Professional Documents
Culture Documents
1. Top view
2. Front view
3. Right-side view
4. Isometric view (Expected Time: 3 hrs)
Figure A Assembled view of the Fixture Figure B Exploded
assembly view of the Fixture
Assembly displaying
various components
Figure C Dimensions of the end_plate Figure D Dimensions of the disk
Figure E Dimensions of the spacer, center_pin, and the nut
Figure F Dimensions of the support_pin and the bolt
a. Set the working directory and create all the components of the assembly in the
Part mode.
b. Open a new assembly file and assemble the end_plate with the default datum
planes.
c. Assemble the end_plate and the disk as shown in Figure G in an assembly file.
1. Top view
2. Front view
3. Right-side view
4. Isometric view (Expected Time: 3 hrs)
Figure A Assembled view of the Bench-Vice assembly
Figure B Exploded view of the Bench-Vice assembly displaying
various components
Figure C Dimensions of the vice_body
Figure D Dimensions of the vice_jaw
Figure E Dimensions of the clamping_plate, setscrew1,
setscrew2, and the oval fillisters
Figure F Dimensions of the jaw_screw and the bar_globes
Figure G Dimensions of the base_plate and the screw_bar
a. Create all the components of the assembly in the Part mode.
b. Create a new assembly file and assemble the vice_body with the default datum
planes of the assembly using the assembly constraints.
c. Assemble the vice_jaw with the vice_body using the assembly constraints, as
shown in Figure H.
1. Top view
2. Front view
3. Right-side view
4. Isometric view (Expected Time: 4 hrs)
Figure A Assembled view of the blower assembly
Figure B Exploded view of the blower assembly
Figure C Dimensions of the upperhousing
Figure D Dimensions of the lowerhousing
Figure E Dimensions of the blower
Figure F Dimensions of the blower
Figure G Dimensions of the cover
Figure H Dimensions of the motorshaft
a. Create all the components of the assembly in the Part mode.
b. Create a new assembly file and assemble the lowerhousing with the default
datum planes of the assembly using the assembly constraints.
c. Assemble the upperhousing with the lowerhousing using the various assembly
constraints, as shown in Figure I.