Professional Documents
Culture Documents
Kit Contents:
1 PSoC® 4 M-Series Pioneer board
2 USB Standard-A to Mini-B cable
3 Four jumper wires (4 inches each)
4 Two proximity sensor wires (5 inches each)
5 Micrium® μC/Probe® license card
6 Quick Start Guide (this document)
CY8CKIT-044 QUICK START GUIDE
1 2
• Connect the board to your computer using the • Bring your finger closer to the CapSense® Gesture
provided USB cable Pad to wakeup the system using proximity sensing.
Note: This demo does not require driver installation, The on-board RGB LED will turn on with white color
although this may continue in the background
The RGB LED will turn off after 3 seconds if your
finger is taken away from the Gesture Pad
3
Supported gestures
4
• Download and install the PSoC Creator IDE, PSoC 4 M-Series Pioneer Kit
code examples, documents and hardware design files from
www.cypress.com/CY8CKIT-044
23 13 22 21 20
1 Power and Status LED
19 2 USB connector (J6)
1
16 3 System power supply jumper (J9) and
2 LDO (3.3V)
3 4 PSoC 5LP programmer and debugger
4 (CY8C5868LTI-LP039)
18
5 PSoC 5LP I/O header (J8)
5 6 PSoC 4200M (CY8C4247AZI-M485)
17
7 PSoC 4200M program and
16
6 debug header (J13)
15
7 8 Digilent® PmodTM compatible I/O
14
header (J16)
9 PSoC 4200M reset button
8 9 10 11 12 13
10 ArduinoTM compatible power header (J1)
11 RGB LED
12 User button
GND/GND
P1_7/AREF
P4_1/SDA
P6_2/D13
P6_1/D12
P6_0/D11
P2_7/D10
P4_0/SCL
P0_3/D9
P0_2/D8
P5_5/D7
P5_3/D6
P1_3/D5
P1_2/D4
P1_1/D3
P1_0/D2
P3_1/D1
P3_0/D0
NC
IOREF/P4_VDD
RESET/RESET
3.3 V/V 3.3
5 V/V 5.0
GND/GND
GND/GND
VIN/VIN
A0/P2_0
A1/P2_1
A2/P2_2
A3/P2_3
A4/P2_4
A5/P2_5
P0_0
P0_1
P0_7
Arduino Uno R3
PSoC 4 M-Series Pioneer Kit
Digilent Pmod
© 2015 - 2018 Cypress Semiconductor Corporation. All rights reserved. PSoC and CapSense are registered
trademarks of Cypress Semiconductor Corporation. Raspberry Pi is a trademark of the Raspberry Pi Foundation.
All other trademarks or registered trademarks referenced herein are the property of their respective owners.
001-95920 Rev.*F