HamworthyKSE
Hamworthy
STO-ST1A
Super Trident
Sewage Treatment Units
PCH 1543
Issue 3 0403
HAMWORTHY KSE LIMITED
Fleets Corner, Poole, Dorset, BH17 0JT, England
Telephone: +44 (0)1202 662600
Facsimile: Spares +44 (0)1202 665444 Sales +44 (0)1202 668793 Service +44 (0)1202 662622
Offices, Associate Companies and Agents throughout the world‘Amendment Record
[ ain changes in comparison with previous asus
Location: ‘Chang
‘Sealion 1-Teshrical Oata “Aad temperature and huidly data
Section 5:8- Recommended Spares | Add Measuring Cynder
ase Roplace 07937 Issue 1 by ssueZ
ocean See Replace 07933 Issue 2by Issue 3
; ‘Delete temperature ang numicty data
jisseien SConaeeses ‘Add Filter Gartsage (net to Uist of Parts10.
1
12,
13.
14.
WARNING
Health and Safety Act Compliance. Before working on this equipment personne! should be made
aware of, and ensure compliance with, the Health and Safety Regulations appropriate to this class of
work
Work must only be carried out by suitably qualified and competent persons.
Before lifting, installing and operating the unit, the instructions detailed below, and also the
accompanying manual must be read.
Ensure that all equipment used for lifting the unit is adequate for the weight. The weight is normally
stencilled on the unit and/or stamped on the machine nameplate.
The handling points are indicated on the unit and these must be used. The hooks of slings must not
be fitted directly to lifting eyebolts or lugs, shackles must be used.
Before running the unit for the first time, the installation must be thoroughly checked and the
procedure detailed in Section 4 of this manual under the heading “Preparation for Initial Operation"
referred to.
The unit must not be run unless all protective guards supplied with the equipment are in position,
Before proceeding with maintenance on the unit, or making adjustments to its connections and fittings,
it must be stopped and isolated electrically and mechanically and visible warning notices displayed.
Ensure safety procedures for hazardous gases or oxygen depletion are carried out before opening the
tanks.
Before commencing repair or overhaul a preliminary check of available spares must be made, e.g.
replacement set of joints or jointing material
Pumps handle various liquids, sometimes not those for which the pump was initially supplied. Know
the properties of the liquids that have been pumped, and the actions necessary to make handling safe
and in the event of an emergency.
Before handling sodium hypochlorite refer to instructions in Section 4.
‘The equipment should not be installed in an explosive atmosphere.
This equipment is subject to international, European, and national regulations and must be used
accordingly.
Page 3