Professional Documents
Culture Documents
DEKE2443
ANALOGUE ELECTRONICS II
Experiment 3: Voltage Regulator Using LM 7805 and LM 7905
Score :
TITLE
Voltage Regulator Using LM 7805 and LM 7905
LEARNING OUTCOME
At the end of this lab, student should be able to:
1) Identify the functionality of IC regulators (three terminal voltage regulators).
2) Compare between the functionality of LM 7805 and LM 7905.
3) Simulate and analyze the functionality of LM 7805 and LM 7905 using engineering software.
EXPERIMENT PROCEDURE
Part 1 (Early Preparation): Simulate Voltage Regulator Using LM 7805 and LM 7905 using P-
Spice/ Multisim/ Proteus Software
1. Construct and simulate a complete dc power supply as in Figure 1.
2. Choose suitable setting for V1 and vary capacitors using 100uF(16V/25V/30V).
3. Analyze the output signal of LM 7805 and LM7905.
(Note: Schematic diagram and output waveforms need to be label with name of group
members and student matric ID)
Figure 1
2. From the data obtained from Figure 1, calculate the peak voltage, Vp of the input circuit.
Vp = Vrms x √2
= ____ x √2
= _____ V
3. Calibrate the oscilloscope and make the setting of the input and output signals
i.e : Input (CH 1)= voltage/div = 5 V/div ; time/div = 5ms/div
Output (CH 2) = voltage/div = 5 V/div; time/div = 5ms/div.
4. Connect the oscilloscope to the circuit and observe the rms input signal, 6V at Channel 1.
Record the value.
Vp = _____V
5. Measure and observe the output voltage, Vout of the circuit (LM 7805) at Channel 2.
Record the value.
Vp = ______V
6. Sketch the resulting waveform (input signal, Vp and output, Vout– LM 7805).
7. Repeat step 3 to 6 to measure and observe the output voltage, Vout of the circuit (LM 7905) at
Channel 2.
Record the value.
Vp = ______V
8. Sketch the resulting waveform (input signal, Vp and output,Vout– LM 7905).