Professional Documents
Culture Documents
1. Sampling is helpful
for-------------------------------------------------------------------------------------------
quantisization
2. Sound waves are (It came in both
papers)----------------------------------------------------------------------longitudinal
a .Longitudinal b. Transverse c. Electro magnetic d. Gravitational
3. If two identical capacitors connected parallel then effective
capacitance..?----------------------------------C=C1+C2
4. Wein bridge is used to
measure---------------------------------------------------------------------------------
frequencies
24. They give Vmax and Vmin and ask us to find modulation
index?--------------------------------------------m= ((Vmax-Vmin}/ (Vmax+Vmin)
25. A voltage source of 5v with internal resistance 2 ohm can transfer max
power to load when the value of load resistance is-----2 ohm
26. In a communication system, noise is most likely to get into the system
30. Which one of the following terms does not apply to the Yagi-uda array?
(C) To prevent interference between two antennae when they are connected to
receiver
(D) To increase the speed of the pulses in the pulsed radar
(C) Watts
(D) In erlangs===================answer
38. Which of the following devices has its characteristics very close to that of
an ideal current source?
(D) MOSFET
47.ht of geostationary
satellite------------------------------------------------------------------------------------------
----36000 Km
54.deviation finding in
fm ?----------------------------------------------------------------------------------------------
----Phase locked loop (PLL circuit)
3.what is
nibble--------------------------------------------------------------------------------------------
---------------------4bits
12.magnetic flux
density-------------------------------------------------------------------------------------------
--------------weber
13.noise is measured
as:pitch,decibel--------------------------------------------------------------------------------
-----------decible
26. If u wants to connect two systems through telephone line which of the
following u will use..?----------modem
A. Bus B.Modem C.Router
30. Cell
converts.----------------------------------------------------------------------------------------
-----chemical to electrical
A. Chemical energy into electric energy
B. electric energy into chemical energy
33. If the gain of the open loop sys’m is doubled then gain margin will
become-------------------------doubled
36. They give change in force and change in diameter of a square plate. Ask us
to find change in pressure---(change in area/change in area)
37. They give three sets of measurements .Which are sets forms
triangle------------------the one where a+b>c where a,b,c are sides taken in any
order
52.hexadecimal digit-------------------------------------------------------------0-9,A-F
53.fluorescent tube related qn---------------------------------------------------choke
coil
56.unit of inductance-------------------------------------------------------------henry
65.compressed air inside a tire, what will happen if air passes through a
hole??------adiabatic process
==========================================================
=================================
67. related to carnot cycle in carnot engine
68.maximum efficiency of carnot engine
where:
T2 is the maximum operating temperature on absolute scale (K)
T1 is the minimum operating temperature on absolute scale (K)
For a heat engine operating between 300oC and 100oC, with a DT of 200
degrees, this maximum efficiency would be:
efficiency = 200/(300 + 273) x 100 = 34.9%
==========================================================
======================================
75.advantage of sampling
a) simple ckt
b) high speed transmission
data=======================================================
======answer
c) all of the above
==========================================================
====================================================
85.a particle whose motion is described by x=asinwt, y=asinwt z=ut moves
along
a) screw path with constant velocity and increase in accelaration
b) screw path with constant velocity and accelaration
c) screw path with increased velocity and accelaration
d) screw path with decreased velocity and increased accelaration
Answer is 'C' however if the question is x=asinwt,y=acoswt,z=ut...the answer
will be 'B'
the answer can be arrived by finding d/dx,d/dy,d/dz which are Vx,Vy,Vz then
finding resultant using sqrt(Vx^2+Vy^2+Vz^2)
similairly again by differentiating we obtain Ax,Ay,Az components of
Acc'n...then find their resultant ..similiarly
==========================================================
====================================================
94.Black
Body---------------------------------------------------------------------------------------------
-----------------ABSORBS/transmits all radns.
98.A material having resistivity=2 times copper covers a copper metal sheet of
same thickness of resistance 2 ohm ,then resistance of composite sheet is---
(6,2/3,4/3,3/4)-----------------------------------------------------------------------------------
---------------------3/4
105.Two taps A(requires 15 mins to fill a tank) and B(12 mins), time required
to fill d tank if both taps used ?--------(20/3) mins
108.Diesel Quality
by-------------------------------------------------------------------------------------------------
-------CETANE NO.
113..to prevent short circuit of surface waves, the polarization used is---
(vertcal,horizontal,circular,etc)--------------circular
119.why radioactivity of
elements-----------------------------------------------------------------------------------------
--nuclear fission
120.principle of hydrogen
bomb---------------------------------------------------------------------------------------------
nuclear fusion
128.HEAT IS MEASURED IS
WAT ?-------------------------------------------------------------------------------------------
---calories
148.what is motor called when its stator rotates at same speed as its
actuator--------------------------------------------syncronized motor
go to site www.careerairforce.nic.in for the question paper (click on model
question paper tab->EKT)
1B 2A 3B 4A 5A 6B 7A 8B 9C 10B
11B 12A 13A 14B 15C 16D 17A 18D 19A 20C
21A 22B 23D 24B 25C 26C 27B 28D 29D 30A
==========================================================
====================================================
<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<END OF
SECTION 2>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>
==========================================================
====================================================
==========================================================
====================================================
SECTION-3
<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<EKT-
COMPUTERS and
IT>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>
==========================================================
====================================================
16)Permanent Memory-
RAM,Dram,Rom,other----------------------------------------------------------------------
--------Rom (it is actually EEPROM)
3]micro-computer has a
——–--------------------------------------------------------------------------------------------
--- CPU
set of
instructions-------------------------------------------------------------------------------------
-------------------------program
recursion is used
in=========================================================
===============???
stack
queue
link list
all of the above
which is offline
device======================================================
================???
connected to cpu
not connected to cpu
direct storage
all of the above.
BCD is:
encoder====================================================
==============================answer
decoder
multiplexer
demultiplexer
cpu consists of
Arithmetic and logical
unit=======================================================
==============answer
timing and control unit
all of the above
one question was like some thing to transfer through bus then which will be
used:
DMA======================================================
===============================answer
Interrupt vector
one circuit was given
and option were
differentiator-----------------------------------------------------------------------------------
-----------------------------------high pass filter
Integrator---------------------------------------------------------------------------------------
----------------------------------low pass filter
2) A BYTE=
BITS ?-------------------------------------------------------------------------------------------
-----------------8
2)Which is d 1st
Computer---------------------------------------------------------------------------------------
-----------UNIVAC
3)CPU consists
of-------------------------------------------------------------------------------------------------
-----------ALU & CONTROL UNIT
==========================================================
====================================================
<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<END OF
SECTION 3>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>
==========================================================
====================================================
==========================================================
====================================================
SECTION-4
<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<EKT-
MECHANICAL,AERONAUTICAL>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>
>>>>>>>>>>>>>>>
==========================================================
====================================================
1) zeroth law of
thermodynamics------------------------------------------------------------------------------
------------------thermal equilibrium of bodies
6) weld spatter
means--------------------------------------------------------------------------------------------
-------------- defect
11)father of industrial
engg?--------------------------------------------------------------------------------------------
-------Fredrick Winslow Taylor
3) petrols quality
by-------------------------------------------------------------------------------------------------
------OCTANE NO
7)TIG welding
requires-----------------------------------------------------------------------------------------
------------ARGON N HELIUM.
8)Ideal Fluids
follow--------------------------------------------------------------------------------------------
------------PASCALS LAW.
9Process havn ini n final states
same--------------------------------------------------------------------------------------
CYCLE.
15)Steffan-Boltzman
law-----------------------------------------------------------------------------------------------
-----ABS TEMP RAISE 2 FOUR.
16)KIRCHOFFS LAW OF HEAT
TRANSFER------------------------------------------------------------------------------------
RATIO.
18)Violating laws of
thermo-------------------------------------------------------------------------------------------
------PMM.
21)Best weldable-.15%CS,.25%CS,// .
5%CS,.75%CS---------------------------------------------------------------------????
25)Dew pt of moist
air------------------------------------------------------------------------------------------------
------vapor condensation temperature
12.(not so sure) the velocity ratio of 8 teeth wheel and 100 teeth wheel in third
gear wheel is(1:12.5,1:800,etc)-----1:12.5
32) Brazing
----------------------------------------------------------------------------------------------------
------------HARD SOLDERING OF BRASS.
32.in 4-stroke engine,the cycle completes after how many revolutions of crank
shaft---(2,4,1+1/2,2+1/2)------------2
4]carnot-cycle–its effeciency and working
basics-------------------------------------------------------------------------(refer above)
==========================================================
====================================================
<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<END OF
SECTION 4>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>
==========================================================
====================================================
==========================================================
====================================================
SECTION-5
<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<EKT-
ELECTRICAL,ELECTRONICS,INSTRUMENTATION>>>>>>>>>>>>>>>
>>>>>>>>>>>>>>>>>>>>>>>>>>>
==========================================================
====================================================
4)the flow and timing of data to and from the micro processor is done
by---------------------------------------------------control pin
a)control pin b)data pin c)address pin d)....
5)given transfer function 2/(s+2) and w=10 find
gain------------------------------------------------------------------------0.196
a).44 b).33 c).196 d)...
8)kWh meter
is--------------------------------------------------------------------------------------------------
---------------recording type
a)recording type b)indicating type c)deflecting type d)..
9)synchronous motor
is--------------------------------------------------------------------------------------------------
------induction type
a)induction type b)cylindrical pole type c)salient pole type d)..
17)schmitt trigger
is--------------------------------------------------------------------------------------------------
---------squaring circuit
a)squaring ckt b).....c)...d)...
18)capacitor
is--------------------------------------------------------------------------------------------------
---------------conductor filled with dielectric
a)insulator filled with dielectric b)conductor filled with dielectric c)...d)...
go to site www.careerairforce.nic.in for the question paper (click on model
question paper tab->EKT)
==========================================================
====================================================
<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<END OF
SECTION 5>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>
==========================================================
====================================================
==========================================================
====================================================
SECTION-6
<<<<<<<<<<<<<<<<<<<<<<<<<<FAST TRACK SELECTION-
GENERAL+EC
combined>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>
==========================================================
====================================================
1.catalyst iz used
for------------------------------------------------------------------------------------------------
---------alters rate of reaction
(slow down the reaction rate, change in product part, inc the rate of
reation…………)
3.max value of
sin@+cos@-------------------------------------------------------------------------------------
--------------45 degrees
(at @= 30 deg., 45, 60, 90………….)
4.something related to prism ref index were given one angle is given and other
angle has to find----------------------n=sin[(A+D)/2]/sin(A/2)
n=refractive index
A=refracting angle
D=Deviation angle
5.latch is same as
----------------------------------------------------------------------------------------------------
--------D-F/F
( RS F/F, JK F/F, d F/F …………….)
6.principle of hydrogen
bomb---------------------------------------------------------------------------------------------
--uncontrolled nuclear fussion
( uncontrolled nuclear fission, controlled nuclear fission uncontrolled nuclesr
fussion, uncontrolled nuclesr fussion…….)
lambda=decay constant
8.property of
radioactivity------------------------------------------------------------------------------------
---------------gamma rays
(atomic nuclei, gamma rays, UV rays…………….)
9.carbon in million form
becoz---------------------------------------------------------------------------------------------
--catenation
(it is tetravalent, isomers, catenation…………..)
10.isotopes
r---------------------------------------------------------------------------------------------------
---------------same atomic no
( hav same atomic no. ,diff nuclei, diff no of protons……………………)
13. in
potassium---------------------------------------------------------------------------------------
----------------------4s>3d
( 4s>3p,4s>3d,4s<3p………….)
18. plane in air when turned in left wats happens to the nose and
tail----------------------------------------------------(actually tail of the airplane move
toward the left, causing the
nose
turn to the right. ...)
(nose raise and tail dowm, nose down tail raise, both remain in same
position……….)
45.in a molecule when oen atom is surrounded by four atom at corners the
structure is----------------------------tetravalent
(tetravalent, octavalent, ………….)
55. P no of persons promise to give Q$ but R persons did not give the S$ each
in charity wat is the eq for charity given
( don’t remember the proper language)
1) The triangle z, z+iz and iz of area or the side is 50 then in which plane it
lies-----------------------------------circle
1)circle 2)ellipse
2) If the area is increased by 69% then how much the side of the square will
increase----------------------------30 % (new area=1.69*side^2
=(1.3*side)*(1.3*side)=i.e. 30%
increase in length of side)
1)13% 2)69% 3)130%
7) Isotopes
means--------------------------------------------------------------------------------------------
---------same at no,different at wt
8) At zero Kelvin the semiconduction in semiconductor is because
of-----------------------------------------------???
11) In Geometric Progression all are +ve nos, first consecutive two nos are
same then common ratio will be----1
12) TWT
question-----------------------------------------------------------------------------------------
-------------???
25) At 0 K semiconductor
becomes-------------------------------------------------------------------------------------
insulator
1)dielectric 2)insulator
26) Water is flowing in a pipe of dia given and spped also given when it is
attached with another pipe of diameter given then what is the speed of the
water in second pipe
----------------------------------------------------------------------------------------------------
----------------------A1*V1=A2*V2
27) Cal of linear strain if weight is given and length it elongates also
given-----------------------------------------Y=stress/strain=(Wt/A)/(l/L)
32) In which compound will the sulphur will have more than one oxidation
state-----------------------------------H2S2O7
36) Probablity of occurence of A is given neither A nor B also given and stated
A and B are independent events.
Probability of occurence of B will
be---------------------------------------------------------------------------------???
1)1/4 2)35482
38) logxto the base 8 +logxto the base 4+logxto the base 4=11 then value of
x-----------------------------------64
1)8 2)64
==========================================================
====================================================
43) In trajectile related question Range is given 100 m Initial velocity is 800
m/sec. find height of the object
H=u(squared)*sin@(squared)/2g
44) Ball drops from height of 200 metres bounds back of 2/3 of its height
when it comes to rest what will be total distance
travvelled-----------------------------------------------------------------1000 meters
(actually dia-magnetic)
1)Ferro magnetic substances 2)Non ferro magnetic
46) Same input given to NAND gate then the operation is said to
be---------------------------------------------------------NOT
1)NAND 2)NOT
47) Susceptability
unit-----------------------------------------------------------------------------------------------
----------unitless
1)Wb-Am 2)WbAm-2
51) Peroxide
effect---------------------------------------------------------------------------------------------
----------------Free radical moment
53) Two sine wave modulated by carrier wave of index 0.3 and 0.7 the
combined index would be-------------------------0.76 to be precise
1)1 2)0.5 3)0.7
------------------------------------------------------
XXXXXXXXXXXXXXXXXXXXXXXXXXXXXXXXXX--------------------------
---------------------------------------
navya,vertika,ronny,chetan,arundhati,neeraja,sushma,prachi,ricky,mahesh