Professional Documents
Culture Documents
1. Furnish sand conforming to AASHTO M 6, class B including the reactive aggregate supplementary
requirement, except as amended or supplemented by the following:
2. For bridge decks or surface courses, do not use: (1) aggregates known to polish or carbonate; (2) aggregates
containing less than 25 percent by mass of insoluble residue as determined by ASTM D 3042.
a. Underdrain pipe with geotextile. Furnish granular backfill conforming to AASHTO M 80, class E and AASHTO
M 43, size number 3, 4, 5, 7, 57 or 67.
b. Underdrain pipe without geotextile. Furnish granular backfill conforming to AASHTO M 6, except the
soundness test is not required.
1. Furnish either sand conforming to Subsection 703.15 or coarse aggregate consisting of sound, durable
particles of gravel, slag or crushed stone conforming to Table 703-1.
703.05 Subbase, Base, and Surface Course Aggregate
1. General. Furnish hard, durable particles or fragments of crushed stone, crushed slag or crushed gravel
conforming to the following:
2. Do not use material that breaks up when alternately wetted and dried.
3. Obtain the aggregate gradation by crushing, screening, and blending processes as necessary. Fine aggregate,
material passing the 4.75mm sieve, shall consist of natural or crushed sand and fine mineral particles.
1. Furnish hard, durable particles or fragments of crushed stone or gravel conforming to the size and quality
requirements for crushed aggregate material normally used locally in the construction and maintenance of
highways by T&T Ministry of Works and Transport. Furnish crushed aggregate with a maximum size of 25 mm
as determined by AASHTO T 27 and T 11. Furnish crushed aggregate uniformly graded from coarse to fine and
free of organic matter, lumps or balls of clay, and other deleterious matter.
1. Coarse aggregate (retained on a 4.75mm sieve). Furnish hard, durable particles or fragments of crushed
stone, crushed slag, or crushed gravel conforming to the following:
2. For the surface course, do not use: (1) aggregates known to polish or carbonate; (2) aggregates containing
less than 25 percent by mass of insoluble residue when tested according to ASTM D 3042.
3. Fine aggregate (passing a 4.75mm sieve). Furnish natural sand, stone screenings, slag screenings or a
combination thereof conforming to AASHTO M 29 including sulphate soundness and the following:
5. Lightweight aggregate (slag). Furnish crushed slag conforming to the quality requirements of AASHTO M
195. Do not use any other kind or type of lightweight aggregate as defined in AASHTO M 195.