Professional Documents
Culture Documents
To provide a clear sealing coat on cementitious floors and a Nitoflor FC110 is resistant to a range of chemicals. Specific
dust-proof and more easily cleaned surface with resistance to data is available on request.
the penetration of oils and liquids. Ideal for warehousing,
garages and light industrial buildings. Maintenance
It is supplied in a single pack ready for use direct from the Surface preparation
can. Two coats are recommended.
It is essential that Nitoflor FC110 is applied to sound, clean
dry substrates in order to achieve maximum adhesion
Technical support between the floor coating and substrate.
Fosroc offers a comprehensive range of high performance, Because Nitoflor FC110 is a relatively thin coating, the
high quality flooring, jointing and repair products for both new substrate must be fine textured. Any surface irregularities
and existing floor surfaces. In addition, Fosroc offers a will show through causing excessive wear on high sports.
technical support package to specifiers, end users, and
contractors, as well as on-site technical assistance in New concrete floors
locations all over the world.
Unless water-reduced, the floor should be at least 28 days
Design criteria old. Dry removal of laitance by light grit-blasting is
preferable but, where this is not feasible, treat with an acid
wash, followed by thorough rising with water and complete
Nitoflor FC110 is designed for application in two coats to
drying. Dust and other debris should then be removed by
achieve an approximate total dry film thickness of 100
vacuum brush.
microns. Substrates should have a relative humidity not
greater than 80% at the time of installation.
Old concrete floors
Page 1
Nitoflor FC110
On sand/cement screeds, 3 or 4 coats may be required Precautions
depending on porosity. Where two or more coats are
applied, best results are obtained by not allowing more than Health and safety
24 hours between applications.
Nitoflor FC110 and Fosroc Solvent 102 should not come in
Cleaning contact with skin and eyes, or be swallowed. Avoid
inhalation of vapour/spray. Use only in well ventilated
Nitoflor FC110 should be removed from tools and areas. If working in confined areas, suitable respirator
equipment using Fosroc Solvent 101 immediately after use. protective equipment must be worn. Wear suitable
protective clothing, gloves and eye/face protection. Barrier
Limitations creams provide additional skin protection.
The durability of Nitoflor FC110 is reduced in areas of very Should accidental skin contact occur, remove with a suitable
heavy foot traffic such as around workbenches, drinks skin cleanser, followed b washing with soap and water. In
machines, doorways etc. It is advisable to either: case of contact wit eyes, rinse immediately with plenty of
water and seek medical advice. If swallowed seek medical
a) Specify additional coats in such areas or attention immediately - do not induce vomiting.
b) Specify a higher build system such as Nitoflor FC150 in
such areas (see relevant data sheet). Fire
Important note:
Fosroc products are guaranteed against defective materials and manufacture and are sold subject to its standard Conditions
for the Supply of Goods and Services, copies of which may be obtained on request. Whilst Fosroc endeavours to ensure that
any advice, recommendation, specification of information it may give is accurate and correct, it cannot, because it has no direct
or continuous control over where or how its products are applied, accept any liability either directly or indirectly arising from the
use of its products, whether or not in accordance with any advice, specification, recommendation of information given by it.
Registered Office: Industrial Area, Phase 4, Road No. 414, Street No. 407
Page 2 SA FO/NITOFLOR FC110/05/A