Professional Documents
Culture Documents
4-687-310-11(1)
www.sony.eu/support
TM
VIDEO/AUDIO
UBP-X800
UBP-X800
4-687-310-11(1)
D:\JOB\SONY master page=left
DVD\2016\SD160015\4687310111_GB\010COVTOC.f
m
Contents
WARNING
WARNING . . . . . . . . . . . . . . . . . . . . . . . . . . 2
PRECAUTIONS . . . . . . . . . . . . . . . . . . . . . . 3 To reduce the risk of fire or electric shock, do not
expose this appliance to dripping or splashing,
and do not place objects filled with liquids, such
Getting Started as vases, on the appliance.
Additional Information
Troubleshooting . . . . . . . . . . . . . . . . . . . 26
Playable discs . . . . . . . . . . . . . . . . . . . . . 29 This appliance is classified as a CLASS 1 LASER
Playable types of files . . . . . . . . . . . . . . . 31 product. The CLASS 1 LASER PRODUCT MARKING
Specifications . . . . . . . . . . . . . . . . . . . . . . 33 is located on the rear exterior.
UBP-X800
4-687-310-11(1)
D:\JOB\SONY master page=right
DVD\2016\SD160015\4687310111_GB\010COVTOC.f
m
Notice for customers in the United This product has been manufactured by or on
Kingdom and Republic of Ireland behalf of Sony Corporation, 1-7-1 Konan Minato-
A molded plug complying with BS1363 is fitted to ku Tokyo, 108-0075 Japan. Inquiries related to
this equipment for your safety and convenience. product compliance based on European Union
Should the fuse in the plug supplied need to be legislation shall be addressed to the authorized
replaced, a fuse of the same rating as the representative, Sony Belgium, bijkantoor van
supplied one and approved by ASTA or BSI to Sony Europe Limited, Da Vincilaan 7-D1, 1935
BS1362, (i.e., marked with or mark) must Zaventem, Belgium. For any service or
be used. If the plug supplied with this guarantee matters, please refer to the addresses
equipment has a detachable fuse cover, be sure provided in the separate service or guarantee
to attach the fuse cover after you change the documents.
fuse. Never use the plug without the fuse cover.
If you should lose the fuse cover, please contact Notice for the customers in Europe
your nearest Sony service station.
Disposal of waste batteries and
electrical and electronic
This product is intended to be used in the
equipment (applicable in the
following countries:
European Union and other
AL, AT, BA, BE, BG, CH, CY, CZ, DE, DK, EE, ES, FI,
European countries with FR, GB, GR, HR, HU, IE, IS, IT, LI, LT, LU, LV, MD,
separate collection systems) ME, MK, MT, NL, NO, PL, PT, RO, RS, SE, SI, SK,
This symbol on the product, the battery or on the Kosovo.
packaging indicates that the product and the Hereby, Sony Corporation declares that this
battery shall not be treated as household waste. equipment is compliance with the essential
On certain batteries this symbol might be used requirements and other relevant provisions of
in combination with a chemical symbol. The Directive 1999/5/EC. For details, please access
chemical symbols for mercury (Hg) or lead (Pb) the following URL:
are added if the battery contains more than http://www.compliance.sony.de/
0.0005% mercury or 0.004% lead. By ensuring
these products and batteries are disposed of
correctly, you will help prevent potentially
negative consequences for the environment and
human health which could otherwise be caused
PRECAUTIONS
by inappropriate waste handling. The recycling
• This unit operates on 220 V - 240 V AC,
of the materials will help to conserve natural
50/60 Hz. Check that the unit’s operating
resources.
voltage is identical with your local power
supply.
In case of products that for safety, performance • Install this unit so that the mains lead can be
or data integrity reasons require a permanent unplugged from the wall socket
connection with an incorporated battery, this immediately in the event of trouble.
battery should be replaced by qualified service • 5,150 - 5,350 MHz band is restricted to
staff only. To ensure that the battery and the indoor operations only.
electrical and electronic equipment will be • This equipment has been tested and found
treated properly, hand over these products at to comply with the limits set out in the EMC
end-of-life to the applicable collection point for Directive using a connection cable shorter
the recycling of electrical and electronic than 3 metres.
equipment. For all other batteries, please view • Place the player in a location with adequate
the section on how to remove the battery from ventilation to prevent heat build-up in the
the product safely. Hand the battery over to the player.
applicable collection point for the recycling of • To reduce the risk of fire, do not cover the
waste batteries. For more detailed information ventilation opening of the appliance with
newspapers, tablecloths, curtains, etc.
about recycling of this product or battery,
• Do not expose the appliance to naked flame
plsease contact your local Civic Office, your
sources (for example, lighted candles).
household waste disposal service or the shop
• Do not install this player in a confined
where you purchased the product or battery. space, such as a bookshelf or similar unit.
UBP-X800
4-687-310-11(1)
D:\JOB\SONY master page=left
DVD\2016\SD160015\4687310111_GB\010COVTOC.f
m
• Do not place the player outdoors, in • Do not turn up the volume while listening to
vehicles, on ships, or on other vessels. a section with very low level inputs or no
• If the player is brought directly from a cold audio signals. Your ears and the speakers
to a warm location, or is placed in a very may be damaged when the sound level
damp room, moisture may condense on the reaches the peak.
lenses inside the player. Should this occur, • Clean the cabinet, panel, and controls with
the player may not operate properly. In this a soft cloth. Do not use any type of abrasive
case, remove the disc and leave the player pad, scouring powder or solvent such as
turned on for about half an hour until the alcohol or benzine.
moisture evaporates. • Do not use cleaning discs or disc/lens
• Do not install the player in an inclined cleaners (including wet or spray types).
position. It is designed to be operated in a These may cause the apparatus to
horizontal position only. malfunction.
• Do not place metal objects in front of the • In the events that this player is repaired,
front panel. It may limit reception of radio repaired parts may be collected for reuse or
waves. recycling purposes.
• Do not place the player in a place where • Observe the following as improper handling
medical equipment is in use. It may cause a may damage the HDMI OUT jack and the
malfunction of medical instruments. connector.
• If you use a pacemaker or other medical – Carefully align the HDMI OUT jack on the
device, consult your physician or the rear of the player and the HDMI connector
manufacturer of your medical device before by checking their shapes. Make sure the
using the wireless LAN function. connector is not upside down or tilted.
• This player should be installed and
operated with a minimum distance of at
least 20 cm or more between the player and
a person’s body (excluding extremities:
hands, wrists, feet and ankles).
• Do not place heavy or unstable objects on
the player.
• Do not place any objects other than discs on – Be sure to disconnect the HDMI cable
the disc tray. Doing so may cause damage when moving the player.
to the player or the object.
• Take out any discs from the tray when you
move the player. If you don’t, the disc may
be damaged.
• Disconnect the AC power cord (mains lead)
and all other cables from the player when
you move the player. – Hold the HDMI connector straight when
• The player is not disconnected from the AC connecting or disconnecting the HDMI
power source (mains) as long as it is cable. Do not twist or force the HDMI
connected to the wall outlet, even if the connector into the HDMI OUT jack.
player itself has been turned off.
• Disconnect the player from the wall outlet if
you are not going to use the player for a
long time. To disconnect the AC power cord
(mains lead), grasp the plug itself; never
pull the cord.
• Observe following points to prevent the AC
power cord (mains lead) being damaged.
Do not use the AC power cord (mains lead)
if it is damaged, as doing so may result in an
electric shock or fire.
– Do not pinch the AC power cord (mains
lead) between the player and wall, shelf,
etc.
– Do not put anything heavy on the AC
power cord (mains lead) or pull on the AC
power cord (mains lead) itself.
UBP-X800
4-687-310-11(1)
D:\JOB\SONY master page=right
DVD\2016\SD160015\4687310111_GB\010COVTOC.f
m
IMPORTANT NOTICE
Caution: This player is capable of holding a
still video image or on-screen display image
on your television screen indefinitely. If you
leave the still video image or on-screen
display image displayed on your TV for an
extended period of time you risk permanent
damage to your television screen. Plasma
display panel televisions and projection
televisions are susceptible to this.
UBP-X800
4-687-310-11(1)
D:\JOB\SONY master page=left
DVD\2016\SD160015\4687310111_GB\020WAR.fm
Getting Started
Supplied Accessories
• Remote commander (remote) (1)
• R03 (size AAA) batteries (2)
UBP-X800
4-687-310-11(1)
Getting Started
D:\JOB\SONY master page=right
DVD\2016\SD160015\4687310111_GB\030STU.fm
Front panel
A B C D
Getting Started
F E
Rear panel
UBP-X800
4-687-310-11(1)
D:\JOB\SONY master page=left
DVD\2016\SD160015\4687310111_GB\030STU.fm
A Z (open/close)
Remote Opens or closes the door tray.
TV 1 (TV on/standby)
The available functions of the remote are Turns on the TV, or sets to standby mode.
different depending on the disc or the 1 (on/standby)
situation. Turns on the player, or sets to standby
mode.
NET SERVICE
Returns to the previous online service
portal.
TV t (TV input select)
Switches between TV and other input
sources.
BLUETOOTH (page 16)
• Scan device list will appear if this player
has no paired Bluetooth device.
• Connect to the last connected device if
this player has a paired Bluetooth
device. If the connection fails, scan
device list will appear.
• Disconnect the connected Bluetooth
device.
B Colour buttons (red/green/yellow/
blue)
Shortcut keys for interactive functions.
C (favourite) (page 13)
Accesses the application registered as
favourite.
NETFLIX
Accesses the “NETFLIX” online service.
For further NETFLIX online service details,
visit the following website and check the
FAQ:
www.sony.eu/support
TOP MENU
Opens or closes the Ultra HD Blu-ray/BD/
DVD’s Top Menu.
POP UP/MENU
Opens or closes the Ultra HD Blu-ray/BD/
DVD’s menu.
OPTIONS (page 17)
Displays the available options on the
screen.
RETURN
Returns to the previous display.
z
N , TV 2 +, and AUDIO buttons have a tactile
dot. Use the tactile dot as a reference when
operating the player.
UBP-X800
4-687-310-11(1)
D:\JOB\SONY master page=right
DVD\2016\SD160015\4687310111_GB\030STU.fm
</M/m/, (muting)
Moves the highlight to select a displayed Turns off the TV sound temporarily.
item. TV 2 (volume) +/–
z Adjusts the TV volume.
• M/m as a shortcut key to launch track DISPLAY
search window and input track number Displays the playback information on the
during music CD playback. screen.
• M/m as a shortcut key to rotate photo To lock the disc tray (Child Lock)
clockwise/counterclockwise by 90
You can lock the disc tray to avoid accidental
degrees.
opening of the tray.
• </, as a shortcut key to perform seek
Getting Started
While the player is turned on, press x (stop),
functions during Home Network video
HOME, and then TOP MENU button on the
playback.
remote to lock or unlock the tray.
• </, as a shortcut key to change still
image when it is enabled to change.
Centre button (ENTER)
Code numbers of controllable TVs
Enters the selected item.
HOME
Hold down TV 1 and the TV manufacturer’s
Enters the player’s home screen.
code using the remote buttons for 2 seconds.
D m/M (fast reverse/fast forward) If more than one remote button is listed, try
• Fast reverse/fast forward the disc when entering them one at a time until you find the
pressed during playback. The search one that works with your TV.
speed changes each time you press the
button. Manufacturer Remote Button
• Plays in slow motion when pressed for Sony (Default) NET SERVICE
more than one second in pause mode.
• Plays one frame at a time when pressed Philips TV t /
for a short time in pause mode. BLUETOOTH / POP
N (play) UP/MENU
Starts or re-starts playback.
Panasonic Colour button (red) /
./> (previous/next)
NETFLIX
Skips to the previous/next chapter, track,
or file. Hitachi Colour button
X (pause) (green)
Pauses or re-starts playback. Sharp Colour button
SUBTITLE (page 22) (yellow)
Selects the subtitle language when multi- Toshiba Colour button (blue)
lingual subtitles are recorded on Ultra HD
Blu-ray/BD/DVD. Loewe (favourite)
x (stop) Samsung TOP MENU
Stops playback and remembers the stop
point (resume point). LG/Goldstar RETURN
The resume point for a title/track is the
last point you played or the last photo for
a photo folder.
AUDIO (page 22)
Selects the language track when multi-
lingual tracks are recorded on Ultra HD
Blu-ray/BD/DVD.
Selects the sound track on CDs.
UBP-X800
4-687-310-11(1)
D:\JOB\SONY master page=left
DVD\2016\SD160015\4687310111_GB\030STU.fm
Do not connect the mains lead until you have made all the connections.
Connecting to your TV
HDMI Cable*
* Premium High Speed HDMI Cable (not supplied) or High Speed HDMI Cable that supports 18 Gbps
bandwidth (not supplied).
b
• To enjoy 4K Ultra HD 60p content, you need to connect the player to your 4K TV using Premium High
Speed HDMI Cable or High Speed HDMI Cable that supports 18 Gbps bandwidth.
• 4K output requires a compatible 4K display which has HDCP2.2 capable HDMI input.
• If you use BRAVIA TV that supports 4K60p, set the TV’s “HDMI signal format” setting to “Enhanced
format”.
10
UBP-X800
4-687-310-11(1)
D:\JOB\SONY master page=right
DVD\2016\SD160015\4687310111_GB\030STU.fm
A 4K AV amplifier (receiver)
Getting Started
t To enjoy Bitstream (Dolby/DTS), set [BD Audio MIX Setting] in [Audio Settings] (page 21).
HDMI Cable*
HDMI Cable*
* Premium High Speed HDMI Cable (not supplied) or High Speed HDMI Cable that supports 18 Gbps
bandwidth (not supplied).
11
UBP-X800
4-687-310-11(1)
D:\JOB\SONY master page=left
DVD\2016\SD160015\4687310111_GB\030STU.fm
Wired Setup
z
The use of a shielded and straight interface cable (LAN cable) is recommended.
Wireless Setup
LAN cable
(not supplied)
z
No cable assembly required between the player and the wireless LAN router.
12
UBP-X800
4-687-310-11(1)
D:\JOB\SONY master page=right
DVD\2016\SD160015\4687310111_GB\030STU.fm
Getting Started
to mains
13
UBP-X800
4-687-310-11(1)
D:\JOB\SONY master page=left
DVD\2016\SD160015\4687310111_GB\040PLY.fm
Enjoying Blu-ray 3D
Playback
1 Prepare for Blu-ray 3D disc playback.
Playing a Disc • Connect the player to your 3D-
compatible devices using a High Speed
For “Playable discs”, see page 29. HDMI Cable.
• Set [3D Output Setting] and [TV Screen
1 Press Z (open/close), and place a disc on Size Setting for 3D] in [Screen Settings]
the disc tray. (page 19).
2 Insert a Blu-ray 3D disc.
The operation method differs depending
on the disc. Refer to the instruction
manual supplied with the disc.
z
Refer also to the instruction manuals supplied
Playing side facing down
with your TV and the connected device.
2 Press Z (open/close) to close the disc tray.
Playback starts.
If playback does not start automatically,
select [Video], [Music], or [Photo] category Playing from a USB Device
in (Disc), and press ENTER.
For “Playable types of files”, see page 31.
z
1 Lift the USB jack cover.
(Mixed disc) contains data contents. Press
OPTIONS on the remote and select [Data
Contents] to display any available contents.
b
When playing a 4K Ultra HD Blu-ray disc with no
disc key, it requires network connection
depending on the network environment and
official key server (Studio).
14
UBP-X800
4-687-310-11(1)
D:\JOB\SONY master page=right
DVD\2016\SD160015\4687310111_GB\040PLY.fm
Playback
Before you use the “Video & TV SideView”
2 Prepare the other necessary Home
Network- compatible products. Refer to device with this player for the first time, be
the instruction manual supplied with the sure to register the “Video & TV SideView”
product. device. Follow the on-screen instructions on
the “Video & TV SideView” device for
registration.
To play a file from a Home Network server via
this unit (Home Network player) b
The registration can only be performed on the
home screen.
Server
Renderer
Controller
15
UBP-X800
4-687-310-11(1)
D:\JOB\SONY master page=left
DVD\2016\SD160015\4687310111_GB\040PLY.fm
Example:
Using Screen mirroring
16
UBP-X800
4-687-310-11(1)
D:\JOB\SONY master page=right
DVD\2016\SD160015\4687310111_GB\040PLY.fm
Playback
• Do not use high volume from the start or for a audio output from Bluetooth device only or
long period. Your ears and the audio device from both Bluetooth device and HDMI
may be damaged. output during Bluetooth connection.
x [Bluetooth Device]*2: Displays Bluetooth
Disconnecting the Bluetooth device device list.
x [Bluetooth Volume]*2: Displays the
Perform any of the following steps: Bluetooth volume control view. This option
– Press BLUETOOTH button on the remote item is only available when the Bluetooth
(page 8). device is connected.
– Disable the Bluetooth function on the
Bluetooth device. Video only
– Turn off the player or the Bluetooth device. x [3D Output Setting]: Sets whether or not
to output 3D video automatically.
b x [A/V SYNC]: Adjusts the gap between
Before you turn off your Bluetooth device, turn
picture and sound, by delaying the sound
down the volume level of your TV to avoid
sudden high volume outbursts. output in relation to the picture output
(0 to 120 milliseconds).
x [HDR Conversion]*3: Converts High
Listening to Audio through a Dynamic Range (HDR) signal to Standard
Dynamic Range (SDR) signal when the
Bluetooth device and HDMI output player is connected to a TV or a Projector
that does not support HDR input. A picture
You can enjoy audio playback from this is more similar to HDR when larger value is
player via a Bluetooth device and HDMI selected, but lowers overall brightness.
output simultaneously. x [Video Settings]:
To set this function, perform any of the – [Picture Quality Mode]: Selects the
following steps: picture settings for different lighting
– Set [Bluetooth Output] in [Bluetooth environments.
Settings] to [Bluetooth + HDMI]. z [Direct]
– Press OPTIONS on the remote during any z [Brighter Room]
*4
playback and select [Bluetooth Output], z [Theatre Room]
*4
then select [Bluetooth + HDMI]. z [Auto]
b z [Custom1]/[Custom2]
– Same audio content is output via Bluetooth x [FNR]: Reduces the random noise
17
UBP-X800
4-687-310-11(1)
D:\JOB\SONY master page=left
DVD\2016\SD160015\4687310111_GB\040PLY.fm
18
UBP-X800
4-687-310-11(1)
D:\JOB\SONY master page=right
DVD\2016\SD160015\4687310111_GB\060ADD.fm
x [Display Type]
[TV]: Select this when the player is connected
Settings and Adjustments to TV.
[Projector]: Select this when the player is
connected to Projector.
Using the Settings Displays
z
Select [Setup] on the home screen when [HDR Conversion] will be adjusted according to
the display type you select. Even though same
you need to change the settings of the
setting value of [HDR Conversion] is selected,
player. dynamic range of picture is different.
The default settings are underlined.
x [Output Video Resolution]
1 Select [Setup] on the home screen
Normally select [Auto]. Select [Original
using </M/m/,.
Resolution] to output the resolution recorded
2 Select the setup category icon using M/m, on the disc. When the resolution is lower than
and press ENTER. the SD resolution, it is scaled up to the SD
x [24p Output]
[Software Update] Outputs 24p video signals only when you
connect a 24p-compatible TV via an HDMI
connection and the [Output Video
x [Update via Internet] Resolution] is set to [Auto], [1080p] or [4K].
Updates the player’s software using available
network. Make sure that the network is [Ultra HD Blu-ray/BD-ROM]
connected to the Internet. See “Step 2: [Auto]: Outputs 24 Hz video signals only
Network Connection” (page 12). when connecting a 24p-compatible TV using
the HDMI OUT jack.
x [Update via USB Memory]
[On]: Turns on the function.
Updates the player’s software using USB [Off]: Select this when your TV is not
memory. Create a folder named “UPDATE” compatible with 24p video signals.
and all the update files must be stored in this
folder. The player can recognise up to 500 [DVD-ROM]
files/folders in a single layer including the [Auto]: Outputs 24 Hz video signals only
update files/folders. when connecting a 24p-compatible TV using
z the HDMI OUT jack.
• We recommend performing the software [Off]: Select this when your TV is not
update every 2 months or so. compatible with 24p video signals.
• If your network condition is poor, visit
www.sony.eu/support to download the latest [Data content]
software version and update via USB memory. This function is available for playback
You can also get information about update contents stored in USB memory or data disc.
functions from the website. [Auto]: Outputs 24 Hz video signals only
when connecting a 24p-compatible TV using
the HDMI OUT jack.
[Off]: Select this when your TV is not
[Screen Settings] compatible with 24p video signals.
[Network content]
x [HDR Output] This function is available for playback
[Auto]: Outputs HDR signal depending on contents from other network, such as Home
contents and HDMI-SINK capability. Network, Screen mirroring, etc.
Conversion function is applied when content [Auto]: Outputs 24 Hz video signals only
is HDR and HDMI-SINK does not support HDR. when connecting a 24p-compatible TV using
[Off]: Always output SDR. the HDMI OUT jack.
[Off]: Select this when your TV is not
compatible with 24p video signals.
19
UBP-X800
4-687-310-11(1)
D:\JOB\SONY master page=left
DVD\2016\SD160015\4687310111_GB\060ADD.fm
x [TV Type]
[16:9]: Select this when connecting to a wide-
screen TV or a TV with a wide mode function.
[4:3]: Select this when connecting to a 4:3
screen TV without a wide mode function.
20
UBP-X800
4-687-310-11(1)
D:\JOB\SONY master page=right
DVD\2016\SD160015\4687310111_GB\060ADD.fm
21
UBP-X800
4-687-310-11(1)
D:\JOB\SONY master page=left
DVD\2016\SD160015\4687310111_GB\060ADD.fm
22
UBP-X800
4-687-310-11(1)
D:\JOB\SONY master page=right
DVD\2016\SD160015\4687310111_GB\060ADD.fm
23
UBP-X800
4-687-310-11(1)
D:\JOB\SONY master page=left
DVD\2016\SD160015\4687310111_GB\060ADD.fm
24
UBP-X800
4-687-310-11(1)
D:\JOB\SONY master page=right
DVD\2016\SD160015\4687310111_GB\060ADD.fm
[Resetting]
x [Reset to Factory Default Settings]
Resets the player settings to the factory
default by selecting the group of settings. All
the settings within the group will be reset.
b
If you dispose, transfer or resell this unit, please
delete all Personal Information for security
25
UBP-X800
4-687-310-11(1)
D:\JOB\SONY master page=left
DVD\2016\SD160015\4687310111_GB\070ADD.fm
Sound
Additional Information
No sound or the sound is not output
correctly.
Troubleshooting • Check that all the cables are securely
connected (page 11).
If a problem occurs while operating the • Switch the input selector on your AV
player, use this troubleshooting guide to help amplifier (receiver) so that the audio signals
remedy the problem before requesting of the player are output from your AV
repairs. If the problem persists, consult your amplifier (receiver).
nearest Sony dealer. • If the audio signal does not come through
the DIGITAL OUT (COAXIAL)/HDMI OUT jack,
check the audio settings (page 20).
Picture • For HDMI connections, try the following:
1Turn the player off and on again. 2Turn
No picture or the picture is not output the connected equipment off and on again.
correctly. 3Disconnect and then reconnect the HDMI
cable.
• Check that all the cables are securely
• For HDMI connections, if the player is
connected (page 10).
connected to a TV through an AV amplifier
• Switch the input selector on your TV to
(receiver), try connecting the HDMI cable
display the signal from the player.
directly to the TV. Refer also to the
• Reset the [Output Video Resolution] to the
instruction manual supplied with the AV
lowest resolution by pressing x (stop),
amplifier (receiver).
HOME, and then POP UP/MENU button on
• The HDMI OUT jack is connected to a DVI
the remote.
device (DVI jacks do not accept audio
• Try the following: 1Turn the player off and
signals).
on again. 2Turn the connected equipment
• The device connected to the HDMI OUT jack
off and on again. 3Disconnect and then
does not support the audio format of the
reconnect the HDMI cable.
player. Check the audio settings (page 20).
• The HDMI OUT jack is connected to a DVI
• Check the [HDMI Audio Output] settings in
device that does not support copyright
[System Settings] (page 23).
protection technology.
• Check the [Output Video Resolution] The HD Audio (Dolby Digital Plus, Dolby
settings in [Screen Settings] (page 19). TrueHD, DTS-HD High Resolution Audio,
• For Ultra HD Blu-ray/BD-ROM/DVD-ROM/
DTS-HD Master Audio, Dolby Atmos and
Data content/Network content, check the
[24p Output] settings in [Screen Settings] DTS:X) is not output by bitstream.
(page 19). • Set [BD Audio MIX Setting] in [Audio
• For 4K output, please make sure that the Settings] to [Off] (page 21).
player is connected to 4K display that • Check that the AV amplifier (receiver) is
supports HDCP2.2 capable HDMI input compatible with each HD Audio format.
using Premium High Speed HDMI Cable or
The interactive audio is not output.
High Speed HDMI Cable that supports 18
Gbps bandwidth (page 10). • Set [BD Audio MIX Setting] in [Audio
Settings] to [On] (page 21).
The display language on the screen
switches automatically when connected to
the HDMI OUT jack.
• When [Control for HDMI] in [HDMI Settings]
is set to [On] (page 23), the display
language on the screen automatically
switches according to the language setting
of the connected TV (if you change the
setting on your TV, etc.).
26
UBP-X800
4-687-310-11(1)
D:\JOB\SONY master page=right
DVD\2016\SD160015\4687310111_GB\070ADD.fm
Additional Information
• The disc is dirty or skewed. [Wi-Fi Protected Setup™ (WPS)] is
• The disc is upside down. Insert the disc with performed.
the playback side facing down.
• The wireless settings of the router may
• The disc has a format that cannot be played
change automatically if you use the Wi-Fi
back by this player (page 29).
Protected Setup function before adjusting
• The player cannot play a recorded disc that
the settings of the router. In this case,
is not correctly finalised.
change the wireless settings of your PC
• The region code on the BD/DVD does not
accordingly.
match the player.
You cannot connect the player to the
wireless LAN router.
USB device • Check if the wireless LAN router is on.
• Move the player and the wireless LAN router
The player does not detect a USB device closer to each other.
connected to the player. • Move the player away from devices that use
• Make sure that the USB device is securely a 2.4 GHz frequency band such as a
connected to the USB jack. microwave, Bluetooth or digital cordless
• Check if the USB device or a cable is device, or turn off such devices.
damaged.
The desired wireless router do not appear
• Check if the USB device is on.
• If the USB device is connected via a USB in the wireless network list.
hub, connect the USB device directly to the • Press RETURN to return to the previous
player. screen, and try wireless setup again. If the
desired wireless router is still not detected,
select [New connection registration] to
Internet streaming perform [Manual registration].
27
UBP-X800
4-687-310-11(1)
D:\JOB\SONY master page=left
DVD\2016\SD160015\4687310111_GB\070ADD.fm
Bluetooth connection cannot be done/ The [Control for HDMI] function does not
completed. work (BRAVIA Sync).
• Set [Bluetooth Mode] to [On] (page 21). • Check that your TV is connected via the
• Make sure the Bluetooth device is turned on HDMI OUT 1 jack.
and the Bluetooth function is enabled. • Check that [Control for HDMI] in [HDMI
• Move the Bluetooth device closer to the Settings] is set to [On] (page 23).
player. • If you change the HDMI connection, turn the
• Connect the player and the Bluetooth player off and on again.
device again. You may need to cancel the • If power failure occurs, set [Control for
connection with the player using your HDMI] in [HDMI Settings] to [Off], then set
Bluetooth device first. [Control for HDMI] in [HDMI Settings] to [On]
• Delete pairing information once from the (page 23).
device list and connected device, before • Check the following and refer to the
retrying connection. instruction manual supplied with the
• Connection may not be possible if other component.
Bluetooth devices are present around the – the connected component is
player. In this case, turn off the other compatible with the [Control for HDMI]
Bluetooth devices. function.
• The connection registration information has – the connected component’s setting for
been erased. Perform the connection
the [Control for HDMI] function is
operation again.
correct.
There is no sound, the sound skips or • When you connect the player to a TV
fluctuates, or the connection is lost. through an AV amplifier (receiver),
• DVD AUDIO cannot be played via Bluetooth – if the AV amplifier (receiver) is not
device due to DRM. compatible with the [Control for HDMI]
• Move the Bluetooth device closer to the function, you may be unable to control
player. the TV from the player.
• Make sure the player is not receiving any – if you change the HDMI connection,
interference from a Wi-Fi network, other disconnect and reconnect the mains
Bluetooth device, other 2.4 GHz wireless lead, or a power failure occurs, try the
device, or microwave oven.
following: 1Switch the input selector
• Check that the Bluetooth connection is
of the AV amplifier (receiver) so that
properly made between the player and the
Bluetooth device. the picture from the player appears on
• Connect the player and the Bluetooth the TV screen. 2Set [Control for HDMI]
device again. in [HDMI Settings] to [Off], then set
• Keep the player away from metal objects or [Control for HDMI] in [HDMI Settings] to
surfaces. [On] (page 23). Refer to the instruction
manual supplied with the AV amplifier
(receiver).
28
UBP-X800
4-687-310-11(1)
D:\JOB\SONY master page=right
DVD\2016\SD160015\4687310111_GB\070ADD.fm
Others
Playable discs
Playback does not start from the beginning
of content. Blu-ray Ultra HD Blu-ray, BD-ROM,
• Press OPTIONS, and select [Play from start]. Disc*1 BD-R*2/BD-RE*2
Playback does not start from the resume DVD*3 DVD-ROM, DVD-R/
point where you last stopped playing. DVD-RW, DVD+R/DVD+RW,
• The resume point may be cleared from DVD AUDIO*4
memory depending on the disc when CD*3 CD-DA (Music CD),
– you open the disc tray. CD-ROM, CD-R/CD-RW,
– you disconnect the USB device. Super Audio CD
– you play other content.
*1
– you turn off the player. Since the Blu-ray Disc specifications are new
and evolving, some discs may not be playable
Message Code 1 [Playback stopped. The depending on the disc type and the version.
content being played is protected by The audio output differs depending on the
source, connected output jack, and selected
Additional Information
Cinavia and is not authorized for playback
on this device. For more information, see audio settings.
*2 BD-RE: Ver.2.1, BD-R: Ver.1.1, 1.2, 1.3 including
http://www.cinavia.com. Message Code
organic pigment type BD-R (LTH type). The
1.] appears on the screen when playing a
BD-Rs recorded on a PC cannot be played if
disc. postscripts are recordable.
• The audio track of the video that you are *3 A CD or DVD disc will not play if it has not been
playing contains a Cinavia code indicating it correctly finalised. For more information, refer
was intended for presentation using to the instruction manual supplied with the
professional equipment only and is not recording device.
authorised for playback by consumers *4 Some DVD AUDIO discs have hidden group
(page 36). and need password entry. Refer to the disc for
the password.
The disc tray does not open and you cannot
remove the disc even after you press Z Discs that cannot be played
(open/close). • BDs with cartridge
• While the player is turned on, press x • BDXLs
(stop), HOME, and then TOP MENU button • DVD-RAMs
on the remote to unlock the tray and disable • HD DVDs
the Child Lock (page 9). • PHOTO CDs
• Try the following: 1Turn the player off, and • Data part of CD-Extras
disconnect the AC power cord. 2Reconnect • Super VCDs
the AC power cord while pressing down • Audio material side on DualDiscs
Z (open/close) on the player. 3Keep
pressing down Z (open/close) on the Note on Discs
player until the tray opens. 4Remove the This product is designed to playback discs
disc. that conform to the Compact Disc (CD)
standard. DualDiscs and some of the music
The message [[EJECT] Key is currently discs encoded with copyright protection
unavailable.] appears on the screen after technologies do not conform to the Compact
Z (open/close) is pressed. Disc (CD) standard, therefore, these discs
• Contact your nearest Sony dealer or local may not be playable by this product.
authorised Sony service facility.
29
UBP-X800
4-687-310-11(1)
D:\JOB\SONY master page=left
DVD\2016\SD160015\4687310111_GB\070ADD.fm
30
UBP-X800
4-687-310-11(1)
D:\JOB\SONY master page=right
DVD\2016\SD160015\4687310111_GB\070ADD.fm
Additional Information
TS*1 .m2ts, .mts Dolby Digital, DTS, LPCM, MPEG, AAC
MPEG4/AVC/ *6
H.264*5 Quick Time .mov Dolby Digital, LPCM, AAC, MP3
FLV*6 .flv, .f4v LPCM, AAC, MP3
.3gp, .3g2,
3gpp/3gpp2*6 AAC
.3gpp, .3gp2
TS .m2ts, .mts Dolby Digital, DTS, LPCM, MPEG, AAC
VC1*1
MKV .mkv Dolby Digital, LPCM, AAC, MP3, Vorbis
ASF .wmv, .asf WMA9, WMA 10 Pro
WMV9*1*7
MKV .mkv Dolby Digital, LPCM, AAC, MP3, Vorbis
Quick Time .mov Dolby Digital, LPCM, AAC, MP3
Motion JPEG*6
AVI .avi Dolby Digital, LPCM, AAC, MP3
MKV .mkv Dolby Digital, LPCM, AAC, MP3, Vorbis
HEVC/H.265 MP4 .mp4, .m4v AAC
TS .m2ts, .mts Dolby Digital, DTS, LPCM, MPEG, AAC
VP6 FLV .flv MP3
Webm .webm Vorbis
VP8/VP9
MKV .mkv Dolby Digital, LPCM, AAC, MP3, Vorbis
Format
AVCHD (Ver.2.0)*1*8*9*10
31
UBP-X800
4-687-310-11(1)
D:\JOB\SONY master page=left
DVD\2016\SD160015\4687310111_GB\070ADD.fm
*11
Music The player can play “.mka” files.
This file cannot be played on a Home
Codec Extension
Network server.
MP3 (MPEG-1 Audio Layer *12 The player does not play coded file such as
.mp3
III)*11 Lossless.
*13 The player does not play DST encoded files.
AAC/HE-AAC*1*11 .m4a, .aac*6 *14 The player does not play animated PNG or
WMA9 Standard*1 .wma animated GIF files.
*15 For MPO files other than 3D, the key image or
WMA 10 Pro*12 .wma
the first image is displayed.
LPCM*11 .wav *16 The player does not support 16bit BMP files.
FLAC*1 .flac, .fla b
Dolby Digital*6*11 .ac3 • Some files may not play depending on the file
format, file encoding, recording condition, or
DSF*1 .dsf Home Network server condition.
DSDIFF*1*13 .dff • Some files edited on a PC may not play.
• Some files may not be able to perform fast
AIFF*1 .aiff, .aif forward or fast reverse function.
ALAC*1 .m4a • The player does not play coded files such as
DRM.
Vorbis .ogg • The player can recognise the following files or
Monkey’s Audio .ape folders in BDs, DVDs, CDs and USB devices:
– up to folders in the 9th layer, including the
root folder.
Photo
– up to 500 files/folders in a single layer.
Format Extension • The player can recognise the following files or
JPEG .jpeg, .jpg, folders stored in the Home Network server:
.jpe – up to folders in the 19th layer.
– up to 999 files/folders in a single layer.
PNG .png*14 • The player can support frame rate:
GIF .gif*14 – up to 60 fps for AVCHD (MPEG4/AVC) only.
– up to 30 fps for other video codecs.
MPO .mpo*6*15 • The player can support video bit rate up to
BMP .bmp*6*16 40 Mbps.
• Some USB devices may not work with this
WEBP .webp player.
• The player can recognise Mass Storage Class
*1 The player may not play this file format on a (MSC) devices (such as flash memory or an
Home Network server. HDD), Still Image Capture Device (SICD) class
*2 The player can only play standard definition devices and 101 keyboard.
video on a Home Network server. • To avoid data corruption or damage to the USB
*3 The player does not play DTS format files on memory or devices, turn off the player when
a Home Network server. connecting or removing the USB memory or
*4 The player can only play Dolby Digital format devices.
files on a Home Network server. • The player may not play high bit rate video and
*5 The player can support AVC up to Level 4.1. audio files on DATA CDs smoothly. It is
*6
The player does not play this file format on a recommended to play such files using DATA
Home Network server. DVDs or DATA BDs.
*7 The player can support WMV9 up to Advance
Profile.
*8 The player can support frame rate up to
60 fps.
*9 The player plays AVCHD format files that are
recorded on a digital video camera, etc. The
AVCHD format disc will not play if it has not
been correctly finalised.
*10 The player can play AVCHD 3D format.
32
UBP-X800
4-687-310-11(1)
D:\JOB\SONY master page=right
DVD\2016\SD160015\4687310111_GB\070ADD.fm
Specifications
Specifications and design are subject to change without notice.
System
Laser Semiconductor laser
Additional Information
USB jack Type A (For connecting a USB memory, memory
card reader, digital still camera, and digital video camera)*
USB
* Do not use for power charging purposes.
Wireless
Wireless LAN standard Protocol IEEE802.11a/b/g/n
Frequency range 2.4 GHz, 5 GHz band
Modulation DSSS and OFDM
Bluetooth Version Bluetooth Specification v4.1
Bluetooth
Communication system Bluetooth Specification v4.1
Output Bluetooth Specification Power Class 1
Maximum communication
Line of sight approx. 30 m
range
Frequency band 2.4 GHz
Modulation method FHSS
Compatible Bluetooth Profiles A2DP v1.2, AVRCP v1.3
Supported Codecs SBC, AAC, LDAC
• 20 Hz - 40,000 Hz (LDAC in sampling 96 kHz and transmit
Transmission range (A2DP) by 990 kbps)
• 20 Hz - 20,000 Hz (in sampling 44.1 kHz)
33
UBP-X800
4-687-310-11(1)
D:\JOB\SONY master page=left
DVD\2016\SD160015\4687310111_GB\070ADD.fm
General
Power requirements Rating: Input 220 V - 240 V AC, 50/60 Hz
Power consumption 15 W
Network standby Less than 2 W (all wired/wireless network ports ON)
430 mm × 265 mm × 50 mm
Dimensions (approx.)
(width × depth × height) incl. projecting parts
Mass (approx.) 3.8 kg
Operating temperature 5 ºC to 35 ºC
Operating humidity 25 % to 80 %
34
UBP-X800
4-687-310-11(1)
D:\JOB\SONY master page=right
DVD\2016\SD160015\4687310111_GB\070ADD.fm
Additional Information
from Microsoft or an authorized Microsoft
DTS and the Symbol together are registered
subsidiary.
trademarks, and DTS-HD Master Audio is a
Content owners use Microsoft PlayReady™
trademark of DTS, Inc. © DTS, Inc. All Rights
content access technology to protect their
Reserved.
intellectual property, including copyrighted
content. This device uses PlayReady
technology to access PlayReady-protected
content and/or WMDRM-protected content. If
the device fails to properly enforce restrictions
• The terms HDMI®, HDMI High-Definition on content usage, content owners may require
Multimedia Interface, Premium High Speed Microsoft to revoke the device’s ability to
HDMI Cable, and the HDMI Logo are consume PlayReady-protected content.
trademarks or registered trademarks of HDMI Revocation should not affect unprotected
Licensing, LLC in the United States and other content or content protected by other content
countries. access technologies. Content owners may
• Blu-ray Disc™, Blu-ray™, BD-LIVE™, require you to upgrade PlayReady to access
BONUSVIEW™ and Ultra HD Blu-ray™ word their content. If you decline an upgrade, you
marks and the logos are trademarks of the will not be able to access content that requires
Blu-ray Disc Association. the upgrade.
• Blu-ray 3D™ and Blu-ray 3D™ logo are • Gracenote, the Gracenote logo and logotype,
trademarks of the Blu-ray Disc Association. the “Powered by Gracenote” logo, and
Gracenote MusicID are either registered
trademarks or trademarks of Gracenote, Inc. in
the United States and/or other countries.
35
UBP-X800
4-687-310-11(1)
D:\JOB\SONY master page=left
DVD\2016\SD160015\4687310111_GB\070ADD.fm
36
UBP-X800
4-687-310-11(1)
D:\JOB\SONY master page=right
DVD\2016\SD160015\4687310111_GB\070ADD.fm
under this Agreement against you directly in its Software License Information
own name. For EULA (End User License Agreement), please
refer to [License agreement] in the option menu
The Gracenote service uses a unique identifier to on each network service icon.
track queries for statistical purposes. The
purpose of a randomly assigned numeric For details of the other software licenses, please
identifier is to allow the Gracenote service to select [Setup] and refer to [Software License
count queries without knowing anything about Information] in [System Settings].
who you are. For more information, see the web
page for the Gracenote Privacy Policy for the This product contains software that is subject to
Gracenote service. the GNU General Public License (“GPL”) or GNU
Lesser General Public License (“LGPL”). These
The Gracenote Software and each item of licenses establish that customers have the right
Gracenote Data are licensed to you “AS IS.” to acquire, modify, and redistribute the source
Gracenote makes no representations or code of said software in accordance with the
warranties, express or implied, regarding the terms of the GPL or the LGPL.
accuracy of any Gracenote Data from in the The source code for the software used in this
Gracenote Servers. Gracenote reserves the right product is subject to the GPL and LGPL, and is
Additional Information
to delete data from the Gracenote Servers or to available on the Web. To download, please visit
change data categories for any cause that the following website:
Gracenote deems sufficient. No warranty is http://oss.sony.net/Products/Linux
made that the Gracenote Software or Gracenote Please note that Sony cannot respond to any
Servers are error-free or that functioning of inquiries regarding the content of this source
Gracenote Software or Gracenote Servers will be code.
uninterrupted. Gracenote is not obligated to
provide you with new enhanced or additional Disclaimer regarding services offered by third
data types or categories that Gracenote may parties
provide in the future and is free to discontinue Services offered by third parties may be
its services at any time. changed, suspended, or terminated without
prior notice. Sony does not bear any
GRACENOTE DISCLAIMS ALL WARRANTIES responsibility in these sorts of situations.
EXPRESS OR IMPLIED, INCLUDING, BUT NOT
LIMITED TO, IMPLIED WARRANTIES OF
MERCHANTABILITY, FITNESS FOR A PARTICULAR
PURPOSE, TITLE, AND NON-INFRINGEMENT.
GRACENOTE DOES NOT WARRANT THE RESULTS
THAT WILL BE OBTAINED BY YOUR USE OF THE
GRACENOTE SOFTWARE OR ANY GRACENOTE
SERVER. IN NO CASE WILL GRACENOTE BE LIABLE
FOR ANY CONSEQUENTIAL OR INCIDENTAL
DAMAGES OR FOR ANY LOST PROFITS OR LOST
REVENUES.
37
UBP-X800
4-687-310-11(1)
D:\JOB\SONY master page=left
DVD\2016\SD160015\4687310111_GB\070ADD.fm
Since communication via the wireless LAN • To keep the disc clean,
function is established by radio waves, the handle the disc by its
wireless signal may be susceptible to edge. Do not touch the
interception. To protect wireless surface. Dust, fingerprints,
communication, this player supports various or scratches on the disc
security functions. Be sure to correctly may cause it to
configure the security settings in accordance malfunction.
with your network environment. • Do not expose the disc to direct sunlight or
No Security heat sources such as hot air ducts, or leave
it in a car parked in direct sunlight as the
Although you can easily make settings,
temperature may rise considerably inside
anyone can intercept wireless
the car.
communication or intrude into your wireless
• After playing, store the disc in its case.
network, even without any sophisticated
• Clean the disc with a
tools. Keep in mind that there is a risk of
cleaning cloth. Wipe the disc
unauthorised access or interception of data.
from the center out.
WEP • Do not use solvents such as
WEP applies security to communications to benzine, thinner,
prevent outsiders from intercepting commercially available disc/
communications or intruding into your lens cleaners, or anti-static
wireless network. WEP is a legacy security spray intended for vinyl LPs.
technology that enables older devices, which • If you have printed the disc’s label, dry the
do not support TKIP/AES, to be connected. label before playing.
WPA-PSK (TKIP), WPA2-PSK (TKIP) • Do not use the following discs.
TKIP is a security technology developed to – A lens cleaning disc.
correct the deficiencies of WEP. TKIP assures – A disc that has a non-standard shape
a higher security level than WEP. (e.g., card, heart).
– A disc with a label or sticker on it.
WPA-PSK (AES), WPA2-PSK (AES) – A disc that has cellophane tape or sticker
AES is a security technology that uses an adhesive on it.
advanced security method that is distinct • Do not resurface the playing side of a disc to
from WEP and TKIP. remove surface scratches.
AES assures a higher security level than WEP
or TKIP.
38
UBP-X800
4-687-310-11(1)
D:\JOB\SONY master page=right
DVD\2016\SD160015\4687310111_GB\070ADD.fm
Code Language
Language code list 1417 Punjabi; 1428 Polish
Panjabi
For details, see [BD/DVD Viewing Settings] 1435 Pashto; Pushto 1436 Portuguese
(page 22). 1463 Quechua 1481 Rhaeto-
The language spellings conform to the ISO Romance
639: 1988 (E/F) standard. 1482 Kirundi; Rundi 1483 Romanian
1489 Russian 1491 Kinyarwanda
Code Language 1495 Sanskrit 1498 Sindhi
1027 Afar 1028 Abkhazian 1501 Sangho; Sango 1502 Serbo-Croatian
1032 Afrikaans 1039 Amharic 1503 Singhalese; 1505 Slovak
1044 Arabic 1045 Assamese Sinhalese
1051 Aymara 1052 Azerbaijani 1506 Slovenian 1507 Samoan
1053 Bashkir 1057 Byelorussian 1508 Shona 1509 Somali
1059 Bulgarian 1060 Bihari 1511 Albanian 1512 Serbian
1061 Bislama 1066 Bengali 1513 Siswati; Swati 1514 Sesotho; Sotho
southern
1067 Tibetan 1070 Breton
1515 Sundanese 1516 Swedish
1079 Catalan 1093 Corsican
1517 Swahili 1521 Tamil
Additional Information
1097 Czech 1103 Welsh
1525 Telugu 1527 Tajik
1105 Danish 1109 German
1528 Thai 1529 Tigrinya
1130 Bhutani; 1142 Greek
Dzongkha 1531 Turkmen 1532 Tagalog
1144 English 1145 Esperanto 1534 Setswana; 1535 Tonga; Tonga
Tswana islands
1149 Spanish 1150 Estonian
1538 Turkish 1539 Tsonga
1151 Basque 1157 Persian
1540 Tatar 1543 Twi
1165 Finnish 1166 Fiji
1557 Ukrainian 1564 Urdu
1171 Faroese 1174 French
1572 Uzbek 1581 Vietnamese
1181 Frisian 1183 Irish
1587 Volapük 1613 Wolof
1186 Scots Gaelic 1194 Galician
1632 Xhosa 1665 Yoruba
1196 Guarani 1203 Gujarati
1684 Chinese 1697 Zulu
1209 Hausa 1217 Hindi
1703 Not specified
1226 Croatian 1229 Hungarian
1233 Armenian 1235 Interlingua
1239 Interlingue 1245 Inupiak
1248 Indonesian 1253 Icelandic
1254 Italian 1257 Hebrew
1261 Japanese 1269 Yiddish
1283 Javanese 1287 Georgian
1297 Kazakh 1298 Greenlandic;
Kalaallisut
1299 Cambodian; 1300 Kannada
Khmer
1301 Korean 1305 Kashmiri
1307 Kurdish 1311 Kirghiz
1313 Latin 1326 Lingala
1327 Laothian; Lao 1332 Lithuanian
1334 Latvian 1345 Malagasy
1347 Maori 1349 Macedonian
1350 Malayalam 1352 Mongolian
1353 Moldavian 1356 Marathi
1357 Malay 1358 Malese;
Maltese
1363 Burmese 1365 Nauru
1369 Nepali 1376 Dutch
1379 Norwegian 1393 Occitan
1403 Oromo 1408 Oriya
39
UBP-X800
4-687-310-11(1)
D:\JOB\SONY master page=left
DVD\2016\SD160015\4687310111_GB\070ADD.fm
Code Area
2044 Argentina 2047 Australia
2046 Austria 2057 Belgium
2070 Brazil 2090 Chile
2092 China 2093 Colombia
2115 Denmark 2165 Finland
2174 France 2109 Germany
2200 Greece 2219 Hong Kong
2248 India 2238 Indonesia
2239 Ireland 2254 Italy
2276 Japan 2304 Korea
2333 Luxembourg 2363 Malaysia
2362 Mexico 2376 Netherlands
2390 New Zealand 2379 Norway
2427 Pakistan 2424 Philippines
2428 Poland 2436 Portugal
2489 Russia 2501 Singapore
2149 Spain 2499 Sweden
2086 Switzerland 2543 Taiwan
2528 Thailand 2184 United
Kingdom
2586 Vietnam
40
UBP-X800
4-687-310-11(1)
D:\JOB\SONY master page=left
DVD\2016\SD160015\4687310111_GB\070BC
O.fm
To find out useful hints, tips and information about Sony products and services
z please visit: www.sony.eu/myproducts/
4-687-310-11(1)
http://www.sony.net/
© 2017 Sony Corporation Printed in Malaysia I - 4 6 8 7 3 1 0 1 1 %
UBP-X800
4-687-310-11(1)