) pressure
a) the N1 vibration
# a) frequency
b) amplitude
c) voltage
36. What percentage of air passing through the combustion section is burned?
# a) 40%
b) 50%
c) 75%
Page 4 - Mod 14
# a) N1 RPM or EPR
c) N1 RPM or N3 RPM
b) milliohmeter
c) milliameter
43. If a FADEC loses its ADC input, in the short term it will
44. With an aircraft with a fixed pitch propeller, what indication has the pilot got of the
output power?
a) fuel flow
b) oil pressure
a) to change analogue inputs into digital format to provide glass cockpit information
and reduce flight crew workload
b) to change analogue inputs into digital format to reduce flight crew workload and
provide maintenance information
Page 5 - Mod 14
47. A sensing element goes open circuit in a ratiometer. What will be happen?
a) hot junction
# b) cold junction
probe fails?
# a) No noticeable effect
53. The vane on a vane type fuel flow measuring device becomes stuck. What safety
backup is available for the engine fuel flow?
b) A bypass valve
54. In a FADEC engine with a hydromechanical fuel system, how is fuel flow controlled?
a) By fuel pressure
c) By oil hydraulics
Page 6 - Mod 14
up to 55,000 ft.
# a) improve efficiency
b) improve thrust
c) reduce size
c) There is no compensation
a) fuel valve
# b) HMU/FFG
66. On a thermocouple circuit on a non FADEC engine, what is the purpose of the ballast
resistor?
# a) inches of Hg
b) inches of water
c) PSI
72. If an engines fadec system loses air data permanently the pilot will
a) accessory gearbox
# b) turbine
# a) on shutdown
a) otto cycle
# b) brayton cycle
c) diesel cycle
a) 2 systems
# b) 3 systems
c) 4 systems
80. With the EEC in control the throttle levers are always
# a) rapid response
b) stagnation
c) surface mounted
Page 9 – Mod 14
a) pressure thrust
b) velocity thrust
# a) phonic wheel
c) eddy currents
a) 2 controlling 1 operating
b) 1 controlling 1 operating
a) over read
b) under read
# a) turbojet
b) turbofan
c) turboprop
# a) divergent
b) convergent
c) convergent-divergent
89. What is the pressure increase over one stage of a centrifugal compressor?
# a) 5:1
b) 1.2:1
c) 8:1
90. The bleed valve on a engine at start up is
# a) open
b) closed
c) modulating
Page 10 – Mod 14
# a) jet pipe
c) front of turbine
a) prsov
b) h.p pump
# c) l.p pump
95. How is fuel flow varied in a variable displacement pressure type pump?
97. When the full authority fuel control unit is changed, the rating plug
Page 11 – Mod 14
# c) the EEC, fire control handle and the engine master switch
102. An increase in fuel flow through the impeller type fuel flow transmitter is measured by
# a) 3 phase star
b) 3 phase delta
c) 2 phase star
a) sintered bearings
c) plain bearings
Page 12 – Mod 14
c) servo operated
a) A fixed frequency
# b) A Variable frequency
c) A DC Current output
111. On a fuel flow measuring device located on the engine
a) In the indicator
a) ensure that the pins and sockets are correctly crimped and brazed
# c) ensure that the pins and sockets are of the same material as the leads
# c) do nothing this is what it should read with the engine shut down.
Page 13 – Mod 14
b) ac servo motor
c) synchronous motor
c) the HP turbine drives the LP compressor and the LP turbine drives the HP
compressor
# c) continuous
a) compound engines
c) complex engines
# c) only used when engine output pressure is used for torque not for thrust.
Page 14 – Mod 14
b) 28V dc is required
c) 115V ac is required
# a) a serviceable battery
b) No power
c) 24V dc
a) never
a) 28vdc
b) 115vac
# c) It has no supply
b) temperature
c) pressure
135. The fuel metering valve in the hydro mechanical unit of a FADEC system is operated
by
c) electrical servo
Page 15 – Mod 14
account
b) open.
# a) has electronic control of the hydro-mechanical fuel control unit in all modes
Newest Members
Recent Forum Posts
LOG BOOK
by bigboss 5 hours ago
YOUR ADVERTISEMENT LINKS
by imran ismail 8 hours ago
MOD 3 MCQ A and MOD 3 MCQ B
by Norsiah 12 hours ago
FACEBOOK ID??
by CARLOS 15 hours ago
More...
Recent Photos
FLIGHTDECK BLOG
by Aircrafttechtrng | 14 comments
MAINTENANCE BLOG
by Aircrafttechtrng | 65 comments
Upcoming Events
No upcoming events
© WWW.AIRCRAFTTECHTRNG.COM 2009