Professional Documents
Culture Documents
Introduction
2-in/2-out USB3.0 Audio Converter
The is an audio converter with a SuperSpeed USB3.0 interface.
In addition to supporting Windows and Mac, using class compliant mode it can also be connected to
an iPad. Since it also supports recording and playback at up to 24-bit/192kHz, it can also be used for the
playback of high-resolution sound sources delivered with superior audio quality over the Internet.
Precautions Copyrights
t8JOEPXT® is a registered trademark of Microsoft® Corporation.
Product handling
t.BD®, iPad® and Lightning™ are trademarks or registered trademarks of Apple Inc.
Do not drop, bump or apply excessive force to the unit.
tMIDI is a registered trademark of Association of Musical Electronics Industry (AMEI).
Be careful not to allow foreign objects or liquids enter the unit. t"MMPUIFSQSPEVDUOBNFT
USBEFNBSLTBOEDPNQBOZOBNFTJOUIJTEPDVNFOUBSF
Operating environment the property of their respective owners.
Note: All trademarks and registered trademarks in this document are for
Do not use in extremely high or low temperatures.
identification purposes only and are not intended to infringe on the copyrights of
Do not use near heaters, stoves and other heat sources.
their respective owners.
Do not use in very high humidity or where it could be splashed by water.
Do not use in places with frequent vibrations.
Recording for any purpose other than personal use from copyrighted sources,
Do not use in places with much dust or sand. including CDs, records, tapes, live performances, video works and broadcasts,
Connection cables and input/output jacks without permission of the copyright holder is prohibited by law.
Zoom Corporation will not assume any responsibility related to infringements of
Always turn the power OFF for all equipment before connecting any
cables. copyrights.
Always disconnect all connection cables and the AC adapter before
moving the unit. 3
Part Names
Top Panel
Part Names
Power indicator
INPUT 2 jack
Hi-Z switches OUTPUT knob
XLR TRS
2 1 TIP : HOT
1 : GND RING : COLD
2 : HOT SLEEVE : GND
3 3 : COLD
4
Rear Panel
Part Names
POWER switch DIRECT MONITOR switch
5
Connecting with a Computer
Connecting with a Computer
NOTE
t 4FFUIF*OTUBMMBUJPO(VJEFJODMVEFEJOUIFESJWFSQBDLBHFGPSEFUBJMFEJOTUBMMBUJPOQSPDFEVSFT
6
Connecting with a Computer
Turning the Power ON
Before turning the power on, minimize the volumes of the and
connected devices.
2. Set to ON.
NOTE
t 5IF cannot be used if it is not connected to a computer.
t *GUIFQPXFSTVQQMJFECZUIF64#CVTJTMPX
PSZPVXBOUUPPQFSBUFUIFVOJUXJUIBOBEBQUFS
use the optional AD-14 adapter that was designed for use with this unit.
By using the optional power adapter for this unit (AD-14), you can connect
iPad connection
it to an iPad.
1. Set to ON.
<Rear>
NOTE
t 5VSOUIFQPXFS0''CFGPSFDIBOHJOHUIF$-"44$0.1-*"/5.0%&TXJUDITFUUJOH
If the power is already ON, changing the CLASS COMPLIANT MODE switch will have no
effect.
8
3.
iPad connection
Connect the and the iPad using an Apple iPad Camera
Connection Kit or Lightning to USB Camera Adapter.
<Rear>
9
Connecting Instruments
<Front>
Keyboard
(TRS cables)
Connecting Instruments
10
Connecting Mics
Recording
<Front>
Dynamic mic
(XLR cable)
Connecting Mics
Condenser mic (XLR cable)
11
"EKVTUJOH*OQVU(BJO
HINT
t 4FUJUTPUIBUUIFMFWFMJOEJDBUPSEPFTOPUMJHIUSFE
12
Connecting Headphones and Speakers
Playback
1. Connect headphones or speakers.
<Front> <Rear>
13
Using Direct Monitoring
14
Connecting MIDI Devices
<Rear>
MIDI keyboard,
MIDI controller Sound module
MIDI OUT jack MIDI IN jack MIDI OUT jack MIDI IN jack
NOTE
t 8IFO VTJOH B .*%* QPSU XJUI B %"8
GPS FYBNQMF
GPMMPX UIF JOTUSVDUJPOT CFMPX XIFO
making settings.
The or might not function properly otherwise.
Windows
6TF;00.6"$.*%*%POPUVTF.*%**/065 ;00.6"$.*%*
Mac
6TF;00.6"$.*%**01PSU%POPUVTF;00.6"$3FTFSWFE1PSU
15
Restoring Factory Default Settings
Follow these instructions to initialize settings, restoring them to their factory defaults.
16
Troubleshooting
Troubleshooting
Cannot select or use the device Sound skips during playback or recording
t Confirm that the is connected to the t If you can adjust the audio buffer size of the
computer correctly. software that you are using, increase the buffer
t Quit all the software that is using the , size.
and disconnect and reconnect the USB cable t Turn the automatic sleep function and other
connected to the . computer power saving settings OFF.
t Reinstall the driver. t Connect the directly to a USB port on
t Connect the directly to a USB port on the computer. Do not connect it to a USB hub.
the computer. Do not connect it to a USB hub.
Cannot play or record
Playback sound cannot be heard or is quiet
t Confirm that the Sound setting of the computer
t Check the speaker connections and volume UIBUZPVBSFVTJOHJTTFUUP;00.6"$
settings on the speakers. t Confirm that is set for input and output
t A djust the O U T P U T and P H O N ES volume in the software that you are using.
controls. t Confirm that i s c o n n e c te d to t h e
t Confirm that the Sound setting of the computer computer correctly.
UIBUZPVBSFVTJOHJTTFUUP;00.6"$ t Quit all the software that is using the ,
and disconnect and reconnect the USB cable
Recorded audio is too loud, too quiet or silent connected to the .
t Adjust the input gain of the . Cannot use with an iPad
t When using a condenser mic, turn phantom
power on. t Turn Class Compliant Mode ON. (→P.8)
t Confirm that the Sound setting of the computer t Confirm that the AD-14 adapter designed for this
UIBUZPVBSFVTJOHJTTFUUP;00.6"$ unit is connected.
17
Specifications
Specifications
18
FCC regulation warning (for U.S.A.)
This equipment has been tested and found to comply with the limits for a Class B digital device, pursuant
to Part 15 of the FCC Rules. These limits are designed to provide reasonable protection against harmful
interference in a residential installation. This equipment generates, uses, and can radiate radio frequency
energy and, if not installed and used in accordance with the instructions, may cause harmful interference
to radio communications. However, there is no guarantee that interference will not occur in a particular
installation. If this equipment does cause harmful interference to radio or television reception, which can be
determined by turning the equipment off and on, the user is encouraged to try to correct the interference by
one or more of the following measures:
t3FPSJFOUPSSFMPDBUFUIFSFDFJWJOHBOUFOOB
t*ODSFBTFUIFTFQBSBUJPOCFUXFFOUIFFRVJQNFOUBOESFDFJWFS
tConnect the equipment to an outlet on a circuit different from that to which the receiver is connected.
t$POTVMUUIFEFBMFSPSBOFYQFSJFODFESBEJP57UFDIOJDJBOGPSIFMQ
For EU Countries
Declaration of Conformity
ZOOM CORPORATION
,BOEB4VSVHBEBJ
$IJZPEBLV
5PLZP+BQBO
http://www.zoom.co.jp
Z2I-2314-0