Professional Documents
Culture Documents
Data Sheet 1
■ Dimensions ■ Packaging
Code Packaging Minimum Quantity
L 180mm Embossed Tape 500
1.85±0.15 K 330mm Embossed Tape 3000
5.87±0.2
5.2±0.2
1.2±0.2
1.6±0.2
(in mm)
<Rated Current>
(Based on Temperature Rise)
When Rated Current is applied to the Products,
self-generation of heat will rise to 40°C or less.
o This data sheet is applied for CHIP INDUCTORS (CHIP COILS) used for General Electronics equipment for your design.
! Note:
1. This datasheet is downloaded from the website of Murata Manufacturing co., ltd. Therefore, it’s specifications are subject to change or our
products in it may be discontinued without advance notice. Please check with our sales representatives or product engineers before ordering.
2. This datasheet has only typical specifications because there is no space for detailed specifications. Therefore, please approve our product
specifications or transact the approval sheet for product specifications before ordering.
2011.5.12
http://www.murata.com/
Inductors (Coils) > Chip Inductor (Chip Coil) > Power Inductor (Wire Wound Type)
Data Sheet 2
22 µH
22µH
10 µH
10 10
Inductance (µH)
Inductance (µH)
10µH 4.7 µH
4.7µH 2.2 µH
2.2µH
1 1 1.2 µH
1.2µH
0.1 0.1
0.1 1 10 100 10 100 1000 10000
Frequency (MHz) Current (mA)
40
Temperature Rise (°C)
2.2µH
30
1.2µH
20
10
0
0 500 1000 1500 2000 2500 3000
Current (mA)
■ !Caution/Notice
!Caution (Rating) Notice
Do not use products beyond the rated current as Solderability of Tin plating termination chip might be
this may create excessive heat. deteriorated when low temperature soldering profile
where peak solder temperature is below the Tin melting
point is used. Please confirm the solderability of Tin
plating termination chip before use.
o This data sheet is applied for CHIP INDUCTORS (CHIP COILS) used for General Electronics equipment for your design.
! Note:
1. This datasheet is downloaded from the website of Murata Manufacturing co., ltd. Therefore, it’s specifications are subject to change or our
products in it may be discontinued without advance notice. Please check with our sales representatives or product engineers before ordering.
2. This datasheet has only typical specifications because there is no space for detailed specifications. Therefore, please approve our product
specifications or transact the approval sheet for product specifications before ordering.
2011.5.12
http://www.murata.com/