You are on page 1of 1

BLAST CHECK LIST

DATE_20/2/16__ BLAST NUMBER_TAC 13/16 ______ TIME 12.00_________ NUMBER OF HOLES: __38____

LOCATION: _AREA C_____________ NO OF BLAST GUARD POSITION: ______2__________

AIR OVER PRESSURE: ___N/A_______________ GROUND VIBRATION:_______N/A______________

YES/NO

1. Was blast correctly posted on Blast Notice Board Y


2. Is Blast Guard in position at least 15 minutes before blasting time Y
3. Did blast controller confirm Load & haul personnel have been cleared N/A
N/A
4. Are all personnel cleared beyond 500m from the blast Y
5. Have all Drills and other equipment been cleared into safe zone Y
6 Did any equipment/installation required special protection N
7. Do blast guards have effective two-way radios and can communicate on a N
blast channel
8. Is radio communication clear and understood during blast N/A
9. Do Blast Guards know the Blast Guard Procedures Y
10. Does each Blast Guard have Blast signs in place Y
11. Are all possible entries effectively blocked to traffic by blast guard Y
12. Was radio silence observed during blasting N/A
13. Was siren run along the entire perimeter of the shot Y
14. Is weather condition safe for blasting to continue Y
15. Is blast close to any residence N
16. If yes have all vulnerable personnel been informed and evacuated N/A
17. Does the shot crew have assured means of clearing the shot when fuse is lit Y
18. Was any misfire observed during the inspection N
19. Did Blast Guards wait until dismissed by Blast controller before clearing their Y
road blocks
20. Any other deviation noted N
21. Were there any community concern N
22. Were Safety officer/s present before and during the blast Y

Remarks: The blast crew needs (2) two-way radio to be able to perform effective blast. Upon request of radios, the team
was given one which makes it impossible to use two-way during blast.

Inspection by: _Noble D. Tay________________________ Sign: ____________________________

You might also like