5 f
fibromat
EROSION CONTROL PRODUCTS
SPECIFICATIONS FOR THE USE OF A BIODEGRADABLE
EROSION CONTROL BLANKET AND HYDROSEEDINGMl
12
24
2.2
23
31
BIODEGRADABLE EROSION CONTROL BLANKET (FIBROMAT®)
‘The term biodegradable erosion control blanket shall referred as BECB.
PRODUCT SPECIFICATION
BECB should be machine made comprising of path straw bonded to alight
weight polypropylene mesh and should have the following measurement:
Norminal mass 250 g/m?
Normal Thickness 68mm
Roll width 2.1 t02.4
Roll size 100m?
INSTALLATION OF BECB BLANKET
Prior to install of BECB, the slope or other soil surface should be prepared
as in clause 4.
Prior to install the BECB, the slope should be seeded by hydroseeding as in
instructed in clause 3.
Prior to installation the BECB, unroll the mat with the netting facing
upwards and the path straw in contact with the soil. Install immediately after
seeding. Unroll the mat vertical to the contour, butting the ends and the
sides of adjoining mats by overlapping a minimum of 50mm.
BECB should be anchored to the ground with the use of U-shaped staples,
length 100-150mm, Smm diameter steel. Where the soil is very sandy the
steel staples should be replaced by bamboo sticks of at least 200mm long.
The general pattern of stapling is at 2 meter intervals both at the margins
and, in an off side line in the center of the roll. Extra stapling is required in
the back filled trench at the top of the slope, and wherever necessary to
accommodate the surface undulations.
SEEDING AND SEED MIXTURE AND FERTILISERS
Seeding is normally done by means of hydroseeder where a slurry of
seeds, fertilizers, binders and organic matter is sprayed on to soil surface.32
3.21
3.22
33
34
SEED MIXTURE
‘The seed mixture shall comprise the following recommended combination or
similar asinstructed by the consultant.
‘Seed Combination A (For hard material) Kgha
Centro (Centrosema pubescens) 10
Signal grass (Brachiaria decumbans) 5
Seed Combination B (for normal soil)
Bermuda grass (Cyenodon Dactylon) 5
Axonopus affinis (Cowgrass) 5
FERTILISERS AND SOIL AMENDMENTS
‘The following fertilisers and soil amendments should be mixed in the hydroseeder :
Type Rate of application
(g/m?)
‘NPK. 25.0
MULCHFIBRE
The following mulchfibre should be mixed in the hydroseeder :
Type Rate of application
(g/m2)
Coconut fibre (short) 50
‘Newsprint fibre 50