Professional Documents
Culture Documents
Assembly instructions
Brief introduction
E240 U.S. production type, rated power 200W, with ER11 collet
4,Backplane
8,Table plate
12,Workpiece plate
Assembly sequence
1 Part of screw of return difference eliminate
Put the Eliminate return difference spring rod insert eliminate return difference
nut plate.
Install Eliminate backlash nut under the plate into three axis’s
end of the rod and then put consumer backlash nut plate, with
one hand pressed both consumer backlash nut lock plate, tighten
the other hand in the case of compression springs into the screw,
mounted at the front of the base plate on the stand, if the screw
end load bearing difficulties, you can use emery cloth to screw
then tighten
while the vertical screw into the base plate screw bearings
NOTE: leave some space between the base plate and the screw
bearing front vertical plate. Because the thickness of the PVC sheet
is not very uniform, this gap is due to adjustment screw length error
then, install the coupling together with the motor base plate together
(stand).
Thus Y-axis (base) part had loaded it
3,X shaft portion
to the left vertical panel, note the screw bearings Installed on the
(vertical)
Another X-axis slide bearing plate mount light bar, and then loaded
fixed with a bearing cap, bearing the bearing cap fixed to the right of
bearing screw slightly cut off at some otherwise due to the length of
bearing
X-axis stepper motor also be Installed to the motor base plate
(horizontal), and then went to the right side together with the coupling
Installed vertical
board
First, the light bars Installed to the Z-axis Z screw bearing plate
(upper)
Two motors Installed upper the base plate (vertical)
Installed the the Z-axis screw, lead screw spindle motor base
plate and bearing plate
(under)
NOTE: leave some space between the screw bearing plate. Because
the thickness of the PVC sheet is not very uniform, this gap is due to
put this gap adjustment screw neither strings to move, they can be
Working table
Spindle motor is fixed by following these four screws
In this way, the whole assembly would be completed.