Professional Documents
Culture Documents
MII
INSTALLATION QUICK SHIFTER
CRF1000A/A2 Issue Date
P/N 08U70-MKK-D00
INSTRUCTIONS March 2018
TORQUE CHART
Refer to the Service Manual for the torque values of the
removed parts.
TOOL BOX
BOLT
4-PIN WATERPROOF
CONNECTOR (Black)
SEAL (Save)
BOLT
4-PIN WATERPROOF
CONNECTOR (Black)
SEAL (Save)
GEAR CHANGE
PEDAL HARNESS
4-PIN WATERPROOF
CONNECTOR (Black)
ELECTRICAL TAPE
2 of 6
6. Install the gear change pedal as shown. 8. Install the bolts as shown.
BOLT (Reuse)
GEAR CHANGE PEDAL PUNCH MARK
BOLT (Reuse)
GREASE
Apply to the marked surfaces.
3 of 6
10. Secure the gear change switch harness with the wire 11. Secure the gear change switch harness with the wire
ties as shown. tie as shown.
•• Confirm that any wire harness is not caught or •• Do not cut the excess wire tie end.
too tight.
Store the end of wire tie in the gap as shown.
•• After installation, check the gear change
pedal harness not to interfere with the engine. WIRE TIE (short)
Secure the gear change pedal
harness to the motorcycle’s harness.
WIRE TIE (long)
Secure the gear change pedal
harness to the motorcycle’s harness.
GEAR CHANGE
PEDAL HARNESS
GEAR CHANGE
PEDAL HARNESS
GEAR CHANGE
GEAR CHANGE PEDAL HARNESS
PEDAL HARNESS
4 of 6
INITIALIZATION INSTRUCTIONS 6. The display shows the message the “ENGINE
1. Connect the SCS short connector (070PZ-ZY30100) START” then start the engine and let it idle.
to the DLC. •• Shift the transmission to the neutral position
2. Turn the ignition switch ON and engine stop switch then do not touch the pedal.
“ ”. •• Do not operate the throttle grip.
•• Do not start the engine.
3. Push and hold the MODE and SEL or SEL
switch.
SEL (UP) switch
MODE switch
Initialization completion
Initialization failure
NOTE:
•• For setting the UP LVL or DOWN LVL of the
Quick Shifter, refer to the Genuine Accessory
User’s Guide.
6 of 6