Professional Documents
Culture Documents
(Computer Science)
4. Research Method
This research was conducted by doing
several processs:
1) Coding Arduino program using arduino IDE
application. Figure 1
2) Designing Arduino microcontroller system, PIR No Block Explanation
sensor, and camera. As a detector to detect
3) Programming the syncronization of email to be 1 PIR sensor people who ride a
used with Arduino microcontroller. motorcycle
The function is to take a
The method used in designing the security 2 Camera
photo
system of motorycles with IoT based and using As the data source which
arduino is a design consists of several stages : (1) can read the input
The need identifications (2). The needs analysis (3). 3 Arduino YUN provided by the PIR
The Hardware Design (4). The Making (5). The sensors, cameras, and
Testing. The design of IoT based motorcycle theft users to be sent/recived by
modul wifi in arduino. 7 7:44:00 7:44:28
8 7:45:00 7:45:35
9 7:46:00 7:46:33
To turn off the motor
4 Relay 10 7:48:00 7:48:33
electrical system.
Telecomunication 11 7:50:00 7:50:26
5 12 7:51:00 7:51:32
Provider
Serves as a storage media Table 3.( Testing of data transmiting)
6 Cloud of photos taken by camera.
6. CONCLUSION
Serves as a motorcycle The system uses PIR sensor to detect the
7 Smartphone unwanted person steal the motorcycle, in order to
control
take a photo of people who ride a motorcycle, it use
Table 1. (Explanation of block diagram system) camera which is controlled by microcontroller using
(Arduino YUN).
5. Results and Analysis If the PIR censor detects the person, then the
In this section we do some testing on each input given to the microcontroller is a high (volt)
component used, and duration of data transmission. voltage that can cause the voltage to the camera and
make it take a photo, and the microcontroller will
5.1 Testing of PIR censor store the image on the memory card after that then
The purpose of the PIR censor testing is to find the microcontroller will send the image to the email,
out the maximum length which can be reach by PIR which has been determined by the microcontroller
censor. The results can be seen in table 2 (Arduino YUN). And if the PIR censor does not
detect the person then the voltage applied to the
No Distance (cm) Condition microcontroller is a low (volt) voltage. Then the
1 5 Yes microcontroller will not give the voltage (volts) on
2 10 Yes the camera.
3 15 Yes To make the camera motor can be stored, a
4 20 Yes memory card is needed to save the photos and the
microcontroller will control it to send the photos to
5 25 Yes
the e-mail.
6 30 Yes
7 35 Yes
References
8 40 Yes [1] Artanto, D. (2012). Interaksi Arduino dan
9 45 Yes LabView. Jakarta: Gramedia.
10 50 Yes [2] Livery, P. (2014). Internet of Thinks with the
11 55 Yes Arduino Yun. BRIMINGHAM: Packt Publishing.
12 60 Yes [3] www.instructables.com/id/Motion-Activated-
Table 2. (Testing Of PIR sensor) Servo/
Transmitter Receiver
No Provider
time time
1 7:35:00 7:35:32
2 7:37:00 7:37:55
3 7:38:00 7:38:34
Telkomsel
4 7:39:00 7:39:26
5 7:41:00 7:41:30
6 7:42:00 7:42:33