Professional Documents
Culture Documents
3. Aim: To Model the given 3D-Part with Dimensions by using solid work.
4. Aim: To Model the given 3D-Part with Dimensions by using solid work.
The cylinder vessel of inner diameter 8 inch with hemispherical end caps. The vessel has a wall
thickness of 0.5 inch where the centers of hemisphere are 15 inch apart.
5. Aim: To assemble the given 3D parts by using solid works.
The cylinder vessel of inner diameter 8 inch with hemispherical end caps. The vessel
has a wall thickness of 0.5 inch where the centers of hemisphere are 15 inch apart.
7. Aim: To Analyze steady state heat transfer analysis of the given plate component of
temperature 700°c one side and 400°c of another side for "chromium copper" material.
8. Aim: To Estimate the Natural frequencies and mode shapes of 2DBeam fixed at both ends.
10. Aim: To perform profile milling to generate the component as shown in figure
11. Aim: To perform step turning operation to generate the component as shown in figure
12. Aim: To perform step turning and threading operation to generate the component as shown
in figure