Professional Documents
Culture Documents
3. If distance of cg from datum is 160” and of leading edge of MAC is 140” and length of MAC is
100”. Find MAC %
a. 20%
b. 50%
c. 75%
4. If the input of half wave rectifier is 240 V and transformer has a step down ratio of 8:1, what is
the output rms value?
a. 42.2 V
b. 30V
5. Demultiplexer is
a. Output is same as multiplexer
b. Output is opposite of multiplexer
c. As in b CCU regulates in input and output
8. A metal which can be hammered, rolled, or pressed into various shapes without cracking,
breaking, or leaving some other detrimental effect, is said to be
a. Malleable
b. Ductility
12. MTCS
a. turboprop engine requires lengthy runway than piston engine of same power
b. turbojet has more weight than piston engine of same power
c. turbofan required short runway as compare to turbojet
d. all of the above
18. We can get vastly superior product than iron If carbon is added to iron, in percentages ranging
up to
a. Approximately 0.5 percent.
b. Approximately 1 percent.
c. If Nickel 3.50%, chromium 1.55% is present
19. Which resistor has the smallest possible size
a. Wire wound resistor
b. Carbon composition resistor
c. Surface mount resister
22. Stringers, bulkhead, skin, rivet and extruded section are made from
a. Cast aluminum alloy
b. Wrought aluminum alloy
c. Pure aluminum
24. Slots provided on the armature are not parallel but are staggered at an angle to provide
a. Safety
b. Reduce the humming noise
c. Stability.
d. …..
29. If the peak value is 100 volts then at an angle of 30˚ what is the instantaneous value
a. 50 V
b. 100 V
c. 150 V
d. 200 V
31 The type of torque wrench which has the ability to preset the torque
a) Deflecting beam b) rigid frame c) micrometer setting type
36 devices which make it possible to obtain more than one voltage from a single power source
a) Current divider
b) Potential divider
c) Resistance divider
d) All are correct
37 The property of a coil to oppose any change in the current flowing through it called
a) Inductance
b) Capacitance
c) Resistance
d) All of the above
45 what is an alternator
a) Ac current generator b) dc generator c)ac motor
47 CRT COLOUR
1. Red, green, blue
2. Yellow, red ,green
48 EICAS
1. Engine indicating and crew alerting system
49 RMS value in half wave is 10 amp, what will be the rms value if it is full wave rectified
1. 14.14 amp
2. 20/ amp
3. 40/ amp
51 Which type crack can be detected by MpI using either circular or longitudinal method?
1. 450
2. Longitudinal
3. Transever
52 What Al-alloy designation indicate that the metal has received no hardening or tempering
treatment
1. 3003-F
2. 5052-H36
3. 6061-0
53 What tasks are completed prior to weighing an a/c to determine its empty wt?
1. Remove all items except those on a/c equipment list, drain fuel and hydraulic fluid
2. Remove all items on a/c equipment list, drain fuel, compute oil and hydraulic fluid lot
3. Remove all items except those on a/c equipment list, drain fuel and fill hydraulic
reservoir
67 In orthographic projection
1. Eight veiws are common
2. Two vines are common
3. One view, two view and three views are common
72 8085 microprocessor
a) Direct register
73 8085 microprocessor
74 materials such as magnesium and eureka when temperature increases its resistence
a) Its resistance increases linearly with temperature
b) Its resistance decreases with temperature
c) Increases
d) Fairly constant over considerable range of temperature
93) When the a/c towed in uneven surface where should the tow bar be connected
-----------------------------------X-----------------------------X------------------------------X------------------------------