You are on page 1of 63

(7) 0il should be drained before transportation from the units.

5 LUBRICATION

5-1 Lubrication method


Gear and Bearinng : 0il bath

5-2 Recommended lubricants


Recommended lubricants are listed in Table1.

5-3 Oil quantity


Use an oil gauge to check the unit for the proper amount of oil.
0utline oil quantity is shown in Table 2.

6 MAINTENANCE

6-1 Oil check and change

(1) 0il quantity should be checked periodically by means of an oil sight gauge. For accurate
measurement, stop the unit. When the unit has not been used for a long period, check the unit after
no load operation for about 2 to 3 minutes as mentioned on above 4-(4).
(2) The first oil change should be made after 500hours of operation or 6months, whichever comes
first. The second oil replacement should be conducted after 2,500hours of operation or 6months,
whichever comes first.
(3) The oil should be replaced with new oil every 5,000hours or every 1year, whichever comes first,
if the oil temperatura falls below 70• ! lf the oil temperatura rises above 70• � the oil should be
changad every 2,500hours or every 6months, whichever comes first.
(4) Where operating conditions are severe, such as rapid rise and fall of temperatura, or the
presence of corrosiva gases in the atmosphere which will result in the rapid deterioration of the oil,
reference should be made to lubricant manufactures.

(5) 0il flushing helps cleaning. The use of a solvent should be avoided to clean the interna! parts of
the unit.

6-2 Oil filling and draining

(1) Drain the oil from a drain plug, by removing the oil drain plug.
(2) While taking all possible care to prevent the entry of rain water and other foreign matter through
the oil filler, the prescribed quantity of oil should be poured into the unit while observing the oil level
gauge. Quantity below the prescribed level will result in inadequate lubrication, while excessive
supply will cause excessive temperatura rise and accelerate oil deterioration.

6-3 Oil seal inspection and change


Worn oil seals may result in oil leaks. lnspect and replace oil seals at regular interval.

6-4 Extended storage of the unit

(1) lf the unit is not to be operated for over a month, replace the oil upon suspension of operation,
3
and run the unit with no load on it at least once a week.
(2) lf the unit is not operated for over three months or it is difficult to accomplish instructions in
above article (1), drain oil, fill the unit with the proper amount of corrosion preventiva oil (JIS NP20
or equivalent) in accordance with Table3, and seal it. When staring the unit again, replace the
anti-corrosion oil with the proper amount of recommended lubricating oils. NOTE, be sure to seal
the air vent plug to keep the unit tightly closed dusting storage.

7 MAINTENANCE OF PARTS

• • • • Overiurul the machine 3 • 6 year after initial operation, depending on the operating
condition. Replace the following parts to extend the service life.

7-1 Renewal parts


• • •Bearing, oil seal, collar, shim, packing, visible gauge, air breather
• • •Shafts and gears when damage is found.
• • "®ther parts (incl. special applications) as necessary.

7-2 Dismantling and Assembly


The PARAMAX ORIVE should be returned to our plant far dismantling and assembly, in
principie. Advise us of the machine No. of the speed reducer to overhaul, serial No., type,
number of speed reducers, and period.

8 ESSENTIALS OF LONG-TERM STORAGE

1. Using interior of general factory of warehouse, store the machine under comparatively
favorable conditions.

2. Store in an environment where moisture, dust, violent temperatura variations and corrosiva
gases like sulfurous acid gas are absent.

3. Make sure of the rusting situation inside the equipment and then spray and also supply Shell
VSI Circulating Oil 32 of the Shell Oil Company and seal it hermetically and repeat the
procedure identified above every half a year.

4. Do not use any mixture with other rust-proof oil.

5. Drain the rust-proof oil when operation is to be commenced; start operation after supplying the
recommended lubricant. Do not operate the equipment with dust-proof oil in.

6. While Daphne Ever Coat No.1 is coated on the shaft thrusting unit and the mounting face, make
sure of the rust situation by sight.

7. The oil quantity of Shell VSI Circulating Oil is in a Table3.

4
10 Table 1. Recommended lubricants

MEROPA SPARTAN MOBILGEAR OMALA


ISOVG220*
WM220 EP220 630 220
MEROPA SPARTAN MOBILGEAR OMALA
ISOVG320*
WM320 EP320 632 320
MEROPA SPARTAN MOBILGEAR OMALA
ISOVG460*
WM460 EP460 634 460

*ISO VG number is the value ofthe kinematic viscosity in mm2/s(cSt)at 40 ºC.

11 Table 2 0·11 Quanft1ty L"ISt9Iper one um"t)


TYPE Oil Quantity[L]

YHD080P3-LR/RL-55.066 65

12 Table 3. Corrosion Preventive Oil Quantity List(per one unit)


Oil Quantity
TYPE
Filling Spray
YHD080P3-LR/RL-55.066 APPROX. 2,000cc 200cc

13 Table 4. Oil Seal List(per one unit)


HIGH SPEED SHAFT D-80 X 100 X 12 X2

LOW SPEED SHAFT D-170 X 200 X 16 X2

14 Table 5. Bearinq List(per one unit)


#32311X1
HIGH SPEED SHAFT
#33213X1
INTERMEDIATE SHAFT #22314X2
INTERMEDIATE SHAFT #23222X2
LOW SPEED SHAFT #23034X2

6
800f)s:QgO)J.

_0�170M200x16

N0.32311

SCAI..E 1:8 MTE 2010.01.25


PARAMAX
1 %$ 1 1 !$El- M 7hnn z.song M.Oiokl YHD080P3-LR-55.066
�•'1_
1Y0803G008
General
Purpose
3-phase
Induction
Motors
8
8
talo ue
MOUNTING ARRANGEMENTS

B3/IM 1001 B6/IM 1051 B7/IM 1061

/ r··:
.Á>.. :
.. -·9'
__ ;


Foot mounted Foot wa/1 mounted with faet on left Fcot wa/1 rr:ounted with feet on left hand
side viewed from OE excl. 315-355 side viewed from DE excl. 315-355

B8/IM 1071 VS/IM 1011 V6/IM 1031

··�· 1 ·t,.....º""t• · ·.
.../ ,
.:;�
; �-,.::.,
-:,o

.
'.!... - ....-

Ceiling mounted with feet Vertical feet wa/1 mounted Vertical feet wa/1 mounted
above motor exc/. sh.aft down excl. shaft up excl. 315 - 355
315- 355 315 - 355

BS/IM 3001 V1/IM 3011 V15/IM 2011 V3/IM 3031 V36/IM 2031

Ít¾n .

� �
"D" type flange at DE, no
feet exc/. 315 - 355

B35/IM 2001
w)J ,, '.

"D" type "D" type "D" type "D" type


flange al DE, f/ange at DE, flange at DE, flange at DE,
no feet shaft shaft down, shaftup, no shaftup, feet
down V15 feet feet V3 exc/.
"D" type flange at DE,
exc/. 7 - phase 37 5 - 3�!>
wilh feel
motors
BEARINGS íl

Motors Roller Bearings


Type Pole Number DE NDE
63 2,4,6, 8 6202 2RS
71 2,4,6, 8 6203 2RS
80 2,4,6, 8 6204 2RS
90 S,L 2,4,6, 8 6205 2RS
100 L 2,4,6, 8 6206 2RS
112 M 2,4,6, 8 6306 2RS
132 S,M 2, 4,6. 8 6308 2RS
160 ML 2,4,6, 8 6309 2ZC3
180 ML 2,4,6, 8 6311 2ZC3/C

STRV
STD ORQ STD ORQ

DE/NDE DE NDE DE/NDE DE NDE


200 2 6212 C3 - - 6312 C3 - -
200 4,6, 8 6212 C3 NU212 6212 C3 6312 C3 NU 312 6312 C3
225 2 6213 C3 - - 6313 C3 - -

225 4,6, 8 6212 C3 NU213 6213 C3 6313 C3 NU 313 6313 C3


250 2 6215 C3 - -
6315 C3 - -
250 4,6,8 6215 C3 NU215 6215 C3 6315 C3 NU 315 6315 C3
280 2 6217 C3 - - 6317 C3 - -
280 4,6, 8 6217 C3 NU217 6217 C3 6317 C3 NU 317 6317 C3
315 2 - - - 6315 C3 - -
315 4,6, 8 - - - 6318 C3 NU 318 6318 C3
355 S,M 2 6317 C3 - - - - -
355 S,M 4 - NU322C3 6322 C3 - - -

355 S,M 6, 8 - NU322Có 6322 Có - - -


STD ........................ standard
STRV , ....................... strenghtened verslon
ORQ ........ ........ ........ on request

©
PERMISSIBLE FREE SHAFT END LOAD (ON ORIVE SIDE) íl
Nrn-nnl VArs.lnn Strenathteneci version
Rodialload 1
/\xial lood
1
Radial load 1
Ax ialload Rotor
Type stcndord 1
for request I rorl,onlal vertical stonoard 11
for reauest lhoizo-itoll vertical mass
X=O I X=E 1 X=D I >:=E 1 1 down up 1 X=Ü 1 X=E X=Ü X=E 1 1
down I up 1
N N N N N N N N N N N N N ko
160M2A 2000 160!) 1500 1300 1700 23
160M2B 1900 1500 1500 120-:) liOO 26
160L2 1900 1500 1400 120) 1800 30
160M4 '.2600 2000 2100 180) 2400 28
160L4 :;;500 2000 2000 170) 2400 34
160M6 3000 2300 2400 210:> 2i00 29
160L6 �900 2300 2300 200) 2800 38
160M8A 3500 2700 2600 2-10:> 2900 25
160M8B �,400 2600 2600 240;) 3000 29
160ML8 3300 2600 2600 230:) 3000 3ó
180M2 2800 2200 2000 1700 2<00 3ó
180M4 3.500 2900 2900 2500 3<00 44
180L4 3400 2700 2900 2400 3L00 49
180L6 4000 3200 3300 2800 3900 54
180LB 4500 3600 3600 3200 4200 54
200L2A 2000 160( .1500 1100 2100 3200 2600 2300 1900 2900 53
200L2B 1800 150( .1500 1000 2100 3100 2500 2300 1300 2900 59
200L4 2L00 1900 7300 6-JOO 2100 1500 2900 3900 3200 10700 880C 3200 2600 4000 72
200L6A 2800 2300 &300 6)00 2400 1800 3300 4600 3300 12200 10100 3700 3000 4600 78
200L6B 2700 2200 5200 6900 2400 1600 3400 4500 3700 12100 10000 3700 2900 4600 8ó
200LB 3100 2600 9100 7500 2700 2000 3600 5100 4200 13300 11000 4100 3400 5000 8·1
225S4 2900 230ü 0300 6'.JOO '2.'.>0IJ lliOO 34,Jü L�QO 3600 13100 10400 3700 3000 4600 /Y
225$8 3900 3100 10400 8200 3200 2500 4200 5900 4700 16400 13000 4700 3900 5700 88
225M2 2200 1800 - 1700 1100 2500 3500 2','00 2600 2000 3400 69
225M4 2700 2100 &100 6400 2400 1600 35,)0 L300 3400 13000 10400 3600 2800 4700 95
225M6 3100 2500 9200 7300 2800 1900 40:)0 5000 4'}00 14700 11800 4100 3200 5400 1C9
225MB :rn10 '7900 70200 820() 3·00 2300 43)0 570() 4�00 ln'.iOO 1'.iOOO 4600 '.i700 .SROO lf.2
250M2 2600 2100 2000 1300 30:)0 L300 3�00 3200 2400 4200 8?
250M4 3200 2600 10100 8300 2800 1800 42 JO 5400 4400 17600 14400 4400 3400 5800 120
250M6 3600 2900 11400 9300 3200 2000 49:)0 ólOO S:.>OO 19800 16200 �ººº 3800 6700 146
250MB 4100 3400 12500 10300 3600 2300 53JO 6900 5$00 21700 17800 5600 4300 7200 146
280S2 3200 2700 2600 1 "ºº 4000 4000 3300 2100 1900 4600 120
280S4 3900 3300 12900 10700 3500 2100 5400 6100 5100 21100 17500 5100 3700 7000 lé5
280S6 5000 4200 15100 12500 4200 2900 590C 7500 6200 24400 20200 6000 4700 7700 151
280S8 5500 4600 1$400 13600 460D 3300 650C 8300 6900 26500 22000 6600 5200 8500 1 él
280M2 3100 2500 2500 1300 4l0C 3900 3200 �ººº 1300 4600 140
280M4 3/UU JIOU IUOO 10!-JOO 3500 1900 550C 5900 4'100 :,>ü91JO l/30IJ tOUO 3�00 /"00 162
280M6 4800 4000 14800 12300 4100 2700 610C 7300 6000 24100 20000 5900 4500 7900 1 il
280M8 5200
- 4300 16100 73300 -- 4500 2900 670C 8000 6600 26200 21700 6500 4?00 8600 186
315S2 3700 32CO .:;ooo 1600 4800 158

!· •
315S4 6400 53CO 22700 18800 "1900 3100 7300 211
X
315S6 7400 62CO 2580() 21400 6:iOO 4100 8900 231
315S8 8400 70CO 28300 23500 iOOO 5:)00 9600 231
315M2A 3600 30CO 2900 1500 4800 168
315M2B ___...
FA
3300 28CO 2900 1300 4900 104
315MAA 6200 5ÍCO 22600 18700 4800 2900 7400 224
315M4B 5900 49CO 22300 18500 4800 2700 7500 242
315M6A 7200 60(0 25600 2120) 6200 4100 9000 246
,.
315M6B
315M8A
- E 6800
8200
5600
6800
25100 2080:) 6100
27800 2310) 6900
3600
4800
9300
9700
282
246
315M8B 7700 6400 27700 2290:) 6800 43CO 10000 282
NOlEII
l. Pe·m·ssible load os o lunctio, of x is linear in th range from (=0 ·o ,,,,,E • LH of 20 000 hours for normal version
2. For direct "°"pling applicotion! the beorings hove been chosen to - LH ol 30 000 1-ours strengthtenec version (25g/25LJ/2skg/35g/3S.gí35K�)
prnviNA nn n·,P.rnQA �P.rvir:� l�P.: 3. Bearings ·ypes ore nomed in other list.

You might also like