Professional Documents
Culture Documents
htm
Rife Generator...
Orgone/Life Energy
This is my initial messy setup for working with a modulated radio frequency
generator. I have a scope, a pulse generator, an assortment of power supplies,
an assortment of capacitors, and an assortment of television fly back
transformers. Basically, I am just throwing parts together from television sets
and junk stereos that I have laying around, and observing what happens. Not
much mathematics has been performed up to this point. Everything so far has
been just trial and error. The concept is simple. Create a tuned radio
frequency carrier signal that will propagate through space, and modulate
that signal with a bioelectric frequency chopper. I chose to begin working
with the television fly back transformer because it is a good cheap (i.e. free)
HV transformer, and smashing it with pulses from a simple 555 timer
chopper circuit. The 555 timer IC is perfect for chopping RF energy into
biological frequencies. TV Fly back transformers are not especially lethal,
yet strong enough to do the job. This is a prime example of a manic electronic
attack.
Above is a multi tap transformer from an audio amplifier that I ripped out of
something somewhere. I located a tap that provides 18 volts at an unknown
current value. This voltage might burn up the 555 but I gave it a try anyway.
This tank transformer turned out not to be powerful enough. I am currently
adapting a computer switching power supply that should supply 20 amps into
the circuit. The 2N3055 NPN power transistor is attached to an old P3 heat
sink. This transistor amplifies the current that the 555 chopper can supply, so
that it can drop across the 10 winds of primary wire and induce a strong
magnetic field. I am driving the base of this transistor directly from pin 3 of
the 555.
Here you can see the 1 inch arc generated with a 2 Amp 12V chopped input
to the television fly back transformer. The audio transformer could not
handle the load, and stopped the chopper circuit every time the fly back was
triggered. I added a nice large 4000UF smoothing capacitor across the DC
output and it makes a very nice thick steady arc now.
IGBIT-Chopper-Schematic.pdf
This hand held device will be used to detect and record very small
electrostatic changes that have settled into the environment, or to detect and
record changing electrostatic fields in the environment. The final product is
intended to have an attractive appearance, much like the devices used in the
GhostBusters movies, as this will assist with commercial acceptance and
resale. For now our main target will be paranormal researches, and will
function in the best manner that we can determine through research and
testing, and development.
This device will emit a "known" electrostatic signal, and amplify the
difference of the known electrostatic signal, with the ambient electrostatic
signal. The product plan is to make magnitude adjustment and phase
adjustment controls to tune into the environment. Once the environment has
been tuned in, then create modulated sounds, that provide audio monitoring,
as well as interesting LED / meter type of displays for visual metering. An
audio output jack will allow users to record active sessions with voiceover
onto portable voice recorders.
The plan is to build each circuit separately on a prototype board with the
proper measuring equipment, and construct this device through
experimentation with each stage. These schematics will serve as a basis for
our investigations, but empirical testing will determine the best overall
construction.
..
...
....
.....