You are on page 1of 2

IN-GATE-2017

GATE 2017 – A Brief Analysis


(Based on student test experiences in the stream of IN on
12th February, 2017 – (Afternoon Session)

Section wise analysis of the paper

S.No Section Classification 1-Mark 2-Mark Total no of Questions


1 Engineering Mathematics 4 2 6
2 Networks 4 4 8
3 Analog Circuits 5 6 11
4 Digital Circuits 2 1 3
5 Signals and Systems 4 3 7
6 Control Systems 0 3 3
7 Communications 0 2 2
8 Measurements 2 4 6
9 Transducers 2 4 6
10 Optical Instrumentation 0 1 1
11 Process Control 2 0 2
12 Verbal Ability 2 2 4
13 Numerical Ability 3 3 6

Type of Questions asked from each section

Basics of networks, two port networks, AC analysis, transient


Networks
analysis, resonance
Analog Circuits Op amp

Digital Circuits Logic gates, sequential circuits, microprocessor


Laplace transform, Z-transform, classification of signals, sampling,
Signals and Systems
DFT
Control Systems Stability, block diagram, time response analysis

Communications Frequency modulation, amplitude modulation

Measurements PMMC, Bridges, instrument transformers

Transducers Pressure measurement, temperature measurement, flow measurement


Disclaimer – This paper analysis and questions have been collated based on the memory of some students who appeared in the
paper and should be considered only as guidelines. GATEFORUM does not take any responsibility for the correctness of the
same.
IN-GATE-2017

Optical Instrumentation Photo detector

Process Control Basics, controllers

Comments on paper:

 IN paper has more concept based questions.

 Compared to last year, in Digital circuits and Communication weightage has come down
while it is increased in Signals and systems, Networks, Analog circuits and Measurements.

 In remaining topics IIT Roorkee has followed almost the same weightage compared to last
year.

 In general the overall difficulty level of the paper is easier than last year.

Disclaimer – This paper analysis and questions have been collated based on the memory of some students who appeared in the
paper and should be considered only as guidelines. GATEFORUM does not take any responsibility for the correctness of the
same.

You might also like