You are on page 1of 2

WALL WASHING TABLE SURGICAL

INSTRUMENTS, TWO SINK & GUN FOR


MATERIAL CLEANING WITH PREASUREZ
AIR / WATER

PRESENTATION :

Stainless-steel table with two washing tubs are equipped with 2 "Cleaning gun" that can be functioned
for pressurized air and water pressure, making it easier for the user in terms of washing and drying of
medical equipment.

TECHNICAL DATA:

MATACHANA wall washing table for surgical instruments, made of AISI-304 stainless steel, provided with
two central washing sink on the right hand, with Monobloc tap for two water supplies cod. 86004, drain
valve, with a bottom shelf and adjustable height legs with rubber caps, equipped with anti-splash rear
frame.
- Dimensions: 2500 x 600 x 900 mm. (length x depth x height).

Set of Cleaning Gun :


Gun for material cleaning with preasurez air
Gun for material cleaning with preasurez Water
Oil Free Compressor

ANTONIO MATACHANA S.A.


TEL: +34 93 486 87
Air/Water Spray Gun (Code 81180)

The Spray Gun is the ideal instrument for cleaning laboratory glassware, pipettes,
syringes, catheters, curettes, endoscopes, cystoscopes, cannulae and a variety of
other instruments and articles used in Sterile Services, laboratories, and medical
practices in other words, everywhere where highest cleanliness and hygiene are
mandatory.

The Spray Gun uses either water or pressurized air this means the cleaning process
is quick, efficient and inexpensive.

The Spray Gun features a new type of internal flow control mechanism. It permits
the smooth and simple adjustment of the water or air flow across the entire range
of the trigger movement.

The desired maximum water or air flow can be set by using the small knurled
screw located behind the trigger. It is then regulated via the trigger up to the set
maximum value.

The gun grip is heat insulated.

The Selecta Spray Gun can be ready for operation very quickly:

• The storage rack with the attachments is fastened to a wall


near the sink or work area.
• The tubing is connected to the tap with a threaded
connector.
• If the spray gun is to be operated with compressed air, the
tubing must be connected to the air supply by means of a
suitable connector.

ATTACHMENTS:

All attachments are connected to the spray gun by seating them on the safety cone located at the
spray gun tip. Even high pressure cannot disconnect them.

a) for syringes and cannulas with record cone


b) for measuring and blood pipettes
c) for catheters, valves etc.
d) for drainage tubings
e) for syringes and cannulas with Luer cone
f) spray jet for rapid instrument cleaning
g) for bottles and Erlenmeyer flasks
h) water jet pump for suction cleaning

ANTONIO MATACHANA S.A. Autor: EM Versión: 1.0


TEL: +34 93 486 87 00 Revisado: Archivo: 81180 Air water spray gun.doc
www.matachana.com Fecha: 17-09-10 Página 1 de 1

You might also like