Professional Documents
Culture Documents
t
rese
r
ente
on
off
EG 110
Working principle : Time setting : To check your program :
The EG 110 is a time switch for the 1. Move mode selector to “prog”.
automatic control of electrical loads. 2. Press the “enter” key repeatedly to display
It is fully programmable with a maximum the different program steps (switching time
of 20 program steps. and state of the channel ON or OFF).
The front cover is sealable preventing prog
auto
unauthorised access after completion of manu
programming.
Warning : at the beginning of use, please
reset the device in order to clear the To modify or delete a program step :
memory before programming. on
reset
This is achieved by using a pen to push
enter
the reset button. off
ON
prog
1. Move mode selector to auto
manu
Presentation : 2. Input time with buttons “+” and “-”.
Important :
The clock starts when leaving the time setting mode.
on
2 reset
1 off enter
prog 3
OFF auto
manu
Programming :
1. Move mode selector to “prog”.
2. Press “enter” repeatedly and select the
on
reset
program step to modify or to delete.
enter
3. Modify :
off ON
prog
- switching time with keys “+” or “-”
4 5 6 7
auto - state of the channel with key “on/off”.
manu
To delete a program step, modify switching time
with keys “+” and “-”, until display --:-- (between
23:59 and 00:00).
Display : 4. Confirm with the “enter” key.
➀ time on
reset
➁ circuit status (ON or OFF) off enter
Buttons :
1. Move mode selector to “prog”.
➂ Mode selector : to select one of the 2. Input the switching time with buttons “+” and “-”.
following modes : 3. Input the type of switching with button “on/off” To override the output :
time setting (for the first action ON is automatically proposed). Permanent override :
prog programming 4. Enter this program step with button “enter”.
auto running mode
manu manual override Program additional time settings by repeating
➃ “on/off” : chooses whether the circuit steps 2 to 4.
is on or off Important : ON
➄ “+” and “-” : changes settings To activate the program, move mode selector to prog
auto
“auto”.
➅ “enter” : to confirm
manu
ON
prog
auto
manu
EG 110
on
reset
off enter 1 2 3 4 5 6
Warranty GB
A warranty period of 24 months is offered on hager products,
from date of manufacture, relating to any material of manu-
facturing defect. If any product is found to be defective it must
be returned via the installer and supplier (wholesaler). The
warranty is withdrawn if :
- after inspection by hager quality control dept the device is
found to have been installed in a manner which is contrary to
IEE wiring regulations and accepted practice within the industry
at the time of installation.
- the procedure for the return of goods has not been followed.
Explanation of defect must be included when returning
goods.
6E 6129.b