Professional Documents
Culture Documents
✔ ✔ RJ-11 RJ-11
w w w.apc.com
✔ USB RJ-45
✔ ✔
User’s Manual
✔
4 CONNECT EQUIPMENT / POWER 53 CHECK BUILDING WIRING 6 CONNECT PHONE/MODEM/FAX 8 CONNECT INTERFACE 10 ORIENTATION
FAULT INDICATOR Phone Jack CABLE
For connection of APC’s optional
If the rear panel Building Wiring Fault (red) external 24-volt battery pack
(BR24BP) to the Back-UPS RS/XS 1500.
indicator is lit, a potential shock hazard exists
due to one of the following conditions: Wall
Outlet
Printer or Scanner • Open or high resistance ground
SURGE ONLY FAX
• Hot or neutral polarity reversed TVSS GND To Computer USB
BATTERY BACKUP • Overloaded neutral circuit Port Data Port BR24BP Battery Pack
Improper building wiring should be USB RJ-45
corrected by a qualified electrician. Do not
use the Back-UPS until the condition that
✘ ✔ ✔
Computer
caused the fault is corrected. Modem/ Modem Port
Phone/Fax
External Disk or Note: Improper building wiring will not
CD / DVD Drive prevent the Back-UPS from operating, but it
will limit its protection capability. Computer
Circuit Breaker
Push to Reset Building Wiring Wall
Outlet
7 CONNECT 10/100 Base-T or VOIP
(Back-UPS RS models only)
9 SWITCH ON THE BACK-UPS
Fault Indicator Building Note: Allow the Back-UPS to charge for a full • When Self-Test has successfully completed,
Computer Wiring Fault
Wall eight (8) hours prior to use. only the green On Line indicator will be lit.
TVSS GND Outlet
Input: 120V~ Network Jack Press the front panel Power ON/OFF switch and • If the internal battery cartridge is not
12A, 60Hz observe that the following events occur after connected (see Step 2 above), the green On
pressing and releasing the switch: Line indicator and red Replace Battery
Modem/ indicators will light. The Back-UPS will also
Phone/Fax Computer • The green On Line indicator flashes.
• The yellow On Battery indicator lights while emit a chirping sound.
Network Port
10/100 Base-T
VOIP
a Self-Test is being performed.
Monitor
4. To select the Low Sensitivity setting, press the pushbutton until the yellow
indicator is flashing. Notice: This device complies with part 68 and 15 of the FCC rules.Operation is subject
5. To select the Medium Sensitivity setting, press the pushbutton until the yellow to the following two conditions: (1) This device may not cause harmful interference.
and red indicators (second and third from the top) are flashing. (2) This device must accept any interference received, including interference that may
6. To select the High Sensitivity setting, press the pushbutton until yellow and both cause undesired operation.
red indicators (bottom three) are flashing.
Battery 7. To exit without changing the Sensitivity Setting, press the pushbutton until the On the bottom of this equipment is a label that contains, among other information, the
Cartridge green indicator is flashing. FCC registration number and ringer equivalence number (REN) for this equipment. If
8. Once in Programming Mode, if the pushbutton is not pressed within 5 seconds, requested, this information must be provided to the telephone company.
the Back-UPS will exit Programming Mode; all indicators will extinguish.