Professional Documents
Culture Documents
EQUIPMENT ID NUMBER(S) EQUIPMENT DESCRIPTION EQPT CODE SYSTEM ID. PLANT NO.
LAYOUT DRAWING NUMBER REV. NO. PURCHASE ORDER NUMBER EC / PMCC / MCC NO.
SCHEDULED INSPECTION DATE & TIME ACTUAL INSPECTION DATE & TIME QUANTITY INSP. MH's SPENT TRAVEL TIME
SAUDI ARAMCO USE ONLY
SAUDI ARAMCO TIP NUMBER SAUDI ARAMCO ACTIVITY NUMBER WORK PERMIT REQUIRED?
ITEM
ACCEPTANCE CRITERIA REFERENCE PASS FAIL N/A RE-INSP DATE
No.
A. General Requirements
Soft foot check is done with piping disconnected on each equipment foot. API 686,
A1 Note: Maximum permissible movement is 0.05 millimeter (2 mils) at each Chapter 7,
foot, or as specified by Manufacturer. Para. 5.4.4.1
API 686,
A2 Fixed and movable equipment shall be free to turn. Chapter 7,
Para. 5.4.4.1
Data of alignment are recorded in SATR-G-2004 or approved equivalent
A3 Contractor QP
alignment form.
Provisions are made for doweling the pump and drive components to the
31-SAMMS-004,
A4 baseplate. Note: Dowels are furnished by the Vendor, but installed in the
Para. 3.3.21
field at the time of final alignment.
For all pumps, 3 mm (1/8 in) thick stainless steel shim packs shall be 31-SAMMS-004,
A5
furnished. Para. 3.3.4
API 686,
The maximum allowable number of shims under any equipment support
A6 Chapter 7,
foot is five.
Para. 5.4.2.1
API 686,
Alignment is within the Manufacturer's tolerances before pipes and
A7 Chapter 7,
conduit attached.
Para. 5.4.5
API 686,
Pipe strain checks have been made in accordance with the
A8 Chapter 7,
manufacturer's procedures.
Para. 5.4.5
API 686,
Alignment is within the Manufacturer's tolerances after pipes and conduit
A9 Chapter 7,
attached.
Para. 5.4.5
REMARKS:
REFERENCE DOCUMENTS:
1. 31-SAMSS-004, Centrifugal Pumps, (30 September, 2003)
2. API 686, Recommended Practice for Machinery Installation and Installation Design, (First Edition, April 1996)
Page 1 of 1