Professional Documents
Culture Documents
Create the assembly as shown in Figure T-1. The components and their drawing views are
shown in Figures T-2 through T-5. Create the components and then assemble them. To
assemble these components, you can refer to the exploded view shown in Figure T-6.
Also, create the exploded state of the assembly with the offset lines. After creating the
assembly, create the drawing view of the exploded state of the assembly shown in Figure
T-7. Finally, insert the BOM and the title block as shown in Figure T-7.
Figure T-1
Figure T-2
Figure T -3
Figure T-4
Figure T-5
Figure T-6
Figure T-7