Professional Documents
Culture Documents
Devansh Raghuwanshi
Course: GATE+ESE
Electrical Engineering (EE)
Q. 1
MY TEST
BOOKMARKS
MY PROFILE
If the input is a 100 V peak square wave with a period of 20 ms. The output of the wave is so designed that it has a maximum
REPORTS value of 25 and minimum of –175 V at the steady state, then the circuit which can perform this function can be represented as
FAQ Solution Video Have any Doubt ?
BUY PACKAGE
A
ASK AN EXPERT
B
C
Correct Option
Solution :
(c)
QUESTION ANALYTICS
Q. 2
A diode circuit shown in the figure below consists of two diodes D1 and D2.
The diodes connected are assumed to be ideal diodes, then the transfer characteristic curve of the clipper circuit formed by the
two diodes can be represented as
FAQ Solution Video Have any Doubt ?
Correct Option
Solution :
(b)
C
QUESTION ANALYTICS
Q. 3
Consider the circuit shown in the figure below:
Assuming the of the transistor to be very large, the value of the collector voltage VC is equal to
FAQ Solution Video Have any Doubt ?
A 6.1
B 2.43 V
C –4.475 V
Correct Option
Solution :
(c)
D –2.21 V
QUESTION ANALYTICS
Q. 4
The N-MOS transistor is so constructed that it has the threshold voltage and then
A 7.614 V
Correct Option
Solution :
(a)
B 4.212 V
C 3.142 V
D 8.624 V
QUESTION ANALYTICS
Q. 5
The transistor is biased in such a way that the transconductance of the transistor gm = 10 mS. If the early voltage then
the value of input resistance Rin (seen by source Vin) is equal to
(Assuming coupling capacitance to be very large).
FAQ Solution Video Have any Doubt ?
A 3.62 kΩ
B 4.62 kΩ
C 5.62 kΩ
Correct Option
Solution :
(c)
D 6.62 kΩ
QUESTION ANALYTICS
Q. 6
For a n-channel MOSFET biased in the saturation region, the parameter and
If the value of the drain current flowing inside the MOS transistor is ID = 0.75 mA, then the value of intrinsic gain of
the MOSFET is equal to
FAQ Solution Video Have any Doubt ?
A 201.21
B 115.46
C 143.34
D 163.3
Correct Option
Solution :
(d)
QUESTION ANALYTICS
Q. 7
At IC = 1 mA and VCE = 10 V, the high frequency parameters at cutoff frequency MHz was measured at
Then the value of capacitance will be equal to
A 1.6 pF
B 2.1 pF
C 2.7 pF
Correct Option
Solution :
(c)
D 3.4 pF
QUESTION ANALYTICS
Q. 8
An ideal op-amp circuit with saturation voltage is used to construct the circuit shown in the figure below.
The output of the op-amp is lead into a differentiator circuit with the value of RC << T. The differentiator is followed by an ideal
diode and a lead resistor RL. If the input to the op-amp is a sinusoidal wave with period T, then the output of the circuit at
steady state can be approximately represented as
FAQ Solution Video Have any Doubt ?
C
Correct Option
Solution :
(c)
D
QUESTION ANALYTICS
Q. 9
A current controlled current source is formed by using of an ideal op-amp circuit. If the output current Io of the circuit which is
measured across the load resistance RL is related to the input as then the value of k is equal to
Correct Option
Solution :
(c)
D
QUESTION ANALYTICS
Q. 10
A Voltage series
Correct Option
Co ect Opt o
Solution :
(a)
For an ideal voltage amplifier the input impedance must be very high and output impedance should be low, so we use
series-shunt or voltage series topology.
B Voltage shunt
C Current series
D Current shunt
QUESTION ANALYTICS
Q. 11
Let the forward voltage drop V for the diode. The circuit is connected with two power supplies with values V1 = 10 V
and V2 = 15 V, then the value of current passing through the diode D is equal ______ mA.
FAQ Solution Video Have any Doubt ?
Solution :
0.127 (0.10 - 0.20)
QUESTION ANALYTICS
Q. 12
Solution :
2.547 (2.20 - 2.80)
QUESTION ANALYTICS
Q. 13
220
Correct Option
Solution :
220
QUESTION ANALYTICS
Q. 14
Consider an inverting amplifier with a normal gain of 1000 constructed from an op-amp with an input offset voltage of 3 mV
and with output saturation level of ±10 V. The value of the peak sine wave that can be applied without any clipping at the output
is equal to _______ mV.
FAQ Solution Video Have any Doubt ?
7
Correct Option
Solution :
7
QUESTION ANALYTICS
Q. 15
An amplifier with open loop gain of A = 2000 ±150 is available for operation but for a particular operation it is necessary to have
the amplifier whose voltage gain varies by not more than 0.2%. The close loop feedback gain of the circuit is equal to
____________.
FAQ Solution Video Have any Doubt ?
53.33 (53.00 - 53.60)
Correct Option
Solution :
53.33 (53.00 - 53.60)
QUESTION ANALYTICS
Q. 16
Consider the figure shown below. If the saturation voltage of the op-amp output is same as the supply voltage, then the width of
the hysteresis loop of the circuit (i.e. UTP - LTP) will be ___________ V.
(assume op-amp is ideal)
12
Correct Option
Solution :
12
QUESTION ANALYTICS
Q. 17
The diode D1 in the figure shown below can be replaced by a 0.7 V battery when it is forward biased by a voltage greater than or
equal to 0.7 V. If the current source a ramp function i.e. then the output can be represented as
FAQ Solution Video Have any Doubt ?
A
Correct Option
Solution :
(d)
QUESTION ANALYTICS
Q. 18
The two transistors have but different values of width to length ratio. The
input to the transistor M2 of 5 V creates an output voltage to V0 = 0.1 V. If the value of then the value of is
equal to
FAQ Solution Video Have any Doubt ?
A 34.306
B 42.301
C 17.413
D 20.253
Correct Option
Solution :
(d)
QUESTION ANALYTICS
Q. 19
The biasing circuit is omitted which ensures that the circuit operates in active region. Neglecting the early effect the value of
Correct Option
Solution :
(c)
D
QUESTION ANALYTICS
Q. 20
Consider the circuit shown in the figure below. The biasing arrangement which ensures that both the transistors will work in
active region has been omitted. The two parallel connected transistors are completely identical i.e.
The base of the two transistors are fused as shown in the figure, then
the value of small signal input resistance as seen by the base of the two transistors is equal to
FAQ Solution Video Have any Doubt ?
Correct Option
Solution :
(b)
C
QUESTION ANALYTICS
Q. 21
Consider the N-MOS transistor as shown in figure below. The MOSFET has parameters
The transistor is used to amplify the small signal vin as shown in the figure. If the value of signal
then the value of output signal is equal to
then the value of output signal is equal to
D
Correct Option
Solution :
(d)
QUESTION ANALYTICS
Q. 22
The D.C. biasing of the circuit is such that the circuit is always in saturation region for all values of small signal input source .
The frequency of the input source is such that all the coupling capacitors acts as short circuit. If the value of the output
resistance RL and the drain resistance (RD) is equal, then the value of current gain is equal to
FAQ Solution Video Have any Doubt ?
A 4
B 2
C 0.5
D 0.25
Correct Option
Solution :
(d)
QUESTION ANALYTICS
Q. 23
Consider the difference amplifier as shown in the figure below. Assuming the op-amp to be ideal the CMRR of the circuit is
equal to
A 35.1 dB
B 41.6 dB
Correct Option
Solution :
(b)
C 74.4 dB
D 89.2 dB
QUESTION ANALYTICS
Q. 24
A –10 mV
B –20 mV
C 10 mV
Correct Option
Solution :
(c)
D 20 mV
QUESTION ANALYTICS
Q. 25
The open-loop gain of the amplifier is equal to AOL = 103, assuming the finite open loop gain to be the only non-idealy present in
the op-amp the value of close loop gain of the amplifier is
FAQ Solution Video Have any Doubt ?
A 101
B 98.9
C 91.73
Correct Option
S l ti
Solution :
(c)
84 63
D 84.63
QUESTION ANALYTICS
Q. 26
Consider the voltage series regulator circuit shown in the figure below. It is assumed that the transistors are biased in active
region with the voltage drop across the base-emitter terminal as VBE = 0.7 V. The current gain of the transistor If the
zener diode is working in the breakdown region with VZ = 8.3 V and the current through zener diode is negligible, then the
output voltage is
A 15.7 V
B 15 V
Correct Option
Solution :
(b)
C 14.7 V
D 14 V
QUESTION ANALYTICS
Q. 27
Consider the modified current mirror circuit shown in the figure below :
All the transistors connected in the circuit are identical with and value of A reference current of 100 mA is
forced into the circuit as shown in the figure. The circuit is used to drive N number of transistors i.e., Q1 to QN which are all
identical to the transistors QR used in mirror circuit. If it is required to maintain a minimum collector current of 99 mA, through
each transistor form Q1 to QN, then the maximum value of ‘N’ that can be achieved is equal to _________.
FAQ Solution Video Have any Doubt ?
24
Correct Option
Solution :
24
QUESTION ANALYTICS
Q. 28
A T-network is connected in the feedback circuit and resistor R3 is kept variable to after the gain of the amplifier. If the value of
then the value of R3 for which the gain of the amplifier is –8 V/V is __________ kΩ.
3
Correct Option
Solution :
3
QUESTION ANALYTICS
Q. 29
The value of RF and R1 are 100 kΩ and 1 kΩ respectively. It is an inverting amplifier with input offset voltage drift of
and input offset current drift of 0.5 nA/°C. The amplifier’s circuit output voltage is equal to zero at 25°C for zero input
voltage. If an input voltage of 7 mV is applied to the amplifier then the value of output voltage at 45°C is equal to _________ V.
(Assuming that the input offset voltage is taking at the non-inverting terminal as positive)
FAQ Solution Video Have any Doubt ?
Solution :
-0.67 (-0.50 - -0.90)
QUESTION ANALYTICS
Q. 30
The two transistors are biased such that the transconductance of both the transistors is 20 mA/V. If of the two transistors is
equal to 100, then the value of 3-dB cutoff frequency due to capacitor C is equal to _________ Hz.
FAQ Solution Video Have any Doubt ?
Solution :
1.81 (1.75 - 1.90)
QUESTION ANALYTICS
Q. 31
Consider the RC phase shift oscillator as shown in the figure below. The op-amp circuit is assumed to be ideal. The minimum
RF will the circuit have sustained oscillations at a frequency of 100 Hz is _______ kΩ.
FAQ Solution Video Have any Doubt ?
Solution :
188.21 (187 - 190)
QUESTION ANALYTICS
Q. 32
Consider the amplifier circuit shown below, which is biased with an ideal current source.
If the transistor has of 100 and early voltage VA of 10 V, then the small signal voltage gain will be ________.
(Assume VT = 25 mV).
FAQ Solution Video Have any Doubt ?
Solution :
-400 (-405 - -395)
QUESTION ANALYTICS
Q
Q. 33
In the circuit shown below, the MOSFET has threshold voltage of 1 V and The body terminal of the
device is shorted to the source terminal and the channel length modulation parameter is zero.
If it is required to keep the MOSFET always in the saturation region, then the maximum value of the gate voltage (Vg) that can
be applied will be _________ V.
FAQ Solution Video Have any Doubt ?
2
Correct Option
Solution :
2
QUESTION ANALYTICS