Professional Documents
Culture Documents
B
TO
BREW SOLDERING,
By BRAZING,
AND
John
Palmer
WELDING
Introduction TIPS
Acknowledgments
Glossary Soldering with a propane torch is the easiest way to join coppe
to stainless steel, you just need the proper flux. But there are a
Equipment time:
Appendix B
▾ rust and cracking after it is in service. The problem cannot be fi
heating the parts during the braze and keep the total time at t
usually not adequate for brazing. You will need to use MAPP ga
Brewing Metallurgy
Welding is the best methods for joining stainless steel, but it t
processes that will work- MIG (auto-wire feed type) and TIG (tu
Passivating Stainless Steel
for these small joints. Your best bet is to look in the Yellow Pag
job for you. The cost should be minimal, $20-50 depending on
Galvanic Corrosion onto 3 converted kegs for 20 dollars. If you want to do it yours
stainless before, here is what you need to know:
Soldering, Brazing, and Welding Tips
Table 20 - Suggested Welding Parameters
Appendix C
▾
Chillers
Appendix D ▾
Appendix E ▾
Appendix F ▾
Ideally, the backside of the weld should be purged with the arg
bother, so the backside of the weld joint should be ground/san
steel wool! To clean off the black/blue-ish oxides that could in
or braze joints on stainless steel, use the oxalic acid based clea
section.
Previous
-
Galvanic
Corrosion
Next -
Appendix
C
••••••••
NOTICE
OF
LIABILITY:
Neither the author,
editor, contributors, or
publisher assume any
responsibility for the
use or mis-use of the
information contained
in this book. It is the
responsibility of the
reader to excercise
good judgement and
to observe all local
laws and ordinances
regarding the
production and
consumption of
alcoholic beverages.
Copyright 1999-2015
by John Palmer. All
rights reserved. The
contents of this site, in
whole or in part, may
not be reproduced in
any form for
redistribution
(including non-
commercial use on
other websites)
without the author's
permission.